Honda GX670R Parts Catalog
  1. Manuals
  2. Brands
  3. Honda Manuals
  4. Engine
  5. GX670R
  6. Parts catalog
Honda GX670R Parts Catalog

Honda GX670R Parts Catalog

General purpose engine
Hide thumbs Also See for GX670R:
Table of Contents

Advertisement

Quick Links

GENERAL PURPOSE ENGINE
GX670U
GX670R
2
13Z6G602
© Honda Motor Co., Ltd. 2008

Advertisement

Table of Contents
loading

Related Manuals for Honda GX670R

Summary of Contents for Honda GX670R

  • Page 1 GENERAL PURPOSE ENGINE GX670U GX670R 13Z6G602 © Honda Motor Co., Ltd. 2008...
  • Page 2 GX670U FOREWORD INDEX ENGINE GROUP PART NUMBER INDEX GX670R PART NAME INDEX...

  • Page 4: Table Of Contents

    Instruction for use of parts catalogue • This parts catalogue was prepared based on the latest infor- mation available as of January 10, 2008. • See the parts catalogue news for any revision that is made after January 10, 2008. •...

  • Page 5: How To Refer To The Part Information

    How to refer to the part information Reference with “Illustrated index” Reference with “Part number index” Reference with “Part name index” 2008.01.10...

  • Page 6: Part Catalogue Structure

    Part catalogue structure 2008.01.10 Address number • Address No. is provided (in place of the page No.) to help you refer to the part with the part No. or part name. Block title Block number Service item/Flat rate time Reference number •...

  • Page 7: When The Parts Were Revised

    When the parts were revised Be sure to check the serial number!! The number has been When shown at the left side, used from the initial model it is applicable to the models without revision. o f N o . 1 0 0 1 8 0 1 a n d t h e subsequent numbers.

  • Page 8: How To Check The Part Block And Serial Numbers

    How to check the part block and serial numbers Engine parts Carburetor parts Part block E-2~ E-14 Stamped Stamped Numbers carburetor engine needed identification number number Check point DZ6G-A TYPE ENGINE SERIAL NUMBER CARBURETOR IDENTIFICATION NUMBER 2008.01.10 D30Z6G6CA0...

  • Page 9: Models, Parts Catalogue Codes And Applicable Serial Numbers

    • Models, parts catalogue codes and applicable serial Nos. given in this parts catalogue can be identified as follows. Model Type BDWN BXF5 BXF9 TDWN GX670U TWF6 TXA2 TXF2 TXF4 TXF5 TXF7 TXF8 TXF9 Models, parts catalogue codes and applicable serial numbers Parts Applicable catalogue...
  • Page 10 VAB2 VAB2 VXE1 VXE1 GX670U VXE2 VXE2 VXE4 VXE4 GX670R * Of carburetor identification numbers, only the portions underlined in the example below are used for registration. Applicable Applicable engine carburetor serial No. identification No. BK01G A/B BK01B B/C/D...

  • Page 11: Features Of Each Type

    • See the following table for the features of each type. (Items in brackets are optional) Specifications 28.575mm Ø Straight 36.5mm Ø Straight Crankshaft 1/10" Tapered 3/16" Tapered Standard Air cleaner Snorkel Control box Winter kit Specifications 28.575mm Ø Straight 36.5mm Ø...
  • Page 12 Model Type TXW Specifications 28.575mm Ø Straight 36.5mm Ø Straight Crankshaft 1/10" Tapered 3/16" Tapered Standard Air cleaner Snorkel Control box Winter kit GX670U GX670R VAB2 VXE1 VXE2 VXE4 2008.01.10...

  • Page 13: Fuel Hose, General Purpose Hoses And Vinyl Hose

    • The standard part fuel hose, general purpose hose and vinyl hose may be substituted by the coiled bulk part. • When ordering the standard part fuel hose, general purpose hose and vinyl hose use the bulk part number written in the parts catalog in brackets ( •...

