Table of Contents
Advertisement
Quick Links
Operation & Maintenance Manual
Model 1580-TBA Tilt-Bed Trailer
Custom Engineered For AEP
Tiltbed Trailer - S/N 1F9UZ262XHV048120
Preface
Thank you for choosing Sauber Mfg. Co.. You have purchased a trailer designed and built with care. With
minimal maintenance and by understanding its operation, your new trailer will provide you with years of excellent
service. We welcome your suggestions for improvement and stand willing to assist you if any questions arise during
its operation. If we can help in any way, please contact your account representative toll free:
The following manual provides important safety information and instruction. Please read this manual before oper-
ating your new trailer. It is important to follow safety instructions and cautions.
We acknowledge that not every situation or combination of tow vehicle and trailer can be addressed, therefore we
ask that you use sound judgment after reading the following outlines.
Some components may be produced by a third party. When available, separate service manuals and instructions
may apply.
Serious Hazards
Loss of control of the tow vehicle/trailer combination could result in serious injury or death. The most common
causes for loss of control include:
•
Failure to adjust driving behavior when towing a trailer
•
Immoderate speed – Driving too fast for the conditions
With ideal road conditions, the maximum recommended speed for safely towing a trailer is 60 mph. If you drive
too fast, the trailer is more likely to sway, increasing the possibility for loss of control. In addition, it is possible that
the tires may overheat, increasing the chance of a blow out.
Decrease your speed as road, weather, lighting, and other conditions decline.
This information is the property of Sauber Mfg. Co. and is intended for customer use only.
Website: SauberMfg.com
Voice Communications: (800) 323-9147
Fax Communications:
(630) 365-6610
07/2017
Page 1
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Sauber 1580-TBA
Summary of Contents for Sauber 1580-TBA
- Page 1 Tiltbed Trailer - S/N 1F9UZ262XHV048120 Preface Thank you for choosing Sauber Mfg. Co.. You have purchased a trailer designed and built with care. With minimal maintenance and by understanding its operation, your new trailer will provide you with years of excellent service.
- Page 2 Tie down all loads with proper sized fasteners. Always secure doors or lids if present on your trailer by securing it's latch. This information is the property of Sauber Mfg. Co. and is intended for customer use only.
- Page 3 • The trailer jacks are not fully retracted. Do not tow the trailer on the road until: • Tires and wheels are checked This information is the property of Sauber Mfg. Co. and is intended for customer use only.
- Page 4 Smaller, single axle trailers can transfer weight on the high side of this range. Larger, multiple axle trailers are de- signed to transfer less because of the limited capacity of the towing vehicle’s rear axle. This information is the property of Sauber Mfg. Co. and is intended for customer use only.
- Page 5 The simplest modifications, such as driving a screw or punching a hole to install a hanger can inadvertently damage an electrical wire or other hidden component. Before making any alteration to your trailer, contact Sauber Mfg. Co. at (800) 323-9147.
- Page 6 LED Model 33 PC C/M w/ Grommet - Red 18782 4" Round S/T/T Lamp w/ .180 Bullet 12923 S/T/T & B/U Lamp Black 4" Grommet This information is the property of Sauber Mfg. Co. and is intended for customer use only.
- Page 7 24"L12"Dx14""H - RS A-Frame Mud Flap 18421 14"Wx12"L Plain Mud Flap - 1/4"T Note: Most items listed here are in stock at Sauber Mfg. Co. This information is the property of Sauber Mfg. Co. and is intended for customer use only.
- Page 8 2. Repeat step 1 until the toggle clamp goes over center with a very firm amount of pressure. 3. Tighten the jam nut against the clevis and install the cotter pin on to the clevis pin. This information is the property of Sauber Mfg. Co. and is intended for customer use only.
Need help?
Do you have a question about the 1580-TBA and is the answer not in the manual?
Questions and answers