Table Of Contents - Rheem AWW023SK JQ-1 Series Installation Maintenance And Service Manual

TABLE OF CONTENTS

INTRODUCTION .......................................................................................... 3
SECTION 1 INSTALLATION ...................................................................... 4
Site Location, Preparation & Unit Positioning ................................................................ 4
Plumbing ....................................................................................................................... 4
Chemical Treatment ...................................................................................................... 5
Electrical ....................................................................................................................... 6
Control Design for Hot Water Heating ........................................................................... 6
Link between Heat Pump, Water Pump and Thermostat for Hot Water Heating ............ 6
Precautions ................................................................................................................... 7
SECTION 2 COMMISSIONING ................................................................... 7
SECTION 3 OPERATION ........................................................................... 8
Thermostat Operation .................................................................................................. 8
Heat Up Time ............................................................................................................... 8
SECTION 4 MAINTENANCE ...................................................................... 8
Heat Exchanger Care .................................................................................................... 9
Water flow rates...........................................................................................10
Service Assistance .......................................................................................................11
SECTION 5 TROUBLESHOOTING ........................................................... 11
Machine Will Not Start .................................................................................................11
Tanks Will Not Heat .....................................................................................................11
Compressor Will Not Run ............................................................................................11
Compressor Motor Hums But Will Not Start.................................................................12
SECTION 6 INSTALLATION SCHEMATIC DRAWING .............................. 13
Typical Single Pool Heat Pump Schematic For Pool Filtration ...................................13
SECTION 7 WARRANTY .......................................................................... 14
Manual water to water Hot water 14/10/2015