FMI GL36ST Owner's Operation And Installation Manual
2-sided (see-through), vented decorative gas appliance
Hide thumbs
Also See for GL36ST:
- Owners manual and installation manual (20 pages) ,
- Owner's operation and installation manual (20 pages) ,
- Owner's operation and installation manual (20 pages)
Table of Contents
Advertisement
2-SIDED (SEE-THROUGH), VENTED DECORATIVE GAS APPLIANCE
OWNER'S OPERATION AND INSTALLATION MANUAL
PFS
®
US
NATURAL GAS MODELS (V)GL36ST AND (V)GL36STE
PROPANE/LP GAS MODELS (V)GL36STP AND (V)GL36STEP
FOR YOUR SAFETY
vapors or liquids in the vicinity of this or any other
appliance.
— WHAT TO DO IF YOU SMELL GAS :
-
For more information, visit www.fmiproducts.com
Advertisement
Table of Contents
Related Manuals for FMI GL36ST
Summary of Contents for FMI GL36ST
- Page 1 2-SIDED (SEE-THROUGH), VENTED DECORATIVE GAS APPLIANCE OWNER’S OPERATION AND INSTALLATION MANUAL ® NATURAL GAS MODELS (V)GL36ST AND (V)GL36STE PROPANE/LP GAS MODELS (V)GL36STP AND (V)GL36STEP FOR YOUR SAFETY vapors or liquids in the vicinity of this or any other appliance. — WHAT TO DO IF YOU SMELL GAS :...
-
Page 2: Table Of Contents
and operational procedures. For assistance or addi- agency or the gas supplier. NOT FOR USE WITH SOLID FUEL CHECK LOCAL CODES PRIOR TO INSTALLATION SAVE THIS BOOK cated on the rating plate. gases. TABLE OF CONTENTS Safety Information ..........3 Technical Service.......... -
Page 3: Safety Information
SAFETY INFORMATION WARNING: This product contains and/or generates of California to cause cancer or Get fresh air at once! Cleaning WARNING: Any change to and Maintenance www.fmiproducts.com 55173H... -
Page 4: Dimensions
SAFETY INFORMATION Continued National Electrical Code, ANSI/NFPA 70 DIMENSIONS 6"(152 mm) 6" O.D. (152 mm) " (64 mm) 24" (610 mm) " (241 mm) " " (2 1/2") 19" (64mm) (483 mm) (540 mm) (387 mm) " " (1080 mm) (114 mm) TOP VIEW 16"... -
Page 5: Introduction
INTRODUCTION Fuel Gas Code, ANSI Z223.1/NFPA 54 ANSI Z21.50 Vented Gas Appliance PFS Corporation WARNING: Installation of WARNING: This gas appli- your local Building and Safety cover this appliance. NOTICE: This appliance is not source of heat. SELECTING LOCATION BEFORE YOU BEGIN Clearances, Note: This decora- tive appliance is not designed for outdoor... -
Page 6: Fireplace Installation
SELECTING LOCATION 1" (22 mm) Minimum 1" (22 mm) Minimum Clearance from Pipes Clearance to Combustibles to Combustibles Continued " (578 mm) 19" (483 mm) " (289 mm) " 6" O.D. (565 mm) (152 mm) 4" (102 mm) Min. from the Perpendicular Side Wall to the Fireplace Opening (Typ.) Figure 3 - Clearances from Top View 1"... - Page 7 FIREPLACE INSTALLATION 49" Minimum Continued (Diagonal) FRAMING As Required by Design as Long as Ceiling Clearances are Maintained Figure 8 - Appliance Must Be Installed on a Wood or Metal Panel if Being Installed on Any Combustible Material Other Than Wood VENT PIPE INSTALLATION "...
- Page 8 Figure 11 - Wall Switch Installation ELECTRONIC MODELS (GL36STE/EP) Air Inlet Eyebrow Vent Hood Vented Crawl Space Required for (Check Local Codes Wall Installation Before Installing in a Vented Crawl Space) Figure 10 - Outside Air Kit MILLIVOLT MODELS (GL36ST/STP) Wiring Diagrams Note: www.fmiproducts.com 55173H...
