Table of Contents
Advertisement
Quick Links
Save these instructions. This manual will help you to obtain
efficient, dependable service from the heater, and enable
you to order repair parts correctly. Keep in a safe place for
future reference.
SAFETY NOTICE:
If this heater is not properly installed, a house fire may result.
For your safety, follow the installation instructions. Never
use make-shift compromises during the installation of this
heater. Contact local building or fire officials about permits,
restrictions and installation requirements in your area.
Please read this entire manual before you install or use your
new room heater. Failure to follow instructions may result in
property damage, bodily injury, or even death. Improper
Installation Could Void Your Warranty!
All manuals and user guides at all-guides.com
MODEL: AW2020E
CAUTION!
United States Stove Company
PO Box 151, 227 Industrial Park Rd.,
South Pittsburg, TN 37380
PH: (800) 750-2723
www.usstove.com
Report Number: F19-476
Certified to: UL 1482-2011 (R2015) and
ULC-S627-00 (R2016)
Mobile home approved (U.S. ONLY)
U.S. Environmental Protection Agency
Ce produit peut vous exposer à des agents chimiques, y compris au monoxyde de
Certified to comply with 2020 particulate
carbone, lesquels sont reconnus dans l'État de la Californie comme causant le cancer et
emissions standards.
des malformations congénitales ou autres dommages au fœtus. Pour obtenir plus de
renseignements, veuillez consulter le site www.P65warnings.ca.gov
CALIFORNIA PROPOSITION 65 WARNING:
This product can expose you to chemicals including carbon monoxide, which
is known to the State of California to cause cancer, birth defects and/or other
reproductive harm. For more information, go to www.P65warnings.ca.gov
R
853576B-4203i
Advertisement
Table of Contents
Related Manuals for United States Stove Ashley AW2020E
Summary of Contents for United States Stove Ashley AW2020E
- Page 1 State of California to cause cancer, birth defects and/or other Installation Could Void Your Warranty! reproductive harm. For more information, go to www.P65warnings.ca.gov United States Stove Company PO Box 151, 227 Industrial Park Rd., South Pittsburg, TN 37380 PH: (800) 750-2723 www.usstove.com...
- Page 2 All manuals and user guides at all-guides.com The instructions pertaining to the installation of your wood stove comply with UL-1482 (R2015) and ULC-S627 standards. This manual describes the installation and operation of the Ashley, AW2020E wood heater. This heater meets the 2020 U.S. Environmental Protection Agency’s cordwood emission limits for wood heaters sold after May 15, 2020.
-
Page 3: Tools And Materials Needed For Installation
All manuals and user guides at all-guides.com Assembly Instructions TOOLS AND MATERIALS NEEDED FOR INSTALLATION You will need a drill with a 1/8” bit to install sheet metal screws into connector pipe. A 5/16” socket/wrench or screw driver to install the room air deflector, and blower assembly described. A 1/2” socket/wrench to install flue collar. -
Page 4: Installation
All manuals and user guides at all-guides.com Installation SAFETY NOTICE • IF THIS STOVE IS NOT PROPERLY INSTALLED, A HOUSE FIRE MAY RESULT. TO REDUCE THE RISK OF FIRE, FOLLOW THE INSTALLATION INSTRUCTIONS. • CONSULT YOUR MUNICIPAL BUILDING DEPARTMENT OR FIRE OFFICIALS ABOUT PERMITS, RESTRICTIONS AND INSTALLATIONS REQUIREMENTS IN YOUR AREA. -
Page 5: Clearances To Combustibles
All manuals and user guides at all-guides.com CLEARANCES TO COMBUSTIBLES It is of utmost importance that the clearances to combustible materials be strictly adhered to during installation of the stove. Refer to the tables below. Single Wall Pipe (Double Wall Pipe) 15 (12) 381 (305) 18 (18) - Page 6 All manuals and user guides at all-guides.com For use in MOBILE HOMES (U.S. installations ONLY): • WARNING! DO NOT INSTALL IN SLEEPING ROOM. • CAUTION! THE STRUCTURAL INTEGRITY OF THE MOBILE HOME FLOOR, WALL, AND CEILING/ROOF MUST BE MAINTAINED. • INSTALL IN ACCORDANCE WITH 24 CFR, PART 3280 (HUD). •...
