Crystal Clean 2740 Operating Manual

Aqueous combination unit

Advertisement

MODEL 2740
Aqueous Combination Unit
Operating Manual
Heritage-Crystal Clean, LLC 2000 Center Drive, Suite East C300 Hoffman Estates, IL 60192 877-938-7948

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 2740 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Crystal Clean 2740

  • Page 1 MODEL 2740 Aqueous Combination Unit Operating Manual Heritage-Crystal Clean, LLC 2000 Center Drive, Suite East C300 Hoffman Estates, IL 60192 877-938-7948...
  • Page 2 Some improvements may have been made after this manual was printed. For the latest information on your equipment, contact your HCC representative. Heritage-Crystal Clean, LLC 2000 Center Drive, Suite East C300 Hoffman Estates, IL 60192 877-938-7948...
  • Page 3: General Instructions

    11. Use only as described in this manual. Use only manufacturer’s recommended attachments. 12. The ambient air temperature should not be below 40F or above 105F. 13. Do NOT modify these machines. “SAVE THESE INSTRUCTIONS” Heritage-Crystal Clean, LLC 2000 Center Drive, Suite East C300 Hoffman Estates, IL 60192 877-938-7948...
  • Page 4: Safety Instructions

    In the event that the lid is lifted mid-cycle, the limit switch will cease all operation of the turntable and pump. NEVER Modify or defeat the limit switch. An unsafe condition may occur if any unauthorized changes are made. Heritage-Crystal Clean, LLC 2000 Center Drive, Suite East C300 Hoffman Estates, IL 60192 877-938-7948...
  • Page 5: Installation

    MODEL 2740 INSTALLATION The 2740 is a high capacity, compact footprint, and self-contained parts washer. The only external hookup is a 220VAC, 1PH, 24A minimum dedicated electrical supply line. Floor plan layout should include adequate access for maintenance, service, and repair. Vertical clearance should allow full opening and closing of the lid without obstruction.
  • Page 6: Electrical Specifications

    FLA: 6.5A ELECTRICAL HOOK-UP The 2740 comes fully wired with plug in the 6-50P configuration. The voltage, phase, and current draw of the machine are listed above and on the serial number plate. The wiring diagram is listed below in this manual.
  • Page 7 Heritage-Crystal Clean, LLC 2000 Center Drive, Suite East C300 Hoffman Estates, IL 60192 877-938-7948...
  • Page 8 SWING AWAY SPRAY BAR Swing Away Spray Bar • Overhead load friendly • Large object friendly • Can move either direction to be completely clear of the turntable area Heritage-Crystal Clean, LLC 2000 Center Drive, Suite East C300 Hoffman Estates, IL 60192 877-938-7948...
  • Page 9: Electrical Instructions

    To avoid personal injury or damage to equipment we recommend this unit be installed by a qualified electrician. Crystal Clean assumes no responsibility for damage caused by improper installation. Heritage-Crystal Clean, LLC 2000 Center Drive, Suite East C300 Hoffman Estates, IL 60192 877-938-7948...
  • Page 10 • Very small parts may need to be contained within their own basket or mesh container to prevent them from falling through the turntable grate and to keep them from getting blown off the turntable by the washer spray. Heritage-Crystal Clean, LLC 2000 Center Drive, Suite East C300 Hoffman Estates, IL 60192 877-938-7948...
  • Page 11 Use an air blow off gun to make sure all filter holes are clean. Give the filter a final rinse, then reinstall the filter tube. Heritage-Crystal Clean, LLC 2000 Center Drive, Suite East C300 Hoffman Estates, IL 60192 877-938-7948...
  • Page 12 The maximum detergent level is at this marker. Maintain level at this marker. Low level is 1 to 1-1/2” below the marker. Heritage-Crystal Clean, LLC 2000 Center Drive, Suite East C300 Hoffman Estates, IL 60192 877-938-7948...
  • Page 13 Heritage-Crystal Clean, LLC 2000 Center Drive, Suite East C300 Hoffman Estates, IL 60192 877-938-7948...
  • Page 14: Troubleshooting Checklist

    MODEL 2740 TROUBLESHOOTING CHECKLIST MACHINE RETURN FORMS ARE MANDATORY Heritage-Crystal Clean, LLC 2000 Center Drive, Suite East C300 Hoffman Estates, IL 60192 877-938-7948...

Table of Contents