Megamaster 720-0905D Assembly & Operating Instructions

Megamaster 720-0905D Assembly & Operating Instructions

Evolution 3 burner with side burner

Advertisement

Quick Links

EVOLUTION 3 BURNER
WITH SIDE BURNER
ASSEMBLY & OPERATING
INSTRUCTIONS
LPGSASA Permit Number (1185-74/1-RSA-147-A)
This instructions manual contains important information necessary
for the proper assembly and safe use of the appliance.
Read these instructions and warnings carefully so as to familiarize
yourself with the appliance before connecting it to its gas
container.
Keep this manual for future reference.
1
MODEL NO. 720-0905D
Questions, problems, missing
parts? Before returning to your
retailer, call our Customer Service
Department at Tel: (010) 001 6342,
8 a.m. - 5 p.m., CAT, Monday-
Friday. Or send us an E-mail at
service@megagroup.co.za. Visit us
online at: www.megamaster.co.za

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 720-0905D and is the answer not in the manual?

Questions and answers

Summary of Contents for Megamaster 720-0905D

  • Page 1 Questions, problems, missing parts? Before returning to your retailer, call our Customer Service Department at Tel: (010) 001 6342, 8 a.m. - 5 p.m., CAT, Monday- Friday. Or send us an E-mail at service@megagroup.co.za. Visit us online at: www.megamaster.co.za MODEL NO. 720-0905D...
  • Page 2 BUT THAT’S NOT WHERE IT BELONGS We get it. You’ve just unboxed your Megamaster Patio Gas braai Braai and you can’t wait to fire it up. Those steaks, fish, vegetables and everything else you could possibly imagine certainly aren’t going to braai themselves.
  • Page 3: Table Of Contents

    TABLE OF CONENTS Gas Hookup Instructions... . Safety Warnings ....Leak Test Instructions ... . . Braai Clearance Information .
  • Page 4: Braai Clearance Information

    BRAAI USAGE INFORMATION DANGER Never use your gas braai in a garage, porch, shed, or any other enclosed area. DO NOT use this appliance under overhead combustible surfaces. Do not install this unit in combustible enclosures. The minimum air space clearance from sides and back of unit to combustible construction is 36 in.
  • Page 5 GAS HOOKUP WARNINGS WARNING Do not try lighting this appliance without reading the “LIGHTING INSTRUCTIONS” section of this manual. BRAAI INSTALLATION 1. Check your local building codes for the proper method of installation. In the absence of local codes, this unit should be installed in accordance with the South African National Standard 1539, Storage and Handling of Liquefied Petroleum Gases, Correct LP Gas Cylinder Use.
  • Page 6: Operation Warnings

    OPERATION WARNINGS SAFETY PRACTICES TO AVOID PERSONAL INJURY When properly cared for your braai will provide safe, reliable service for many years. However, extreme care must be used as the braai produces intense heat that can increase risk of injury. When using this appliance basic safety practices must be followed, including the following: •...
  • Page 7: Lp Gas Supply Safety

    LP GAS SUPPLY SAFETY • If this information is not followed exactly, a fire • When your gas braai is not in use the gas must resulting in death or serious injury could occur. be turned off at LP gas cylinder. •...
  • Page 8 NOW THAT WE GOT ALL THE SAFETY INFORMATION OUT OF THE WAY, LET’S START WITH SOME ELBOW GREASE!
  • Page 9: Package Parts List

    PACKAGE PARTS LIST...
  • Page 10 PACKAGE PARTS LIST...
  • Page 11 PACKAGE PARTS LIST...
  • Page 12 PACKAGE PARTS LIST...
  • Page 13: Tools Needed

    TOOLS NEEDED TOOLS NEEDED Some parts come with Screws pre- installed. Loosen and tighten for final assembly. HARDWARE PACK LIST Flat Head Screw Truss Head Screw Truss Head Screw Flat Washer 5/32-32x 2/5 " 1/4-20 x 3/5 " 5/32-32x 2/5 " 1/4"...
  • Page 14: Assembly Instructions