  • Page 14: Flat Rate Service Time

    FLAT RATE SERVICE TIME Flat rate service time (FRT) means the standard time required to service a product, which is listed in this manual to help the dealers control the actual working process and calculate the service charge by using it as a guide. FRT setting system Net service time Removal, Disassembly/reassembly, Installation...
  • Page 15 Work procedure • As the work procedure is set with the work time according to the method in the separate Service Manual, refer to this Manual as required. • Work methods permitting servicing in the shortest time still permitting assurance of safe work and product warranty are used for the setting of service items not listed in the Service Manual.
  • Page 16 Explanation of FRT by using an example (The example may differ from the actual presented items) Ref. (Relative ref. Number) L.O.N. Description (1, 3, 4, 7) 1111L1 VALVE, INTAKE • • • • • • • • • • • • • 4.1 •...
  • Page 17 Indication mark for the listing of service items that continues to the following page Ref. (Relative ref. Number) L.O.N. Description 1111L1 VALVE, INTAKE • • • • • • • • • • • • 4.1 • • Mark indicated at the last line. Indication of the block with no setting of FRT Ref.
  • Page 18 Major service items without using spare parts (1) Removal/Installation, (2) Adjustment, (3) Inspection/Measurement, (4) Overhaul, (5) Other work E: Engine, T: Transmission, D: Drive system, B: Body and related parts (1) Removal/Installation Set with the parts configuration in the status of being removed from the product.

