Advertisement
FILLING HYDRAULIC SYSTEM
Never run Ultra Legs
must be done slowly to ensure all air is removed from the system. Air remaining in the system
may prevent smooth operation. Ultra Legs
filling the hydraulic system, you will be raising and lowering the pontoon; make sure adequate
space is had before initiating fill. Use only Ultra Legs
1. Connect black battery wire to the Negative ( – ) battery terminal and the red battery wire to
the Positive ( + ) battery terminal. Ensure all hoses have been tightened.
2. Using the 2.5 gallon bottle and the 1 gallon bottle, slowly pour oil into the oil tank until it is
1/2" from the top.
3. Press the ALL
full. As the level drops, add more oil to maintain a safe oil level. Continue this until the alarm
sounds to signal that the legs have been fully retracted.
4. Fill oil level to within 1" of top of the tank.
5. Press the ALL
position. Do this slowly and do not let the oil level drop below half full. As the level drops,
add more oil to maintain a safe oil level.
6. Press the ALL
Do this slowly and do not let the oil level drop below half full. As the level drops, add more
oil to maintain a safe oil level.
7. Press the FRONT
half full. As the level drops, add more oil to maintain a safe oil level. Lift until the bow of the
pontoon begins to lift off the blocks.
8. Check for leaks in all front hoses and fittings.
9. Press the REAR
full. As the level drops, add more oil to maintain a safe oil level. Lift until the stern of the
pontoon begins to lift off the blocks.
10. Check for leaks in all rear hoses and fittings.
11. Ensure blocks are still in place, then press the ALL
Continue this until the alarm sounds to signal that the legs have been fully retracted.
12. Press the ALL
full. As the level drops, add more oil to maintain a safe oil level at slightly above half full.
Continue this until the pontoon reaches its full height. You may have to toggle the bow or
stern individually during lifting to levelly raise the pontoon.
13. At this point, the oil level in the tank should be approximately half full as oil will return to
the tank as the boat lowers. Only add more oil if the oil level drops below half full, and only
fill back to half full.
without oil in the oil tank. Filling the hydraulic system takes time and
®
button on the remote control. Do not let the oil level drop below half
button on the remote control to raise the pontoon fully into the standing
button on the remote control to lower the pontoon back onto the blocks.
button on the remote control. Do not let the oil level drop below
button on the remote control. Do not let the oil level drop below half
button on the remote control. Do not let the oil level drop below half
www.ultralegs.com
require approximately thirteen quarts of oil. While
®
provided oil.
®
button on the remote control.
5
Advertisement
