Service Interlock Connector; Hybrid Battery Cooling Duct - Hyundai SANTA FE HYBRID 2021 Manual

NOTICE
When the vehicle is paint baked, do
not bake over 30 minutes in 70°C
(158°F) or 20 minutes in 80°C (176°F)
degree.
Do not wash the engine
compartment, using water. Water
may cause an electric shock and
damage the electronic components.
WARNING
This hybrid vehicle uses the hybrid
battery system inverter and converter
to generate high voltage. High voltage
in the hybrid battery system is very
dangerous and may cause severe burns
and electric shock. This may result in
serious injury or death.
For your safety, never touch,
replace, disassemble or remove the
hybrid battery system including
components, cables and connectors.
Severe burns or electric shock may
result in serious injury or death when
you fail to follow this warning.
When the hybrid battery system
operates, the hybrid battery system
can be hot. Always be careful
because burns or electric shock may
be caused by high voltage.
Do not spill liquid on the HPCU, HSG,
motor and fuses. If the hybrid system
components come in contact with
liquid, it may result in electric shock.

Service Interlock Connector

In case of emergency, cut the service
interlock connector cable to isolate the
high voltage of the battery.
WARNING
Never disconnect the service interlock
connector or cut the wire except in an
emergency situation.
Serious problems may occur, such as
the vehicle will not start.

Hybrid Battery Cooling Duct

The hybrid battery cooling duct is
located of the Passenger's seat (Left
hand-driver) and Driver's seat (Right
hand-driver). The cooling duct cools
down the hybrid battery. When the
hybrid battery cooling duct is blocked,
the hybrid battery may be overheated.
Clean the cooling duct for the hybrid
battery with a dry cloth on a regular
basis.
01
OTMHQ010016
OTMHQ010017
1-53