  • Page 19: Illustrated Index

    CYLINDER HEAD CRANKSHAFT E-12 FAN COVER ENGINE GROUP CYLINDER BARREL PISTON/CONNECTING ROD E-14 CARBURETOR 2008.01.10 CRANKCASE COVER CAMSHAFT E-15 AIR CLEANER(STANDARD)
  • Page 20 E-15-1 AIR CLEANER(SNORKEL) E-18 FUEL PUMP E-21 STARTER MOTOR ENGINE GROUP E-16 MUFFLER(HIGH-R) E-19 FLYWHEEL E-22 CONTROL(1) 2008.01.10 E-16-1 MUFFLER(HIGH-L) E-20 IGNITION COIL E-22-1 CONTROL(2)
  • Page 21 E-22-2 CONTROL(3) E-24 OIL COOLER E-40-1 OTHER PARTS(CONTROL COVER) ENGINE GROUP E-22-20 AUTO THROTTLE E-28 LABEL/TOOL EOP-2 WINTER KIT 2008.01.10 E-23 CONTROL BOX E-40 OTHER PARTS(LABEL)
  • Page 22 Ref. Part No. Description 1 11911-ZJ1-840 HANGER, ENGINE •••••••••••••• 2 12204-ZE2-306 GUIDE, IN. VALVE (O.S.) ••••• 3 12205-ZJ1-405 GUIDE, EX. VALVE (O.S.) ••••• 4 12210-ZJ1-406 HEAD COMP., CYLINDER (#1) ••• 5 12216-ZE2-300 CLIP, VALVE GUIDE ••••••••••• 6 12220-ZJ1-405 HEAD COMP., CYLINDER (#2) ••• 7 12251-ZJ1-841 GASKET, CYLINDER HEAD •••••••...
  • Page 23 Ref. Part No. Description 23 95701-08020-00 BOLT, FLANGE, 8X20 •••••••••• 24 95701-10080-00 BOLT, FLANGE, 10X80 ••••••••• 25 98079-52876 PLUG, SPARK (BPR2ES)(NGK) ••• 98079-5485V PLUG, SPARK (J14CR-U)(DENSO) 98079-5487V PLUG, SPARK (ZGR4A) ••••••••• 98079-5585V PLUG, SPARK (J16CR-U)(DENSO) 98079-5587V PLUG, SPARK (ZGR5A) ••••••••• 98079-52876 PLUG, SPARK (BPR2ES)(NGK) •••...
  • Page 24 Ref. Part No. Description 1 12000-ZN1-405 BARREL ASSY., CYLINDER •••••• 12000-ZN1-406 •••••••••••••••••••••••••••• 12000-ZN1-415 •••••••••••••••••••••••••••• 12000-ZN1-416 •••••••••••••••••••••••••••• 2 12356-ZJ1-000 COVER, BREATHER ••••••••••••• 3 12358-ZJ1-000 PACKING, BREATHER COVER ••••• 4 12372-ZE2-300 VALVE, BREATHER ••••••••••••• 5 15558-ZJ1-003 VALVE, OIL SHUT-OFF ••••••••• 6 16541-ZJ1-840 SHAFT, GOVERNOR ARM •••••••••...
  • Page 25 Ref. Part No. Description 13 90031-ZE1-000 BOLT, FLANGE, 6X32 •••••••••• 14 91001-ZJ1-841 BEARING, NEEDLE, 8X12.7X11.1 15 91002-ZJ1-841 BEARING, NEEDLE, 8X12X10 •••• 16 91201-ZE9-003 OIL SEAL, 8X14X5 •••••••••••• 17 91201-ZJ1-841 OIL SEAL, 38X58X9 ••••••••••• 18 91302-MB6-830 O-RING, 13X3.0 •••••••••••••• 19 91353-671-004 O-RING, 14MM(NOK) •••••••••••...
  • Page 26 Ref. Part No. Description 1 11300-ZJ1-842 COVER ASSY., CRANKCASE •••••• 11300-ZJ1-843 •••••••••••••••••••••••••••• 2 11381-ZJ1-840 GASKET, CASE COVER •••••••••• 3 12105-ZA0-701 BOLT, SEALING ••••••••••••••• 4 15120-ZJ1-000 COVER ASSY., OIL PUMP (TWO BOLTS) 15120-ZJ1-010 COVER ASSY., OIL PUMP (THREE BOLTS) 5 15124-ZJ1-003 ROTOR, OIL PUMP OUTER •••••••...
  • Page 27 Ref. Part No. Description 13 16511-ZJ1-840 WEIGHT, GOVERNOR •••••••••••• 14 16512-ZJ1-840 HOLDER, GOVERNOR WEIGHT ••••• 15 16513-ZE2-000 PIN, GOVERNOR WEIGHT •••••••• 16 16531-Z0A-000 SLIDER, GOVERNOR •••••••••••• 17 90015-883-000 BOLT, FLANGE, 6X28 •••••••••• 18 90018-PN3-000 HOLDER, OIL FILTER •••••••••• 19 90473-147-000 WASHER, 6X16 ••••••••••••••••...
