Related Manuals for Bad Boy BB25
Summary of Contents for Bad Boy BB25
- Page 1 OPERATOR’S MANUAL Bad Boy 25" Push Mower Model: BB25 - Kawasaki Operator’s Manual Read these instructions carefully and make sure you understand them before using the Bad Boy Push Mower. Rev. 4/2016...
-
Page 2: I Ntroduction, Personal Safety
If you have further questions you can contact - Bad Boy Mowers, by writing or calling, see information below. Bad Boy Mowers, will willingly be of service and provide you with advice as well as help you to use your product both efficiently and safely. -
Page 3: Registration Of The Product
85 dB(A). Use hearing protection. REGISTER THE PRODUCT Please register your new Bad Boy Push Mower by mailing in a copy of this page together with a copy of your mower invoice/receipt. Registration will allow us to contact you in case of any critical updates or recalls on this machine. -
Page 4: Table Of Contents
Always wear approved personal safety equipment such as hearing protection, eye protection, and protective gloves when operating machine. See manufacturer’s instructions for proper operation and installation of accessories. Only use accessories approved by Bad Boy Mowers or the engine manufacturer. -
Page 5: Lawn Mower Safety
8. Check grass catcher components and the rear discharge IV. SAFE HANDLING OF GASOLINE: door frequently and replace only with Bad Boy Mowers original To avoid personal injury or property damage, use extreme care parts when necessary. -
Page 6: Decals And Locations
DECALS AND LOCATIONS These labels warn you of potential hazards that can cause serious injury. Carefully read and understand them. If a label comes off or becomes hard to read, contact Bad Boy Mowers immediately for a free replacement. Part #: 201155-1... -
Page 7: Assembly - Setup
Engine Owner’s Manual and Warranty Statement BB25 Operator’s Manual. NOTICE: If you are missing any of these items or if you are unsure of how to properly assemble this mower please contact Bad Boy Mowers by phone: (866) 622-3269 10 mm 10 mm... -
Page 8: Recommended Engine Oil
Install the blade brake control cable in the upper control bar. Note that there are three holes for the control cable . All BB25 models uses the BBC hole position (1). Pull on the cable sheath and insert into the upper hole (2) of the handle bracket. -
Page 9: Recommended Fuels
ASSEMBLY - SETUP STEP 9 Before fi lling the engine with gasoline - follow all instructions in this manual as well as all instructions provided in the Kawasaki Owner’s Manual. Maximum fi ll volume: Kawasaki: 1.9 Qt (1.8 Liter) - 87 octane or higher The engine will not operate on gasoline marketed as E-85 (85% ethanol) APPROVED FUEL... -
Page 10: Controls And Operation
A simple test to verify the BBC function is to install an empty - Step 7 on Page 8 or 9. A Bad Boy Mower dealer can typically also verify the correct grass collection bag. The mulch plug should not be installed. - Page 11 Due to wear, the drive engagement position of the lower 1 With a grass catcher in place An original equipment Bad Boy Mower catcher has been control bar can change. If the distance between the lower bar and the handle (2) is less than a 1/4 inch when the mower tested to be used with this mower.
-
Page 12: Maintenance
MAINTENANCE Maintenance - Procedures Service Interval Before each use Check the engine oil level. Check the operation and integrity of the BBC control system (see page 10). Inspect the mower blade for wear or damage. Inspect the cables for any wear or damage. Inspect the grass catcher for any damage. -
Page 13: Blade Maintenance
A blade carburetor are up). balance tool is available from Bad Boy Mowers or most lawn 3. Use a wood block between blade and mower deck to and garden dealers, and hardware stores. -
Page 14: Blade Brake Clutch Cable Adjustment
MAINTENANCE BLADE BRAKE CLUTCH CABLE ADJUSTMENT It is recommended that the adjustment of the Blade Brake Clutch (BBC) cable is checked at the minimum every 50 Hours or within each 4 weeks of operation. If not properly adjusted the brake might not work as designed. This adjustment pertains to a belt that has been used a minimum of 2 hours. -
Page 15: Warranty
WARRANTY STATEMENT All Bad Boy Push Mowers can be registered for warranty by mailing copy of the warranty registration in this manual with a copy of the sales invoice/receipt to: Bad Boy Inc, Attention: Warranty Department, 102 Industrial Dr, Batesville, AR 72501...
Need help?
Do you have a question about the BB25 and is the answer not in the manual?
Questions and answers