Workswell s.r.o. will, at its option, repair or replace any such defective product free of charge if, upon inspection, it proves to be defective in material or workmanship and provided that it is returned to Workswell within the said defined period.
While looking for a solution of any technical problem we recommend following these steps: try to find an answer by searching this User Manual contact your dealer search Workswell s.r.o. website at https://www.workswell‐thermal‐camera.com/products‐overview/?t=fire‐ prevention log in and send an email to support.workswell.eu Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web...
3.3 Updates The primary aim of Workswell s.r.o. company is to supply their products in a way to meet the current needs of its users and at the same time to remove all the weaknesses that were found in their use as soon as possible.
It can also cause damage to the detector in the camera. Plug the camera to its own power source. ◦ ◦ Do not use the Workswell SAFETIS system in temperatures higher than +50 C (+122 F). High temperatures can cause damage to the camera.
Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary. www.workswell.eu VAT No.: CZ29048575...
6. SYSTEM OVERVIEW System overview Workswell SAFETIS is a thermal system specially constructed and developed for the fast detection of the risk of flare‐up before the occurrence of fire. It is intended as all‐in‐one solution featuring a thermal camera, control unit, I/O card, as well as a TPC/IP interface integrated within a single casing including an in‐built web server...
Page 11
6. SYSTEM OVERVIEW Figure 6.1: Safetis family tree overview Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 Reg. No.: 29048575 All pictures are only for illustration. info@workswell.eu +420 725 877 063 155 00, Prague 13 Real values may vary.
7.1.1 Power Supply 7.1.1.1 SAFETIS Indoor Power Supply You can power your SAFETIS with M12 5‐pin cable. Voltage between VCC and GND pins must be within range 18VDC ‐ 32VDC. You can see the power connector pinout in the Figure 7.1a.
(a) Power supply connector table To power‐on the SAFETIS, connect the power wires to the board power supply connector J3 (230VAC or 110VAC) as shown on the figure 7.2, following the connector labelling for polarity as explained in 7.3b. Connect the camera to the J4 connector.
7.1.2 Digital Outputs You can use 7 Digital Outputs of your SAFETIS with M12 8‐pin cable. Each Digital Output is set as an open collector circuit. You can see the Digital Outputs connector pinout in the Figure 7.4a and output’s schematics and example circuit in the Figure 7.5.
7. SYSTEM ASSEMBLY 7.2 Mounting the system 7.2.0.1 SAFETIS Indoor mounting system Figure 7.6: SAFETIS indoor mechanical drawings. a) Digital outputs b) Power supply c) Not used d) Not used e) Ethernet Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web...
7. SYSTEM ASSEMBLY 7.2.0.2 SAFETIS Outdoor mounting system Figure 7.7: SAFETIS outdoor mechanical drawings. a) Power supply b) Digital outputs c) Ethernet d) Not used e) Not used Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration.
IP address can be changed later. All the users need for configuring and controlling the SAFETIS is computer or tablet with at least 10” screen with web browser. The built in web server should be running few seconds after the SAFETIS boots up.
8.1.4 Admin and Operator Modes As with the two kind of users, there are two basic modes with different web pages on SAFETIS web server. If administrator logs in to web server, the ”Admin Mode” starts. If operator logs in, the ”Operator Mode” starts.
The SAFETIS will continue a measurement until the operator stops the measurement session. 8.2.2 Digital outputs During the measurement session, the SAFETIS will produce the digital outputs according to the settings. These signals should be controlled from the PLC unit.
9. LOGIN Login If you power up the SAFETIS, log‐in screen appears. There are two types of log‐in screen, one if there is not any measurement in progress and one if there is. 9.1 No measurement in progress For logging in, follow these steps: 1.
Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary. www.workswell.eu VAT No.: CZ29048575...
10. ADMINISTRATOR MODE Administrator Mode In Administrator mode, you can configure the SAFETIS for correct measurement. For correct settings, you have to go through all of the settings tabs. 10.1 System In this part, you can set: System Overview, Basic Settings,...
For setting the new IP address or subnet mask, fill the numbers and press the Set Network button. After that, SAFETIS will reboot and start with the new IP address. You have to change the address in your web browser to the new one for connecting to the SAFETIS.
Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary. www.workswell.eu VAT No.: CZ29048575...
Page 25
Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary. www.workswell.eu VAT No.: CZ29048575...
10. ADMINISTRATOR MODE 10.2 Preset (SAFETIS Pan‐Tilt only) In the SAFETIS Pan‐Tilt version of the firmware, you can select from multiple presets of the measurements. Each measurement can contain different types and amount of ROIs and different settings for each ROI and corresponding outputs.
Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 Reg. No.: 29048575 All pictures are only for illustration. info@workswell.eu +420 725 877 063 155 00, Prague 13 Real values may vary. VAT No.: CZ29048575 www.workswell.eu Czech Republic...
Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary. www.workswell.eu VAT No.: CZ29048575...
ROI ‐ deletes selected ROI. Run image calibration (NUC) 10.4.4 Pan‐Tilt settings (SAFETIS Pan‐Tilt only) This panel allows you to move the positioning system and save the position of the currently edited preset. When the camera will measure using this preset, the system will move and point at the position you saved here. To set the Pan‐Tilt position you can:...
Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary. www.workswell.eu VAT No.: CZ29048575...
Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary. www.workswell.eu VAT No.: CZ29048575...
Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary. www.workswell.eu VAT No.: CZ29048575...
Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary. www.workswell.eu VAT No.: CZ29048575...
Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary. www.workswell.eu VAT No.: CZ29048575...
Figure 10.17: Name and duration of the preset settings. 10.8 Finish This is the last part of the SAFETIS settings. Administrator can choose one of the three options: Save & Log Out ‐ Save changes and log administrator out. Discard & Log Out ‐ Discard changes and log administrator out.
Whereas administrator can set the settings for the measurement, the operator controls the measurement itself. 11.1 Graphical interface On Log‐in screen, select operator, type password and log in. After operator mode starts, SAFETIS needs few seconds to prepare measurement and load the settings.
Figure 11.2: ROI Table. SAFETIS information and numeric indicators Some basic information about the SAFETIS and measurement can be found int the tab ”SAFETIS STATUS”. The selected numeric indicators (selected ROI and measurement information) can be found in the tab ”ROI STATUS”.
Page 38
Additional information for Pan‐Tilt (SAFETIS Pan‐Tilt only) In the SAFETIS Pan‐Tilt version of the firmware, the panel contains additional information about the presets. You can see the countdown to the next preset. When this time reaches zero, the camera will turn and load new preset settings previously saved in the Administrator mode.
Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary. VAT No.: CZ29048575 www.workswell.eu...
11. OPERATOR MODE 5. Confirm your action by clicking the Ok button. 11.3 Measurement session When the measurement starts, the SAFETIS saves the state and continue the measurement until stopped by the operator or administrator. 11.3.1 Web server during measurement session Even when the Internet browser is closed or the Ethernet connection fails, after reconnecting to the web server the operator is informed about the ongoing measurement.
12. ETHERNET Ethernet As an alternative to web server control we propose the TCP/IP communication. With simple TCP/IP text commands, user can control the SAFETIS device. Parameter Value Protocol TCP/IP IP address SAFETIS IP address Port number 2240 Table 12.1: TCP/IP control parameters 12.1 Communication Protocol...
Page 42
Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary. www.workswell.eu VAT No.: CZ29048575...
Page 43
Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary. www.workswell.eu VAT No.: CZ29048575...
The update can be applied using web server application or SAFETIS Control unit interface. 13.1 Firmware update using web server Once you have obtained the update file, connect to the SAFETIS web server. The update file should have extension ”.wsm”.
‐30 C to +60 Humidity 5‐95%, noncondensing Maximum irradiance 100W/cm If you use the product in conflict with these conditions, damage to the Workswell SAFETIS system can occur. Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration.
Page 46
The sensor starts warming‐up automatically when the user turns Workswell SAFETIS system on. The infrared camera is usually ready in less than 5 minutes. During the warm‐up process the accuracy of the measured temperature data is lower and various defects can appear in the thermal image.
Page 47
16. MAINTANANCE Maintanance 16.1 Cleaning the SAFETIS head and cables Liquids: Use one of these liquids: Warm water A weak detergent solution Equipment: A soft cloth Procedure: 1. Soak the cloth in the liquid. 2. Twist the cloth to remove excess liquid.
Page 48
When you can not connect to the SAFETIS via web‐browser, check that you have typed in correct IP address. In the case that you do not know the IP address of the SAFETIS, you can press and hold the RESET button for more than 5 seconds to reset the SAFETIS IP address to default 10.0.XX.YY, where XX.YY are first two and second two...
Page 49
17. TROUBLESHOOT 17.5 System Update Make sure that your SAFETIS version is up to date. You can find information about the current version on https://www.workswell‐thermal‐camera.com/firmware‐update/safetis/ Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration.
Page 50
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 51
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS SAFETIS Ex‐Proof housing installation and restrictions Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 52
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 53
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 Reg. No.: 29048575 All pictures are only for illustration. info@workswell.eu +420 725 877 063 155 00, Prague 13 Real values may vary.
Page 54
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 Reg. No.: 29048575 All pictures are only for illustration. info@workswell.eu +420 725 877 063 155 00, Prague 13 Real values may vary.
Page 55
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 56
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 Reg. No.: 29048575 All pictures are only for illustration. info@workswell.eu +420 725 877 063 155 00, Prague 13 Real values may vary.
Page 57
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 58
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 59
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 60
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 61
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 Reg. No.: 29048575 All pictures are only for illustration. info@workswell.eu +420 725 877 063 155 00, Prague 13 Real values may vary.
Page 62
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 63
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 Reg. No.: 29048575 All pictures are only for illustration. info@workswell.eu +420 725 877 063 155 00, Prague 13 Real values may vary.
Page 64
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 65
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 66
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 67
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 68
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 69
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 70
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 71
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 72
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 73
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 74
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 75
18. SAFETIS EX‐PROOF HOUSING INSTALLATION AND RESTRICTIONS Headquarters Version 210224 EN, 24 Feb, 2021 E‐mail and Web Mobile: U Albrechtova vrchu 12 All pictures are only for illustration. info@workswell.eu +420 725 877 063 Reg. No.: 29048575 155 00, Prague 13 Real values may vary.
Page 76
Contacts Sales Department Headquarters Partners Worldwide Mobile: +420 725 955 464 Workswell s.r.o. Visit our partner list online E‐mail: sales@workswell.eu U Albrechtova vrchu 12 155 00, Prague 13 Czech Republic Company contact details Mobile: +420 725 877 063 E‐mail: info@workswell.eu...
Need help?
Do you have a question about the SAFETIS and is the answer not in the manual?
Questions and answers