  • Page 28 Ref. Part No. Description 1 13310-ZN1-U40 CRANKSHAFT COMP. •••••••••••• 2 13310-ZN1-000 CRANKSHAFT COMP. •••••••••••• 3 13310-ZN1-800 CRANKSHAFT COMP. •••••••••••• 4 13310-ZN1-810 CRANKSHAFT COMP. •••••••••••• 5 90401-ZJ1-000 WASHER, CRANKSHAFT THRUST (38.5X54.0X1.0) 6 90745-ZE2-600 KEY, 6.3X6.3X43 ••••••••••••• CRANKSHAFT Reqd. QTY Serial No. - -------- -------- VAB2 1 -------- -------- TAF,TDW,TDWN,TWF6,TXA2,TXF,TXF2,TXF4,TXF5,TXF7,TXF8,TXF9,TXW 1 -------- -------- BAF,BDW,BDWN,BXF,BXF5,BXF9...
  • Page 29 Ref. Part No. Description 1 13010-ZJ1-841 RING SET, PISTON (STD.) 13011-ZJ1-841 RING SET, PISTON (0.25) 13012-ZJ1-841 RING SET, PISTON (0.50) 13013-ZJ1-841 RING SET, PISTON (0.75) 13010-Z5H-004 RING SET, PISTON (STD.) 13011-Z5H-004 RING SET, PISTON (0.25) 13012-Z5H-004 RING SET, PISTON (0.50) PISTON/CONNECTING ROD Reqd.
  • Page 30 Ref. Part No. Description (1) 13013-Z5H-004 RING SET, PISTON (0.75) (TEIKOKU) (2) - -------- -------- BDWN,TDWN 2 13101-ZN1-000 PISTON (STD.) ••••••••••••••• 13102-ZN1-000 PISTON (0.25) ••••••••••••••• 13103-ZN1-000 PISTON (0.50) ••••••••••••••• 13104-ZN1-000 PISTON (0.75) ••••••••••••••• 13101-ZN1-010 PISTON (STD.) ••••••••••••••• 13102-ZN1-010 PISTON (0.25) ••••••••••••••• 13103-ZN1-010 PISTON (0.50) •••••••••••••••...
  • Page 31 Ref. Part No. Description 1 12209-ZE8-003 SEAL, VALVE STEM •••••••••••• 2 14100-ZJ1-842 CAMSHAFT ASSY. •••••••••••••• 14100-Z6D-V40 •••••••••••••••••••••••••••• 3 14410-ZJ1-840 ROD, PUSH ••••••••••••••••••• 4 14431-ZE2-010 ARM, VALVE ROCKER ••••••••••• 5 14451-ZE1-013 PIVOT, ROCKER ARM ••••••••••• 6 14568-ZJ1-841 SPRING, WEIGHT RETURN ••••••• 14568-Z6D-V40 ••••••••••••••••••••••••••••...
  • Page 32 Ref. Part No. Description 14 14771-ZE2-000 RETAINER, IN. VALVE SPRING •• 15 14773-ZE2-000 RETAINER, EX. VALVE SPRING •• 16 14775-ZE2-010 SEAT, VALVE SPRING •••••••••• 17 14781-ZE2-000 ROTATOR, VALVE •••••••••••••• 18 14791-ZE2-010 PLATE, PUSH ROD GUIDE ••••••• 19 90005-896-000 BOLT, FLANGE, 5X16 •••••••••• 20 90012-ZE0-010 BOLT, PIVOT, 8MM ••••••••••••...
  • Page 33 CAMSHAFT Ref. (Relative ref. Number) L.O.N. + 4 1111T1B .Replace both heads (intake and exhaust all) add 1111U3 ARM, ROCKER :LEFT BANK EXHAUST .INCLUDES: Valve clearance adjustment 1111U3A .Replace left bank intake rocker arm add •••••••••••••• 1111U3B .Replace both heads (intake and exhaust all) add 1111T2 ARM, ROCKER :RIGHT BANK INTAKE .INCLUDES: Valve clearance...
  • Page 34 CAMSHAFT Ref. (Relative ref. Number) L.O.N. .INCLUDES: Valve clearance adjustment and reface 1111T9B .Replace one head(intake and exhaust all) add •••••••••••• 1111U1 VALVE, INTAKE(ONE) :RIGHT BANK .INCLUDES: Valve clearance adjustment and reface 1111U1B .Replace one head(intake and exhaust all) add •••••••••••• 9 1111U0 VALVE, EXHAUST(ONE) :LEFT BANK .INCLUDES: Valve clearance adjustment and reface...