-
Page 7: Chimney Connector (Stove Pipe)
All manuals and user guides at all-guides.com CHIMNEY CONNECTOR (STOVE PIPE) The chimney connector and chimney must have the same diameter as the stove outlet (6”). If this is not the case, we recommend you contact your dealer to ensure there will be no problem with the draft. -
Page 8: Factory Built Chimney
All manuals and user guides at all-guides.com FACTORY BUILT CHIMNEY When a metal prefabricated chimney is used, the manufacturer’s installation instructions must be followed. You must also purchase (from the same manufacturer) and install the ceiling support package or wall pass-through and “T” section package, firestops (where needed), insulation shield, roof flashing, chimney cap, etc. -
Page 9: Combustible Wall Chimney Connector Pass-Throughs
All manuals and user guides at all-guides.com COMBUSTIBLE WALL CHIMNEY CONNECTOR PASS-THROUGHS METHOD A - 12” (304.8 mm) Clearance to Combustible Wall Le dégagement minimum de la cheminée à la brique et les Member: Using a minimum thickness 3.5” (89 mm) brick matériaux combustibles est de 5 cm (2 po) (50,8 mm) and a 5/8”... -
Page 10: Operation
All manuals and user guides at all-guides.com Operation WOOD STOVE UTILIZATION The operation of this wood heater in a manner inconsistent with the owner’s manual will void your warranty and is also against federal regulations. This heater is designed to burn natural wood only. Higher efficiencies and lower emissions generally result when burning air dried seasoned hardwoods, as compared to softwoods or too green or freshly cut hardwoods. -
Page 11: Operational Tips
All manuals and user guides at all-guides.com It is EXTREMELY IMPORTANT to use DRY WOOD only in your wood stove. The wood should have dried for 9 to 15 months, such that the humidity content (in weight) is reduced below 20% of the weight of the log. It is very important to keep in mind that even if the wood has been cut for one, two or even more years, it is not necessarily dry, if it has been stored in poor conditions. - Page 12 All manuals and user guides at all-guides.com negative pressure in the house. If such is the case, open a window slightly near the stove and twist together a few sheets of newspaper into a torch. Light up this paper torch and hold it as close as possible to the mouth of the pipe inside the combustion chamber to warm up the chimney.
-
Page 13: Creosote Formation And Need For Removal
All manuals and user guides at all-guides.com RELOADING Once you have obtained a good bed of embers, you should reload the unit. To do so, open the air controls to maximum a few seconds before opening the stove’s door. Then proceed by opening the door very slowly; open it one or two inches for 5 to 10 seconds, before opening it completely to increase the draft and thus eliminate the smoke which is stagnant in a state of slow combustion in the stove. -
Page 14: Maintenance
All manuals and user guides at all-guides.com Maintenance Your wood stove is a high-efficiency stove and therefore requires little maintenance. It is important to perform a visual inspection of the stove every time it is emptied, to ensure that no parts have been damaged, in which case repairs must be performed immediately. -
Page 15: Repair Parts
All manuals and user guides at all-guides.com Repair Parts Part No. Description Qty. 40292A 6” Flue Collar 88042 Rope Gasket 1/4” 25845 Air Deflector 891492 Blower Assembly (B36) 26060 Rear Shield 610926 Rear Ashpan (AW2020E-BP) 29068 Pedestal (AW2020E-BP) 29065 Pedestal Front (AW2020E-BP) 610922 Pedestal Weldment... - Page 16 All manuals and user guides at all-guides.com Repair Parts Part No. Description Qty. 88316 Kao Wool Blanket 88146 Ceramic Fiber Board 86953 Secondary Air Tube (Ø1/8) 86952 Secondary Air Tube (Ø11/64) 29039 Brick Retainer (left) 29040 Brick Retainer (right) 40561 Ash Plug 24103A Half Pumice Firebrick (4-1/2 X 4-1/2)
- Page 17 All manuals and user guides at all-guides.com Notes...
- Page 18 All manuals and user guides at all-guides.com Notes...
-
Page 19: Service Record
All manuals and user guides at all-guides.com Service Record It is recommended that your heating system is serviced regularly and that the appropriate Service Interval Record is completed. SERVICE PROVIDER Before completing the appropriate Service Record below, please ensure you have carried out the service as described in the manufacturer’s instructions. - Page 20 2. The PART DESCRIPTION / UNE DESCRIPTION DE LA PIÈCE ________________________ 3. The MODEL NUMBER / LE NUMÉRO DE MODÈLE ________________________________ 4. The SERIAL NUMBER / LE NUMÉRO DE SÉRIE ____________________________________ United States Stove Company PO Box 151, 227 Industrial Park Rd., South Pittsburg, TN 37380 PH: (800) 750-2723 www.usstove.com...
- Page 21 All manuals and user guides at all-guides.com...
- Page 22 All manuals and user guides at all-guides.com...
- Page 23 All manuals and user guides at all-guides.com...
- Page 24 All manuals and user guides at all-guides.com...
- Page 25 All manuals and user guides at all-guides.com...
- Page 26 All manuals and user guides at all-guides.com...
- Page 27 All manuals and user guides at all-guides.com...
- Page 28 All manuals and user guides at all-guides.com...
- Page 29 All manuals and user guides at all-guides.com...
- Page 30 All manuals and user guides at all-guides.com...
- Page 31 All manuals and user guides at all-guides.com...
- Page 32 All manuals and user guides at all-guides.com...
- Page 33 All manuals and user guides at all-guides.com...
- Page 34 All manuals and user guides at all-guides.com...
- Page 35 All manuals and user guides at all-guides.com...
- Page 36 All manuals and user guides at all-guides.com...
Need help?
Do you have a question about the Ashley AW2020E and is the answer not in the manual?
Questions and answers