Troubleshooting - Monarch GC 340 Owner's Manual

Battery Maintenance
Your batteries are a sealed type and cannot leak (see Fig. 21). They are capable of about
300-400 full discharge cycles. If you discharge them less than fully, they will achieve a higher
number of cycles. They are maintenance free.
When the batteries need replacing (the scooter will not have as big a range as when new),
phone your local Scooters Australia dealer who will be able to supply and fit new batteries
either in your home or at the workshop.
Do not settle for inferior batteries that do not fit the specifications of both the scooter and the
charger as you risk poor scooter performance and low battery life.

TROUBLESHOOTING

IF YOUR SCOOTER DOES NOT OPERATE:
• Make certain that the freewheel lever is set to the engaged position. See page 11.
• Check the main circuit breaker. If necessary, reset the circuit breaker.
• Make certain that the speed adjustment dial is at the desired setting.
• Make certain that the key switch is set to the "On" position.
• Make sure the scooter is properly charged – including making sure the power point is
switched on during charging.
If none of the above procedures solve the problem, contact your authorised Scooters
Australia dealer.
WARNING: Do not attempt electrical repairs. Consult your authorized Scooters Australia
dealer.
Main Circuit Breaker Tripping
Figure 22.
The 50-amp main circuit breaker reset button is located under the seat on the front of the rear
shroud panel. See Fig. 22.
If, for no apparent reason, your scooter stops operating, the main circuit breaker may have
tripped.
Possible causes for the main circuit breaker to trip:
• If your scooter is equipped with pneumatic tyres, low tyre pressure can cause the motor
to overload and trip the main circuit breaker.
• Driving up a long, steep hill.
• Driving over a curb.
• Run-down batteries.
As you operate your scooter, battery voltages go down and battery current must rise to satisfy
the demands of the motor and of other electrical devices operating on your scooter. This can
cause a heavy current draw that will trip the main circuit breaker.
Monarch GC340 / 440 Owner's Manual. © Scooters Australia 2010-13. 19