  • Page 35 CAMSHAFT Ref. (Relative ref. Number) L.O.N. +11 1111V9A .Replace one head(intake and exhaust all) add •••••••••••• 1111W0 SPRING, VALVE(ONE) :INTAKE RIGHT BANK •••••••••• .INCLUDES: Valve clearance adjustment 1111W0A .Replace one head(intake and exhaust all) add •••••••••••• 1111W1 SPRING, VALVE(ONE) :EXHAUST LEFT BANK •••••••••• .INCLUDES: Valve clearance adjustment 1111W1A .Replace one head(intake and...
  • Page 36 CAMSHAFT Ref. (Relative ref. Number) L.O.N. F.R.T. Description .INCLUDES: Valve clearance adjustment 2008.01.10...
  • Page 37 E-12 Ref. Part No. Description 1 16715-ZJ1-840 COVER, FUEL PUMP •••••••••••• 2 16715-ZJ1-850 COVER, FUEL PUMP (MANUAL CONTROL) 16715-ZJ1-860 COVER, FUEL PUMP (MANUAL CHOKE) 3 19611-ZJ1-840ZA COVER, FAN *NH1*...BLACK 19611-ZJ1-840ZC *R280*...POWER RED 4 19611-ZJ1-850ZA COVER, FAN (RECOIL STARTER) *NH1*...BLACK 19611-ZJ1-850ZC *R280*...POWER RED 5 19612-ZJ1-841 PLATE, SIDE •••••••••••••••••...
  • Page 38 E-12 Ref. Part No. Description 9 19632-ZN1-010 SHROUD •••••••••••••••••••••• (R. SIDE) 10 33713-GC2-000 COLLAR B, TAILLIGHT ••••••••• 11 34150-ZJ1-842 ALERT UNIT, OIL ••••••••••••• 34150-ZJ1-843 •••••••••••••••••••••••••••• 12 80101-310-000 RUBBER, RR. FENDER CUSHION •• 13 90013-883-000 BOLT, FLANGE, 6X12(CT200) ••• 14 90018-ZE1-000 BOLT, FLANGE, 6X23(CT200) •••...
  • Page 39 E-14 Ref. Part No. Description 1 12357-ZJ1-840 TUBE, BREATHER •••••••••••••• 2 15772-551-000 CLIP, BREATHER TUBE ••••••••• 3 16010-ZN1-801 GASKET SET •••••••••••••••••• 4 16011-ZN1-801 VALVE SET, FLOAT •••••••••••• 5 16013-ZN1-801 FLOAT SET ••••••••••••••••••• 6 16015-ZN1-801 CHAMBER SET, FLOAT •••••••••• 7 16016-ZN1-801 SCREW SET, PILOT ••••••••••••...
  • Page 40 E-14 Ref. Part No. Description 16 16211-ZN1-000 INSULATOR, CARBURETOR ••••••• 17 16221-ZN1-000 PACKING, CARBURETOR ••••••••• 18 17103-ZN1-010 ELBOW, MANIFOLD ••••••••••••• 19 17228-ZN1-000 PACKING, AIR CLEANER •••••••• 20 17238-ZJ4-830 COLLAR A, AIR CLEANER ••••••• 21 17410-ZN1-000 ELBOW COMP., AIR CLEANER •••• 22 90314-ZJ1-840 NUT, INSERT, 6MM ••••••••••••...
  • Page 41 E-15 Ref. Part No. Description 1 17210-ZJ1-842 ELEMENT COMP., AIR CLEANER •• 2 17218-ZJ1-840 FILTER, OUTER ••••••••••••••• 3 17219-ZJ1-840 CLIP, AIR CLEANER ••••••••••• 4 17220-ZN1-000 CASE COMP., AIR CLEANER ••••• 17220-Z6G-000 •••••••••••••••••••••••••••• 5 17229-ZN1-000 SEAL, AIR CLEANER CASE •••••• 6 17230-ZJ1-840 COVER ASSY., AIR CLEANER ••••...
  • Page 42 E-15 Ref. Part No. Description 10 90003-ZJ1-840 BOLT, SPECIAL, 5MM •••••••••• 11 95701-06028-00 BOLT, FLANGE, 6X28 •••••••••• 12 90634-ZL8-H00 CAP, SEALING •••••••••••••••• 13 95002-02100 CLIP, TUBE (B10) •••••••••••• AIR CLEANER(STANDARD) Reqd. QTY Serial No. - -------- -------- BAF,BDW,BDWN,BXF,BXF5,BXF9,TAF,TDW,TDWN,TWF6,TXF,TXF2,TXF4,TXF5,TXF7 TXF8,TXF9,TXW,VXE1,VXE2,VXE4 - -------- -------- BAF,BDW,BDWN,BXF,BXF5,BXF9,TAF,TDW,TDWN,TWF6,TXF,TXF2,TXF4,TXF5,TXF7 TXF8,TXF9,TXW,VXE1,VXE2,VXE4 - -------- -------- BDWN,TDWN - -------- -------- BDWN,TDWN...
