Subscribe to Our Youtube Channel
Related Manuals for Grundfos UNILIFT KP 150 A
Summary of Contents for Grundfos UNILIFT KP 150 A
- Page 1 GRUNDFOS INSTRUCTIONS UNILIFT KP 150, KP 250, KP 350 Installation and operating instructions UNILIFT KP 150, KP 250, KP 350 Installation and operating instructions Other languages http://net.grundfos.com/qr/i/96894217...
- Page 3 UNILIFT KP 150, KP 250, KP 350 English (GB) Installation and operating instructions ............5 Български...
- Page 4 Türkçe (TR) Montaj ve kullanım kılavuzu ..............304 Українська...
-
Page 5: Table Of Contents
Pumped liquids ......11 The symbols and hazard statements below may appear in Grundfos Identification. -
Page 6: Notes
1.2 Notes 3. Installing the product The symbols and notes below may appear in Grundfos installation CAUTION and operating instructions, safety instructions and service Toxic material instructions. Minor or moderate personal injury ‐ The product will be classified as contaminated if used for a liquid which is injurious to health or toxic. -
Page 7: Mechanical Installation
3.1.2 Minimum space for UNILIFT KP-AV 3.2.1 Foundation For pumps with a vertical level switch, the minimum installation Place the pump on a plate or on bricks so that the inlet strainer is dimensions of the pit, basin or tank must be as shown in fig. free of sludge, mud or similar materials. - Page 8 3.2.4 Pipe connection UNILIFT KP-A start and stop levels Fit the outlet pipe or hose in the Rp 1 1/4 outlet. Steel pipes can be Minimum cable length Maximum cable length screwed directly into the pump outlet. (L): (L): In a permanent installation, fit a union to the outlet pipe to facilitate 70 mm 150 mm mounting and removal.
-
Page 9: Electrical Connection
3.3 Electrical connection Three-phase pumps with a float switch, UNILIFT KP-A, must be connected to the mains supply by means of a contactor. See the DANGER figure below. Electric shock Death or serious personal injury ‐ Switch off the power supply before you start any work on the product. -
Page 10: Starting Up The Product
3.3.1 Checking the direction of rotation 4. Starting up the product Three-phase pumps only DANGER Check the direction of rotation every time the pump is connected to Electric shock a new installation. Death or serious personal injury 1. Place the pump on a plane surface. ‐... -
Page 11: Product Introduction
5. Product introduction 5.1 Intended use The Grundfos UNILIFT KP pump is a single-stage submersible Grundfos UNILIFT KP pumps are available in these versions: pump designed for pumping grey wastewater, that is, wastewater from showers, sinks, washing machines, etc. Automatic start/stop operation via a float •... -
Page 12: Identification
5.3 Identification 5.3.2 Type key 5.3.1 Nameplate Example: UNILIFT KP 150 A 1 Code Explanation Designation UNILIFT KP Type range Rated motor output, XXXXXXX X EN 12050- 2 Automatic operation with float switch Automatic operation with vertical level Level control... -
Page 13: Servicing The Product
6. Servicing the product 6.1 Maintaining the product Under normal operating conditions, the pump is maintenance-free. DANGER If the pump has been used for liquids other than clean water, flush it Electric shock through with clean water immediately after use. Death or serious personal injury If the pump delivers too little water due to deposits or the like, ‐... - Page 14 6.2.2 Cleaning the inside of the pump 9. Clean the impeller and the area around the shaft. 10. Check the impeller, the pump housing and the sealing part. If Before and during the mounting of the pump housing, necessary, replace defective parts. check that the sealing part is fitted correctly.
-
Page 15: Service Kits
The product will be classified as contaminated if it has been used Inlet strainer for a liquid which is injurious to health or toxic. If you request Grundfos to service the product, contact Grundfos UNILIFT KP 150 96548064 with details about the pumped liquid before returning the product for UNILIFT KP 250 service. -
Page 16: Fault Finding The Product
The pump starts automatically after sufficient cool- The liquid temperature is too high. ing. If not, use another pump type. Contact your lo- cal Grundfos supplier or sales support. The impeller is blocked or partly blocked by impuri- The motor protection or thermal re- Clean the pump. -
Page 17: Technical Data
-20 - +70 °C. 1. Use the public or private waste collection service. 8.2 Operating conditions 2. If this is not possible, contact the nearest Grundfos company or service workshop. Installation depth Maximum 10 m below liquid level... - Page 18 Appendix A A.1. Dimensions A.1.1. UNILIFT KP-AV UNILIFT KP-M Rp 1 1/4 Rp 1 1/4 * UNILIFT KP 350...
- Page 19 Free from manufacturing defects The relevant Grundfos entity, as specified below, warrants that from the date of purchase and for the period related to the specific product purchased (Warranty Period) the products purchased (Equipment) by you (the Customer) in the relevant country will, with normal use, be free from manufacturing defects and material defects (Warranty), subject to the terms set out herein.
- Page 20 Excluded products This Warranty does not apply to Equipment that Grundfos imports that is not manufactured by Grundfos (or one of its related compa- nies). However: FOR EQUIPMENT PURCHASED IN AUSTRALIA: The Customer is entitled to the benefit of the warranty provided by the overseas manufacturer of that Equipment (if any), and any rights the Customer may have under the Australian Consumer Law (ACL).
- Page 21 What Grundfos will do If Grundfos is informed of any claim within the Warranty Period and that claim is within the terms of this Warranty, Grundfos will make arrangements for the service, repair or replacement of the Equipment, at the sole discretion and cost of Grundfos. The Customer will bear the cost of freight and insurance to transport any products to Grundfos, or to the place of purchase (as applicable).
- Page 22 A.3. Argentinian supplement sheet Only for Argentinean market // Solo para el mercado argentino: La bomba UNILIFT AP(B)/KP está determinada para instalaciones fijas y debe conectarse a una bornera o un tablero Grundfos modelo LCD108. Bomba monofásica: Bomba trifásica: L3 PE W PE Cable marrón: L1...
- Page 23 Tel.: +387 33 592 480 Centre Turkey Fax: +387 33 590 465 29-33 Wing Hong Street & 68 King Lam GRUNDFOS Pumper A/S GRUNDFOS POMPA San. ve Tic. Ltd. Sti. www.ba.grundfos.com Street, Cheung Sha Wan Strømsveien 344 Gebze Organize Sanayi Bölgesi E-mail: grundfos@bih.net.ba...
- Page 24 96894217 04.2022 ECM: 1340393 www.grundfos.com...
Need help?
Do you have a question about the UNILIFT KP 150 A and is the answer not in the manual?
Questions and answers