Table of Contents
Advertisement
Quick Links
All manuals and user guides at all-guides.com
36" CORNER UNIT, B-VENT DECORATIVE GAS FIREPLACE
OWNER'S OPERATION AND INSTALLATION MANUAL
PFS
®
US
(V)GL36CL(E) Left Side
(V)GL36CR(E) Right Side
Corner, Natural Gas
Corner, Natural Gas
(V)GL36CLP(E) Left Side
(V)GL36CRP(E) Right Side
Corner, Propane/LP Gas
Corner, Propane/LP
FOR YOUR SAFETY
vapors or liquids in the vicinity of this or any other
appliance.
— WHAT TO DO IF YOU SMELL GAS :
-
For more information, visit www.fmiproducts.com
Advertisement
Table of Contents
Related Manuals for FMI GL36CR
Summary of Contents for FMI GL36CR
- Page 1 All manuals and user guides at all-guides.com 36" CORNER UNIT, B-VENT DECORATIVE GAS FIREPLACE OWNER’S OPERATION AND INSTALLATION MANUAL ® (V)GL36CL(E) Left Side (V)GL36CR(E) Right Side Corner, Natural Gas Corner, Natural Gas (V)GL36CLP(E) Left Side (V)GL36CRP(E) Right Side Corner, Propane/LP Gas...
-
Page 2: Table Of Contents
All manuals and user guides at all-guides.com TABLE OF CONTENTS Safety Information ..........2 Cleaning and Maintenance ........ 14 Dimensions ............4 Technical Service..........14 Introduction ............5 ............ 15 Selecting Location ..........5 Wiring Diagrams ..........15 Fireplace Installation..........6 Troubleshooting .......... - Page 3 All manuals and user guides at all-guides.com SAFETY INFORMATION Continued WARNING: This product con- Get fresh air at once! WARNING: Any change to Cleaning and Maintenance www.fmiproducts.com 112301-01E...
-
Page 4: Dimensions
All manuals and user guides at all-guides.com SAFETY INFORMATION Continued National Electrical Code, ANSI/NFPA 70 DIMENSIONS 6" O.D. 6" " 24" " " " 40" " " " 4" TOP VIEW " 16" " " 16" 12" 12" " " "... -
Page 5: Introduction
All manuals and user guides at all-guides.com INTRODUCTION WARNING: Installation and WARNING: This gas appli- NOTICE: This appliance is not source of heat. SELECTING LOCATION BEFORE YOU BEGIN Clearances, YOU MAY Existing Side Wall 4" From Opening to Perpendicular Wall Access National Electrical Control Panel... -
Page 6: Fireplace Installation
All manuals and user guides at all-guides.com SELECTING LOCATION 1" Min. Clearance Continued Doublewall from Pipes to Combustibles 6" B-Vent 35" Min. to Effective Do Not Pack Space Opening Between Spacer with to Ceiling Any Type of Insulation " Minimum 0"... - Page 7 All manuals and user guides at all-guides.com FIREPLACE 1" Min. to INSTALLATION Combustibles Continued Nailing Flange FRAMING Prepared Nails or Framing Screws Figure 8 - Securing Appliance with Nailing Flanges VENT PIPE INSTALLATION Note: Figure 6 - Framing Dimensions Prior to Placing Appliance B-1 Type Vent (Not...
- Page 8 All manuals and user guides at all-guides.com FIREPLACE CAUTION: Do not connect INSTALLATION Continued OPTIONAL OUTSIDE AIR KIT repair. Note: CAUTION: Air inlet ducts attic space. Wall Switch (Supplied) To Thermopile Secure to Collars with Duct Tape or Screws Air Inlet Back View Location Route Millivolt Wires...
- Page 9 All manuals and user guides at all-guides.com FIREPLACE INSTALLATION Continued Pilot Gas Line Do Not Kink Pilot To Pilot Adjustment Burner ON/OFF Knob To Main not enter the gas line. Burner Inlet Outlet Pressure Pressure Figure 12 - Millivolt Control Valve Shutoff Main Valve...
- Page 10 All manuals and user guides at all-guides.com FIREPLACE INSTALLATION Noncombustible Facing Material Continued Do Not Block Effective Opening "L" Shaped Metal Support WARNING: All gas piping Noncombustible Facing Material Figure 17 - Fireplace Facing Material After ensuring that the gas valve GLASS DOOR detection solution to all con- and corrected.
-
Page 11: Operating Fireplace
All manuals and user guides at all-guides.com OPERATING FIREPLACE MILLIVOLT MODELS If you smell gas, STOP! Follow “B” in the safety information in column 1. If you don’t FOR YOUR SAFETY smell gas, go to the next step. READ BEFORE LIGHTING 7. - Page 12 All manuals and user guides at all-guides.com OPERATING FIREPLACE LIGHTING Continued INSTRUCTIONS TO TURN OFF GAS NOTICE: During initial operation TO APPLIANCE 1. Turn off the wall switch. 2. Turn off all electric power to the appliance 4. Push in gas control knob and turn clockwise to OFF.
-
Page 13: Inspecting Burner
All manuals and user guides at all-guides.com INSPECTING BURNER PILOT ASSEMBLY ADJUSTMENT air shutter and that air shutter is CORRECT LONG, BLUE FLAME WITH YELLOW TIPS INCORRECT Ignitor CLOSE 3/8" to 1/2" SHUTTER SHORT, SHARP 1/8" (3 mm) (10 mm - 13 mm) BLOWING FLAME INCORRECT Pilot Burner... -
Page 14: Cleaning And Maintenance
All manuals and user guides at all-guides.com CLEANING AND WARNING: Do not operate MAINTENANCE area. Do not run unit. Use proper glass. Discard glass safely. A WARNING: Installation and for glass. each use and at least annually TECHNICAL SERVICE WARNING: Turn off gas and ing appliance. -
Page 15: Wiring Diagrams
All manuals and user guides at all-guides.com SPECIFICATIONS WIRING DIAGRAMS PILOT THERMOPILE IGNITOR DO NOT CONNECT TO 120V N.C.SW HEAT LIMIT SWITCH TH/TP INCOMING MAIN GAS SUPPLY PILOT SAFETY WIRE WALL SWITCH (SUPPLIED) MILLIVOLT WIRING DIAGRAM USE ONLY CL2 THRMST WIRE 18 GA. -
Page 16: Troubleshooting
All manuals and user guides at all-guides.com TROUBLESHOOTING MILLIVOLT SYSTEM Note: OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Wiring Diagrams Pilot will not stay lit www.fmiproducts.com 112301-01E... - Page 17 All manuals and user guides at all-guides.com TROUBLESHOOTING ELECTRONIC IGNITION SYSTEM Note: OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Wiring Diagram Wiring Diagrams www.fmiproducts.com 112301-01E...
-
Page 18: Replacement Parts And Accessories
All manuals and user guides at all-guides.com REPLACEMENT PARTS AND ACCESSORIES CABINET STYLE DOOR KIT For use with all models. For use with all models. REMOTE CONTROL KIT - MLCR MILLIVOLT VALVE REMOTE CONTROL KIT - WRC For Electronic Units Only ELECTRONIC VALVE For use with all models. - Page 19 All manuals and user guides at all-guides.com NOTES _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________...
- Page 20 This is FMI PRODUCTS, LLC’s exclusive warranty, and to the full extent allowed by law; this express war- ranty excludes any and all other warranties, express or implied, written or verbal and limits the duration of FMI PRODUCTS, LLC makes no other warranties regarding this product.
Need help?
Do you have a question about the GL36CR and is the answer not in the manual?
Questions and answers