  • Page 43 E-15-1 Ref. Part No. Description 1 17207-ZJ1-840 RUBBER, AIR CLEANER HOLDER 2 17208-ZJ1-840 HOLDER COMP., AIR CLEANER 3 17209-ZJ1-840 HOLDER COMP., AIR CLEANER 4 17210-759-013 ELEMENT COMP., AIR CLEANER •• 5 17220-ZJ1-850 CASE COMP., AIR CLEANER 6 17222-ZJ1-850 STAY COMP. A, AIR CLEANER 7 17224-ZJ1-850 STAY COMP.
  • Page 44 E-15-1 Ref. Part No. Description 21 90502-759-003 WASHER, AIR CLEANER ••••••••• 22 95018-52250 BAND, AIR CLEANER CONNECTING TUBE (52) 23 95018-58250 BAND, AIR CLEANER CONNECTING TUBE (58) 24 95701-06012-00 BOLT, FLANGE, 6X12 •••••••••• 25 95701-06016-00 BOLT, FLANGE, 6X16 •••••••••• 26 95701-06028-00 BOLT, FLANGE, 6X28 •••••••••• 27 95701-08020-00 BOLT, FLANGE, 8X20 ••••••••••...
  • Page 45 E-16 Ref. Part No. Description 1 18310-ZN1-003 MUFFLER COMP. (HIGH-R) •••••• 2 18321-ZN1-003 PROTECTOR, MUFFLER •••••••••• 3 18338-ZJ1-841 STAY, MUFFLER (HIGH) •••••••• 4 18355-ZN1-003 ARRESTER, SPARK ••••••••••••• 5 90009-ZJ1-801 SCREW, (NELSON) ••••••••••••• 6 95701-06008-00 BOLT, FLANGE, 6X8 ••••••••••• 7 95701-08014-00 BOLT, FLANGE, 8X14 •••••••••• 8 95701-08020-00 BOLT, FLANGE, 8X20 ••••••••••...
  • Page 46 E-16-1 Ref. Part No. Description 1 18310-ZN1-802 MUFFLER COMP. (HIGH-L) •••••• 2 18321-ZN1-003 PROTECTOR, MUFFLER •••••••••• 3 18338-ZJ1-841 STAY, MUFFLER (HIGH) •••••••• 4 18355-ZN1-003 ARRESTER, SPARK ••••••••••••• 5 90009-ZJ1-801 SCREW, (NELSON) ••••••••••••• 6 95701-06008-00 BOLT, FLANGE, 6X8 ••••••••••• 7 95701-08014-00 BOLT, FLANGE, 8X14 •••••••••• 8 95701-08020-00 BOLT, FLANGE, 8X20 ••••••••••...
  • Page 47 E-18 Ref. Part No. Description 1 16700-ZL8-013 PUMP ASSY., FUEL •••••••••••• 2 16711-ZJ1-840 STAY, FUEL PUMP ••••••••••••• 3 16851-ZN1-000 TUBE, FUEL •••••••••••••••••• 16851-Z6G-003 TUBE, FUEL (FKM) •••••••••••• 4 16852-ZJ1-840 TUBE B, FUEL •••••••••••••••• 16852-ZJ1-850 •••••••••••••••••••••••••••• 16852-Z6C-841 TUBE B, FUEL (FKM) •••••••••• 16852-Z6C-851 ••••••••••••••••••••••••••••...
  • Page 48 E-18 Ref. Part No. Description 12 95002-02080 CLIP, TUBE (B8) ••••••••••••• 13 95002-02100 CLIP, TUBE (B10) •••••••••••• 14 95002-50000 CLIP, TUBE (C9) ••••••••••••• 95002-02080 CLIP, TUBE (B8) ••••••••••••• 15 95002-70000 CLIP, TUBE (C11) •••••••••••• 16 95003-25015-20 TUBE, VINYL, 9X11X150 (95003-25001-10M) 17 95002-40800-08 CLAMP, TUBE (D8) ••••••••••••...
  • Page 49 E-19 Ref. Part No. Description 1 19511-ZJ1-000 FAN, COOLING •••••••••••••••• 2 19513-ZJ1-000 PLATE, COOLING FAN SETTING •• 3 28452-ZJ1-801 GRID, SCREEN •••••••••••••••• 28452-ZJ1-811 GRID, SCREEN (P.T.O.) ••••••• 4 28454-ZJ1-801 HOLDER, SCREEN GRID ••••••••• 5 31110-ZJ1-840 FLYWHEEL COMP. •••••••••••••• 31110-ZJ1-850 •••••••••••••••••••••••••••• 6 90201-ZG3-000 NUT, FLANGE, 20MM •••••••••••...

