Page 1
Operation and Maintenance Manual Sweeney Digital Turning Tool (DTT) Model No. SWE189DTTC-NBT (Pratt & Whitney PWA64005) Document Number: L4554 Document Revision: D Issue Date: May, 2021 Language: English To reduce the risk of injury, user must read and understand this document before use.
Page 2
Enerpac for quality tools, services and solutions. For additional information, visit www.enerpac.com. WARRANTY Refer to the Enerpac Global Warranty document for terms and conditions of the product warranty. Such warranty information can be found at www.enerpac.com. NAMEPLATE Refer to the controller nameplate for the product model number, serial number and other applicable information.
CONTENTS PAGE SAFETY ..............................4 COMPLIANCE ............................6 SPECIFICATIONS AND PRODUCT DATA ....................7 DESCRIPTION ............................11 FEATURES AND COMPONENTS ......................12 POWER REQUIREMENTS ........................15 SET UP ..............................15 TURNING TOOL INSTALLATION ......................18 PENDANT SCREENS OVERVIEW ......................18 10.0 BEGINNING THE INSPECTION ......................
/ or damage to other property. placing it into operation. If any problems are found, Enerpac cannot be responsible for any damage or injury do not use the tool. from unsafe use, lack of maintenance, or incorrect 1.2 Electrical Shock Hazards...
Page 5
1.4 Grounding Instructions • If the tool is to be operated outdoors and an extension cord is needed, use only an outdoor use extension cord. An outdoor use extension cord will be clearly WARNING marked with the suffix letter “W” and the statement Failure to observe the following instructions and “Suitable for Use with Outdoor Appliances”.
2.1 Compliance Statement Sweeney Digital Turning Tool Model SWE189DTTC-NBT Enerpac declares that the Sweeney Model SWE189DTTC- NBT Digital Turning Tool (DTT) has been tested, conforms to applicable standards and is approved to carry the CE, CSA and FCC certification marks.
10 Amps UL 2054 & IEC 62133 certified Rating (rechargeable) Quantity: 2 NOTE: Mains supply voltage should be within ± Enerpac Part No. SWE189DTTAK10 10% of the rated voltage. 3.3 Additional Specifications Item Specification (all models) Pollution Degree Installation Category...
Page 8
3.5 Dimensions - Controller and Drive Motor Dimension 9.93 252.2 4.79 121.8 5.76 146.2 6.55 166.4 CONTROLLER 9.43 239.4 3.13 79.4 3.13 79.4 Dimension 20.0 DRIVE MOTOR L4554_d...
Page 9
3.6 Dimensions - Pendant and Foot Pedal Dimension 8.99 228.3 3.90 99.0 2.52 64.1 3.52 89.5 2.63 66.7 0.79 20.0 PENDANT Dimension 16.0 20.0 FOOT PEDAL L4554_d...
Page 10
3.7 Dimensions - Transport Case (Travel Size) Dimension 21.96 557.8 13.97 354.8 8.85 224.8 L4554_d...
4.0 DESCRIPTION The Sweeney Digital Turning Tool (DTT) provides a highly accurate way of rotating components of a turbine engine to facilitate inspection of the engine with the use of a borescope. The system controls a motor and gear assembly that turns the turbine engine at a controlled rate of rotation by a controlled number of degrees forward or reverse to position engine turbine blades for inspection by the operator.
5.0 FEATURES AND COMPONENTS Key: NEMA C14) 4. AC Power Inlet Connector ( 1. Pendant USB Connection 2. Drive Motor Cable Connector 5. Power On-Off Switch and Circuit Breaker 3. Foot Pedal Cable Connector 6. Power Indicator Light Figure 2: Controller L4554_d...
Page 13
Key: 1. Adjustable Clip 2. LCD Screen Display 3. Function Buttons 4. Up Arrow Button 5. Flag Button 6. Counter-Clockwise (CCW) Rotation Button 7. Clockwise (CW) Rotation Button 8. Down Arrow Button 9. Stop Button 10. Pendant On-Off Button 11. Wrist Strap 12.
Page 14
prevent damage NOTICE controller electrical circuits, be sure power switch is in the OFF ( o ) position before connecting or disconnecting drive motor cable. Figure 4: Drive Motor and Connecting Cable Figure 5: Foot Pedal Figure 6: Transport Case L4554_d...
Shipping damage is not The top of the controller features unique connectors to covered by the Enerpac warranty. ensure that the drive unit, foot pedal, AC power cord and pendant are connected in the proper locations.
Page 16
At the drive motor end, connect the drive motor cable Connect the AC power cord to the controller power by aligning the bosses with the notches and pushing inlet connection and to an electrical power source of the male connector into the female connector. With the correct specifications.
Page 17
7.4 Powering Up To power-up the controller: Press the ON ( ) half of PAIRING PENDANT the power switch located on the top of the controller. The controller power indicator will illuminate with a white light, indicating that the unit is on. Searching for controller To power-up the pendant: Press and hold the power button on the side of the pendant housing until the...
9.1 Splash Screen EXIT Upon successful calibration of backlash, a splash screen will display the Enerpac logo as well as the current firmware version of the tool. To install the drive motor on the engine interface adaptor, first line up the square drive and the flange bolt pattern.
Page 19
9.2 Main Menu 9.2.7 Set Blade To set the blade one position, select this option. Blade 1 The main menu contains user adjustable settings which must be set in order to track blade numbers on the allow the user to tailor the DTT to specific engine rotation pendant screen.
9.3.5 Reset Blade 1 • If in manual mode, press and hold the CW or CCW button to start rotating the engine. Release the Press to reset the Blade 1 position. To set blade one from button to make the engine come to a controlled stop. the main menu, highlight “Blade 1”...
Run time between battery charges is dependent on the To ensure compatibility and proper operation, use only application, pendant run time, and other factors. the correct replacement batteries (Enerpac part no. A low battery alert will appear if the battery charge drops SWE189DTTAK10) obtained from an authorized Enerpac to about 10 percent of maximum charge.
If the circuit breaker trips repeatedly, a serious electrical problem may be present. If this occurs, immediately discontinue use of the digital turning tool and take it to an Enerpac Authorized Service Center for diagnosis and repair. NOTICE If the circuit breaker trips and the “lost signal”...
The information in the Troubleshooting Guide is intended as an aid to help diagnose and correct various possible problems that may occur. For repair service, contact your nearest Enerpac Authorized Service Center. Only an Enerpac Authorized Service Center should be permitted to service the DTT and its components.
Troubleshooting Guide (continued) Problem Possible Cause Action 5. Blade number displays a “?” Blade 1 is not set. Reset blade in the main menu. FLAG REVIEW JT8D-200(H) HPC7 GOTO DIRECTION: MODE: AUTO START INSPECTION MENU 6. Motor is Disconnected screen appears: Drive motor cable is not Be sure that the drive motor cable is properly connected.
18.0 REPLACEMENT PARTS LIST The following parts list is applicable to the Sweeney Digital Turning Tool, model SWE189DTTC-NBT (Pratt & Whitney PWA64005). Components listed are available to order as individual items should a replacement be required in the event of malfunction or loss.
Page 26
Replacement Parts List (continued) Item Description Part Number Image Drive Motor Cable SWE189DTTAK5 Foot Pedal Assembly SWE189DTTAK6 Transport Case SWE189DTTAK7 Drive Motor SWE189DTTAK8 Pendant Batteries SWE189DTTAK10 (quantity 2) L4554_d...
Need help?
Do you have a question about the SWE189DTTC-NBT and is the answer not in the manual?
Questions and answers