Table of Contents
Advertisement
Quick Links
Turbo Air Speeds up the Pace of Innovation
Open Display Merchandiser
Installation and Operation Manual
Please read this manual completely before attempting to install or operate this equipment.
Extra Deep
TOM-36-DX*-**-*
TOM-48-DX*-**-*
TOM-60-DX*-**-*
Full Heights
Mid Heights
TOM-40*-**-*
TOM-40M*-**-*
TOM-50*-**-*
TOM-50M*-**-*
www.turboairinc.com
Vertical Air Curtain
TOM-36E*-**-*
TOM-48E*-**-*
TOM-60E*-**-*
Advertisement
Table of Contents
Related Manuals for Turbo Air TOM-40M Series
Summary of Contents for Turbo Air TOM-40M Series
- Page 1 Turbo Air Speeds up the Pace of Innovation Open Display Merchandiser Installation and Operation Manual Please read this manual completely before attempting to install or operate this equipment. Extra Deep Full Heights Mid Heights Vertical Air Curtain TOM-36-DX*-**-* TOM-40*-**-* TOM-40M*-**-*...
-
Page 2: Table Of Contents
CONTENTS PAGE INTRODUCTION SPECIFICATIONS INSTALLATION Damage inspection Location of display Leveling of display TURBO AIR RECOMMENDED OPERATING CONDITIONS OPERATING INSTRUCTIONS Power switch Light switch Temperature control Thermometer Placing the product MAINTENANCE & CLEANING Condenser coil TROUBLESHOOTING Merchandiser not functioning Merchandiser is warm... -
Page 3: Introduction
INTRODUCTION This owner’s manual has important information. Please read the entire manual before installing your new Turbo Air Open Display Merchandiser. For specific questions not answered on this manual, please call: CUSTOMER SERVICE DEPARTMENT TURBO AIR 4184 E. Conant St. -
Page 4: Specifications
SPECIFICATIONS Model TOM-40*-**-* TOM-50*-**-* TOM-40M*-**-* TOM-50M*-**-* Dimension 39 x 28 x 78.5 50.9 x 28 x 78.5 39 x 28 x 60.5 50.9 x 28 x 60.5 (W x D x H) in. 120V/1Ph/60Hz Electricity Full Load Amperes Compressor NT6226GK / CAJ9513Z Refrigerant R-404A 10.8W X 5... -
Page 5: Installation
INSTALLATION INSTRUCTIONS DAMAGE INSPECTION Prior to installation, the customer must check for damages with the freight com- pany before the unit is accepted. 1. If the crate is damaged, make sure to note the damage on the Bill of Lading prior to signing the delivery off. -
Page 6: Turbo Air Recommended Operating Conditions
TURBO AIR RECOMMENDED OPERATING CONDITIONS • Unit should not be placed • Unit should not be placed • Unit should not be placed in direct sunlight. near HVAC vents. near fans. • Unit should not be placed • Level the cabinet on all four corners near doorways. -
Page 7: Operating Instructions
OPERATING INSTRUCTIONS Level and set your merchandiser in place. Connect all necessary electrical connections. Your Open Display Merchandiser should now be ready for use. POWER SWITCH: Located at the bottom of front panel, colored in red. LIGHT SWITCH: Located at the bottom of front panel, colored in green. TEMPERATURE CONTROL: The temperature control is located underneath the bottom shelf and near the inner right-hand side of your merchandiser. -
Page 8: Maintenance & Cleaning
MAINTENANCE & CLEANING Always turn off your unit (both power and lights) when cleaning. Remove all products and allow your unit to reach room temperature. Do not allow electrical components to get wet. CLEAN YOUR OPEN DISPLAY MERCHANDISER THOROUGHLY BEFORE FIRST USAGE. a. -
Page 9: Troubleshooting
TROUBLESHOOTING For any problems with your unit, please refer to the following check list. If you are still experiencing problems or have questions, please call the Customer Service line at 1-800-381-7770. Ⅰ. MERCHANDISER NOT FUNCTIONING a. Check to see that the breaker hasn’t tripped. b. -
Page 10: Wiring Diagram
WIRING DIAGRAM timer... - Page 11 TWO YEAR WARRANTY Turbo Air warrants to the original purchaser of every new Turbo Air refrigerated unit, the cabinet and all parts thereof, to be free from defects in material or workmanship, under normal use and service, for a period of two (2) year from the date of original installation or 27 months after shipment date from Turbo Air , whichever occurs first.
- Page 12 3. ALTERATION, NEGLECT, ABUSE, MISUSE, ACCIDENT, DAMAGE DURING TRANSIT OR INSTALLATION, FIRE, FLOOD, ACTS OF GOD. TURBO AIR is not responsible for the repair or replacement of any parts that Turbo Air determines have been subjected after the date of manufacture to alteration, neglect, abuse, misuse, accident, damage during transit or installation, fire, flood, or an Act of God.
-
Page 13: Warranty
(2) year from the date of original installation or 27 months after shipment date from Turbo Air, whichever occurs first. Any part, covered under this warranty, that are by Turbo Air to have been defective within two (2) year of original installation or twenty seven (27) months after shipment date from manufacturer, whichever occurs first, is limited to the repair or replacement, including labor charges, of defective parts or assemblies.