    ASSEMBLY INSTRUCTIONS...
  • Page 31: Gas Hookup Instructions

    GAS HOOK-UP INSTRUCTIONS NEVER CONNECT AN UNREGULATED GAS SUPPLY LINE TO THE APPLIANCE. USE THE REGULATOR/HOSE ASSEMBLY SUPPLIED. This is a LP Gas configured braai. Do not attempt to use a natural gas supply unless the braai has been reconfigured for natural gas use. Total gas consumption (per hour) of this stainless steel gas braai with all burners on “HIGH”: Main burner - 13,500 Btu/hr.
  • Page 32: Leak Test Instructions

    LEAK TEST INSTRUCTIONS GENERAL Although all gas connections on the braai are leak tested at the factory prior to shipment, a complete gas tightness check must be performed at the installation site due to possible mishandling in shipment, or excessive pressure unknowingly being applied to the unit. Periodically check the whole system for leaks following the procedures listed below.
  • Page 33 We feel much better knowing you’re safer for having taken the time to go through that first section thoroughly. Now, let’s get on with putting your Megamaster braai together so you can unleash your inner kebab/ pesto mushrooms / gourmet boerie roll...
  • Page 34 BRAAI IGNITION INSTRUCTIONS CAUTION: DO NOT LEAVE THE BRAAI UNATTENDED WHILE COOKING. USING THE BRAAI Each main burner is rated at 13,500 Btu/hr. The main braai burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. The igniter knobs are located on the lower center portion of the valve panel.
  • Page 35: Ignition Instructions

    IGNITION INSTRUCTIONS FLAME CHARACTERISTICS 1. Check for proper burner flame characteristics. 2. Burner flames should be blue and stable with no yellow tips, excessive noise, or lifting. If any of these conditions exist call our customer service line. If the flame is yellow, this is a indication of insufficient air.
  • Page 36: Care And Maintenance

    CARE AND MAINTANENCE STAINLESS STEEL There are many different stainless steel cleaners available. Always use the mildest cleaning procedure first, scrubbing in the direction of the grain. Do not use steel wool as it will scratch the surface. Specks of grease can gather on the surfaces of the stainless steel and bake on to the surface and give the appearance of rust.
  • Page 37: Troubleshooting Guide

    TROUBLESHOOTING GUIDE PROBLEM SOLUTION Make sure you have a spark while you are trying to light the burner (if no spark) . Check if the battery is installed properly. Ensure that the wire is connected to the electrode assembly. When attempting to light my Clean wire (s) and / or electrode with rubbing alcohol and a clean braai, it will not light swab.
  • Page 38: Burner Replacement

    MAIN BURNER REPLACEMENT WARNING: If you wish to replace the main burner, we strongly recommend that you hire a professionally trained technician to replace it. Please understand that we will not be responsible for any liability, personal injury, or property damage resulting from an improperly assembled burner. HOW TO REPLACE THE MAIN BURNER 1.
  • Page 39: Parts Diagram

    PARTS DIAGRAM...
  • Page 40 PARTS LIST Warranty Warranty Part (Description) coverage Part (Description) coverage (year) (year) Infrared PLUS™ heat plate A Main lid Infrared PLUS™ heat plate B Main lid screw Hood buffer A Cooking grid A Temperature gauge Cooking grid B Logo Side burner cooking grid Lid handle Side burner igniter wire Side shelf, left...
  • Page 41: Warranty

    WARRANTY The manufacturer warrants to the original consumer-purchaser only that this product (Model #720-0905D) shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer reserves the right to require photographic evidence of damage, or that defective parts be returned, postage and/or freight pre-paid by the consumer, for review and examination.
  • Page 42 THANK YOU. You are now a Megamaster manual pro! Get out there and enjoy making your braaing experience even better. For great inspiration and recipes to use your braai, check out the recipe pages on our website www.megamaster.co.za Finally, don’t forget to keep this manual in a safe place for future reference.

This manual is also suitable for:

1185-741-rsa-147-a

Table of Contents