Recommended Filters; Electrical Connections - Gardner Denver RDS Series Operation And Maintenance

RDS Series — 50-1000 SCFM
Installing the Dryer

4.2 Recommended Filters

Air dryers are part of a complete air treatment system
that includes filters, moisture separators, etc. To achieve
maximum benefit from the dryer, install proper filtration.
Coalescing filters should be used in conjunction with a
good particulate filter. The particulate filter is used to
extend the life and the function of the coalescing element.
Recommended filters are as follows.
Dryer Model Pre-Filter
RDS50 FSH65P
RDS75 FSH75P
RDS100 FSH100P
RDS125 FSH150P
RDS150 FSH150P
RDS200 FSH225P
RDS250 FSH300P
RDS300 FSP300P
RDS400 FSH450P
RDS500 FSH650P
RDS650 FSH650P
RDS800 FSH1000P
RDS1000 FSH1000P

4.3 Electrical Connections

SERIOUS PERSONAL INJURY AND DAMAGE TO THE
DRYER WILL OCCUR IF THE DRYER IS CONNECTED
TO A POWER SOURCE OTHER THAN THE VOLTAGE
LISTED ON THE DATA TAG OF THE DRYER. THE
MANUFACTURER IS NOT LIABLE FOR DAMAGE DUE
TO IMPROPER WIRING, PROTECTION, OR
ELECTRICAL SERVICE INSTALLATION.
WHEN INSTALLING ELECTRICAL SERVICE TO THIS
MACHINE, COMPLY WITH THE NATIONAL ELECTRIC
CODE AS WELL AS STATE AND LOCAL BUILDING
CODES.
Caution
FAILURE TO INSTALL THE PROPER ELECTRICAL
PROTECTION CAN RESULT IN PERSONAL INJURY,
FIRE, EQUIPMENT DAMAGE, OR DEATH. THE
MANUFACTURER IS NOT RESPONSIBLE FOR
DAMAGE OR INJURY CAUSED BY LACK OF OR
IMPROPERLY INSTALLED ELECTRICAL
PROTECTION.
ON RDS800,1000,1250 AND 2800 MODELS
VERIFICATION OF PROPER COMPRESSOR
ROTATION MUST BE MADE!
ROTATION MUST BE OBSERVED SO THAT:
1. FANS PULLING AIR INTO DRYER.
2. SUCTION PRESSURE DROPS AT START-UP.
3. COMPRESSOR DOES NOT MAKE EXCESSIVE NOISE.
See wiring diagram at the end of the manual for electrical
connections to the dryer. Check model number to verify
that proper voltage is being supplied to the dryer. Refer
to figure 4.3.1 for correct wire connections.
Figure 4.3.1 Wiring Connections High Voltage
After-Filter
FSH65C
FSH75C
FSH100C
FSH150C
FSH150C
FSH225C
FSH300C
FSH300C
FSH450C
FSH650C
FSH650C
FSH1000C
FSH1000C
- 12 -
A S
LL INGLE
P U
HASE NITS
A T
LL HREE
P U
HASE NITS
View of Connections With Lid Removed.
Section 4