  • Page 50: Ignition Coil

    E-20 Ref. Part No. Description 1 30500-ZJ1-844 COIL ASSY., IGNITION •••••••• (L. SIDE) 30500-ZJ1-845 •••••••••••••••••••••••••••• (L. SIDE) 2 30518-ZJ1-000 GROMMET, HIGH TENSION CORD •• 3 30550-ZJ1-844 COIL ASSY., IGNITION •••••••• (R. SIDE) 30550-ZJ1-845 •••••••••••••••••••••••••••• (R. SIDE) 4 30700-ZJ1-841 CAP ASSY., NOISE SUPPRESSOR • 5 31630-ZJ1-003 COIL ASSY., CHARGE (12V/3A) •...
  • Page 51 E-20 Ref. Part No. Description (7) 31740-ZJ1-861 DIODE ASSY., ENGINE STOP •••• 31740-ZJ1-852 •••••••••••••••••••••••••••• 31740-ZJ1-862 •••••••••••••••••••••••••••• 8 32763-PA0-000 CLAMP, CORD ••••••••••••••••• 10 90014-ZE6-000 BOLT, FLANGE, 6X35(CT200) ••• 11 90031-ZE1-000 BOLT, FLANGE, 6X32 •••••••••• 12 95701-06008-00 BOLT, FLANGE, 6X8 ••••••••••• IGNITION COIL Reqd.

