Grundfos Unilift KP 150 Installation And Operating Instructions Manual
Hide thumbs
Also See for Unilift KP 150:
- Installation and operating instructions manual (249 pages) ,
- Manual (12 pages) ,
- Technical data manual (6 pages)
Related Manuals for Grundfos Unilift KP 150
Summary of Contents for Grundfos Unilift KP 150
-
Page 1: Prior To Installation, Read These Installation And Operating Instructions. Fig
GRUNDFOS INSTRUCTIONS Unilift KP 150, KP 250, KP 350 Installation and operating instructions... -
Page 2: Symbols Used In This Document
Nós Grundfos declaramos sob nossa única responsabilidade que os los productos ProductName1 y ProductName2 a los cuales se refiere produtos Unilift KP 150, KP 250 e KP 350 aos quais se refere esta esta declaración son conformes con las Directivas del Consejo relativas declaração estão em conformidade com as Directivas do Conselho das... -
Page 3: Warning
Mi, Grundfos, pod polno odgovornostjo izjavljamo, da so izdelki Mi, Grundfos, izjavljujemo uz punu odgovornost, da su proizvodi Unilift KP 150, KP 250 in KP 350, na katere se ta izjava nanaša, v Unilift KP 150, KP 250 i KP 350, na koje se ova izjava odnosi, sukladni skladu z naslednjimi smernicami Sveta za uskladitev pravnih predpisov smjernicama Savjeta za prilagodbu propisa država-članica EZ:... -
Page 4: If These Safety Instructions Are Not
Ми, фірма Grundfos, із усією відповідальністю заявляємо, що Unilift KP 150, KP 250 un KP 350, uz kuriem attiecas šis paziņojums, вироби Unilift KP 150, KP 250 i KP 350 до яких і відноситься дане atbilst šādām Padomes direktīvām par tuvināšanos EK dalībvalstu свідоцтво... -
Page 5: Observed, It May Result In Personal
Unilift KP 150, KP 250, KP 350 Installation and operating instructions Montage- und Betriebsanleitung Notice d'installation et d'entretien Istruzioni di installazione e funzionamento Instrucciones de instalación y funcionamiento Instruções de instalação e funcionamento Οδηγίες εγκατάστασης και λειτουργίας Installatie- en bedieningsinstructies Monterings- och driftsinstruktion Asennus- ja käyttöohjeet... -
Page 6: Table Of Contents
CONTENTS 2. Unilift KP pumps Page Grundfos Unilift KP pump series is available in these versions: Symbols used in this document Unilift KP pumps • Unilift KP-S with integrated, electronic sensor Application (automatic operation) Pumped liquids • Unilift KP-A with float switch... -
Page 7: Application
3. Application 4. Functions Unilift KP 150, KP 250 and KP 350 are single-stage Unilift KP-S submersible pumps designed for the pumping of Automatic on/off operation via an integrated, grey wastewater. electronic sensor. The Unilift KP pump can pump water with a limited... -
Page 8: Installation
6. Installation 6.2 How to place the pump Unilift KP-A and Unilift KP-M can be used in vertical Do not install the pump hanging from position with the discharge port pointing upwards. the electric cable or the discharge pipe. The pumps may also be used in horisontal or tilted Do not lower or lift the pump by means position with the discharge port as the highest point. -
Page 9: Start/Stop Level
Start Stop Start Stop [mm] [mm] [mm] [mm] Unilift KP 150 A Unilift KP 250 A Start Unilift KP 350 A 6.5 Electrical connection The electrical connection must be carried out in Stop accordance with local regulations and standards. Check that the mains voltage and frequency correspond to the values stated on the pump nameplate. -
Page 10: Operation
6.5.1 How to check the direction of rotation 7. Operation (Three-phase pumps only) 7.1 Unilift KP-S Check the direction of rotation every time the pump is connected to a new installation. The pump will start in these situations: Check the direction of rotation like this: Automatic start 1. -
Page 11: Maintenance
8. Maintenance Under normal operating conditions, the pump is maintenance-free. If the pump has been used for liquids other than clean water, it should be flushed through with clean water immediately after use. Warning For safety reasons the suction strainer must always be fitted to the pump during operation. -
Page 12: Service
96632898 strainer strainer Order the parts through the pump supplier. If other pump components are damaged or defective, please contact the pump supplier. Fig. 16 Sensor Cable and level switch must be replaced by an authorised Grundfos Note service workshop. -
Page 13: Fault Finding
Replace the sensor. Contact b) Defective sensor. touches the upper sensing Grundfos. element. 6. Unilift KP-S does not stop a) High salt concentration and after the liquid has passed moisture or dirt on the sensing Clean the sensing elements. -
Page 14: Disposal
This product or parts of it must be disposed of in an environmentally sound way: 1. Use the public or private waste collection service. 2. If this is not possible, contact the nearest Grundfos company or service workshop. Subject to alterations. -
Page 15: Unilift Kp-A Unilift Kp-S
Dimensions Unilift KP-S Unilift KP-M Rp 1 Rp 1 * Unilift KP 350... - Page 16 Tel.: +34-91-848 8800 Germany Tel.: +43-6246-883-0 Telefax: +34-91-628 0465 GRUNDFOS GMBH México Telefax: +43-6246-883-30 Schlüterstr. 33 Bombas GRUNDFOS de México S.A. de Sweden Belgium 40699 Erkrath C.V. GRUNDFOS AB N.V. GRUNDFOS Bellux S.A. Tel.: +49-(0) 211 929 69-0 Boulevard TLC No. 15 Box 333 (Lunnagårdsgatan 6)
- Page 17 Being responsible is our foundation Thinking ahead makes it possible Innovation is the essence 96894217 1008 www.grundfos.com...
Need help?
Do you have a question about the Unilift KP 150 and is the answer not in the manual?
Questions and answers