- Page 9 FIREPLACE INSTALLATION Continued Pilot Gas Line Do Not Kink Pilot To Pilot Adjustment Burner ON/OFF Knob To Main Burner Strain Relief Grommet Common Ground Wire Inlet Outlet Pressure Pressure Figure 12 - Wiring Through Outer Surround Figure 13 - Millivolt Control Valve GAS SUPPLY TESTING Note: Main...
- Page 10 FIREPLACE Shutoff Valve INSTALLATION Continued Extension Typical Exterior Wall Gas Shutoff Installation Figure 15 - Typical Exterior Wall Gas Shut-Off Installation LOG SET PLACEMENT Bottom Logs does not enter the gas line. WARNING: All gas piping Top Logs (Twigs) Figure 16 - Log Placement FIREPLACE FACING After ensuring that the gas valve detection solution to all con-...
-
Page 11: Burner Flame Adjustment
FIREPLACE Ignitor Flame Pilot Burner INSTALLATION Sensor 1/8" to 1/4" Continued 3/8" to 1/2" Noncombustible Facing Material Burner Do Not Block Effective Opening Figure 19 - Correct Pilot Flame Pattern - "L" Shaped Electronic Assembly Metal Support Noncombustible Facing Material BURNER FLAME ADJUSTMENT Figure 17 - Fireplace Facing Material MANTELS... - Page 12 FIREPLACE Top Slot Under Frame INSTALLATION Adjustment Continued Clip OPTIONAL GLASS DOOR Adjustment Screw Replacement Parts and Accessories Long Pivot Pin Installing Glass Door Bottom Pin Bottom Slot Adjustment Clip Figure 21 - Installing Glass Doors Glass Doors Must be Fully Open (as Shown) or Fully Closed when Appliance is in Operation Figure 22 - Glass Doors Shown Fully...
-
Page 13: Operating Fireplace
OPERATING FIREPLACE 1. STOP! Read the safety information, column 1. MILLIVOLT MODELS 2. Turn wall switch to the OFF position. 3. Turn off all electric power to the appliance. FOR YOUR SAFETY 4. Open control access panel. READ BEFORE LIGHTING 5. - Page 14 OPERATING FIREPLACE C. Use only your hand to push in or turn the gas control knob. Never use tools. If the Continued knob will not push in or turn by hand, don’t TO TURN OFF GAS nician or gas supplier. Force or attempted TO APPLIANCE 1.
-
Page 15: Cleaning And Maintenance
OPERATING FIREPLACE WARNING: Turn off gas and Continued appliance. Any safety screen ing the appliance. Figure 26 - Pilot TO TURN OFF GAS TO APPLIANCE 1. Turn off all electric power to the appliance if service is to be performed. 2. -
Page 16: Wiring Diagrams
WIRING DIAGRAMS PILOT THERMOPILE IGNITOR DO NOT CONNECT TO 120V N.C.SW HEAT LIMIT SWITCH TH/TP INCOMING MAIN GAS SUPPLY PILOT SAFETY WIRE WALL SWITCH (SUPPLIED) MILLIVOLT WIRING DIAGRAM PILOT INCOMING IGNITOR WALL SWITCH MAIN GAS (SUPPLIED) SUPPLY SENSOR BLACK INCOMING 120V AC WHITE (FUSE BOX... -
Page 17: Troubleshooting
TROUBLESHOOTING MILLIVOLT SYSTEM Note: OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Replacement Parts Replace- ment Parts and Accessories Pilot will not stay lit www.fmiproducts.com 55173H... - Page 18 TROUBLESHOOTING ELECTRONIC IGNITION SYSTEM Note: OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Replacement Parts and Acces- sories Replace- ment Parts and Accessories Pilot will not stay lit www.fmiproducts.com 55173H...
-
Page 19: Replacement Parts And Accessories
REPLACEMENT PARTS AND ACCESSORIES BURNER ASSEMBLY - 23439 For use with all models. ON/OFF REMOTE CONTROL KIT - MLCR For Millivolt Units Only VENT HOOD - AK4 For use with all models. MILLIVOLT VALVE REFRACTORY Natural Gas - 14512 Side Refractory - 23519 Propane/LP Gas - 14513 Face - 112139-01 ELECTRONIC VALVE... - Page 20 This is FMI PRODUCTS, LLC’s exclusive warranty, and to the full extent allowed by law; this express war- ranty excludes any and all other warranties, express or implied, written or verbal and limits the duration of FMI PRODUCTS, LLC makes no other warranties regarding this product.