  • Page 52: Starter Motor

    E-21 Ref. Part No. Description 1 30201-PH9-004 RING, SNAP (DENSO) •••••••••• 2 30202-PZ1-003 COLLAR SET, CLUTCH STOP ••••• 3 31200-ZJ1-841 MOTOR ASSY., STARTER •••••••• 31200-ZJ1-842 •••••••••••••••••••••••••••• 4 31203-PH9-004 LEVER, PINION DRIVE ••••••••• 5 31204-ZJ1-H01 SWITCH ASSY., MAGNET •••••••• 31204-ZJ1-H02 •••••••••••••••••••••••••••• 6 31206-ZG4-801 ARMATURE COMP.
  • Page 53 E-21 Ref. Part No. Description 17 31234-ZJ1-H01 COVER, TERMINAL ••••••••••••• 31234-ZJ1-H02 •••••••••••••••••••••••••••• 18 91002-ZG4-801 BEARING A ••••••••••••••••••• 19 94001-08200-0S NUT, HEX., 8MM •••••••••••••• 20 94111-08000 WASHER, SPRING, 8MM ••••••••• 21 94301-10120 DOWEL PIN, 10X12 •••••••••••• 22 95701-08110-00 BOLT, FLANGE, 8X110 ••••••••• STARTER MOTOR Reqd.
  • Page 54 E-22 Ref. Part No. Description 1 16263-883-W10 JOINT, ROD •••••••••••••••••• 2 16500-ZJ1-851 CONTROL ASSY. ••••••••••••••• 3 16534-ZN1-000 SPRING, STARTER ••••••••••••• 16534-ZN1-010 •••••••••••••••••••••••••••• 4 16551-ZJ1-840 ARM, GOVERNOR ••••••••••••••• 5 16555-ZN1-000 ROD, GOVERNOR ••••••••••••••• 6 16561-ZN1-800 SPRING, GOVERNOR (MANUAL) ••• 7 16562-ZN1-000 SPRING, THROTTLE RETURN •••••...
  • Page 55 E-22 Ref. Part No. Description 24 93500-05025-0A SCREW, PAN, 5X25 •••••••••••• 25 94050-06000 NUT, FLANGE, 6MM •••••••••••• 26 94251-10000 PIN, LOCK, 10MM ••••••••••••• CONTROL(1) Reqd. QTY Serial No. 1 -------- -------- BAF,BXF,TAF,TWF6,TXA2,TXF,TXF2,TXF4,TXF7,TXF8,TXW 1 -------- -------- BAF,BXF,TAF,TWF6,TXA2,TXF,TXF2,TXF4,TXF7,TXF8,TXW 1 -------- -------- BAF,BXF,TAF,TWF6,TXA2,TXF,TXF2,TXF4,TXF7,TXF8,TXW 2008.01.10 Parts catalogue code...
  • Page 56 E-22-1 Ref. Part No. Description 1 16263-883-W10 JOINT, ROD •••••••••••••••••• 2 16500-ZJ1-861 CONTROL ASSY. ••••••••••••••• 3 16500-ZJ1-871 CONTROL ASSY. ••••••••••••••• 4 16534-ZN1-000 SPRING, STARTER ••••••••••••• 16534-ZN1-010 •••••••••••••••••••••••••••• 5 16551-ZJ1-840 ARM, GOVERNOR ••••••••••••••• 6 16555-ZN1-000 ROD, GOVERNOR ••••••••••••••• 7 16561-ZN1-000 SPRING, GOVERNOR •••••••••••• 8 16562-ZN1-000 SPRING, THROTTLE RETURN •••••...
  • Page 57 E-22-1 Ref. Part No. Description 21 90016-ZG9-N30 SCREW, RECESSED, 5X25 ••••••• 22 90605-230-000 CIRCLIP, 5MM •••••••••••••••• 23 92301-04006-0H BOLT, RECESSED, 4X6 ••••••••• 24 92301-05016-0A BOLT, RECESSED, 5X16 •••••••• 25 92301-05025-0A BOLT, RECESSED, 5X25 •••••••• 26 93500-05025-0A SCREW, PAN, 5X25 •••••••••••• 27 94050-06000 NUT, FLANGE, 6MM ••••••••••••...
  • Page 58 E-22-2 Ref. Part No. Description 1 16263-883-W10 JOINT, ROD •••••••••••••••••• 2 16500-ZJ1-890 CONTROL ASSY. (AUTO THROTTLE) 3 16534-ZN1-000 SPRING, STARTER ••••••••••••• 16534-ZN1-010 •••••••••••••••••••••••••••• 4 16550-ZN1-000 ARM COMP., GOVERNOR ••••••••• 5 16551-ZJ1-840 ARM, GOVERNOR ••••••••••••••• 6 16555-ZN1-000 ROD, GOVERNOR ••••••••••••••• 7 16561-ZJ1-860 SPRING, GOVERNOR (MANUAL) •••...
  • Page 59 E-22-20 Ref. Part No. Description 1 36337-ZJ1-840 PLATE, SOLENOID ••••••••••••• 2 36350-ZN1-003 SOLENOID ASSY., ROTARY •••••• 3 90202-ZJ1-840 NUT, SPECIAL CAP •••••••••••• 4 90654-SA4-003 CLIP, WIRE HARNESS, 6MM(WHITE) 5 90686-459-711 PURSE, LOCK, 8MM •••••••••••• 6 91402-ZJ1-841 CLIP, PURSE LOCK •••••••••••• AUTO THROTTLE Reqd.
  • Page 60 E-23 Ref. Part No. Description 1 31604-ZJ7-800 BRACKET, REGULATOR RECTIFIER 2 31612-ZE2-003 CASE, CONTROL ••••••••••••••• 3 31614-ZE2-003 BRACKET, CASE MOUNTING •••••• 4 31620-ZG5-013 RECTIFIER ASSY., REGULATOR (20A) 31620-ZG5-023 •••••••••••••••••••••••••••• 31620-ZG5-033 •••••••••••••••••••••••••••• 5 31710-ZJ1-811 RECTIFIER ASSY. (10A) ••••••• 31710-ZJ1-812 •••••••••••••••••••••••••••• 6 31750-735-003 RECTIFIER COMP., REGULATOR (5A) 31750-735-013...
  • Page 61 E-23 Ref. Part No. Description 10 32183-ZJ0-890 HARNESS ASSY., REGULATOR 11 32340-Z6D-831 BOX ASSY., CONTROL •••••••••• 32340-Z6D-832 •••••••••••••••••••••••••••• 12 32345-ZJ1-812 PANEL COMP., CONTROL •••••••• 13 32349-ZJ1-840 STAY, CONTROL BOX ••••••••••• 14 32823-ZV5-003 PLUG, INNER CONNECTOR ••••••• 15 32902-892-003 BAND •••••••••••••••••••••••• 16 35100-ZJ1-841 SWITCH ASSY., COMBINATION •••...
  • Page 62 E-23 Ref. Part No. Description 21 90676-SA8-003 BAND, WIRE HARNESS, 150MM (BLUE) 22 91408-ZJ1-810 TUBE, CORD, 30MM •••••••••••• 23 91504-750-003 CLIP, WIRE HARNESS (BLACK) •• 24 93500-04012-0H SCREW, PAN, 4X12 •••••••••••• 25 94001-04080-0S NUT, HEX., 4MM •••••••••••••• 94001-04390-0S •••••••••••••••••••••••••••• 26 94111-04800 WASHER, SPRING, 4MM •••••••••...

  • Page 63: Oil Cooler

    E-24 Ref. Part No. Description 1 11513-MN5-300 COLLAR, 12MM •••••••••••••••• 2 15605-ZN1-000 COOLER ASSY., OIL ••••••••••• 3 15610-ZN1-000 COOLER COMP., OIL ••••••••••• 4 15613-ZN1-000 GRILLE, OIL COOLER •••••••••• 5 15614-ZN1-003 HOSE A, OIL ••••••••••••••••• 6 15616-ZN1-003 HOSE B, OIL ••••••••••••••••• 7 15676-ZN1-000 STAY, OIL COOLER ••••••••••••...
  • Page 64 E-28 Ref. Part No. Description 1 87101-ZN1-010 EMBLEM (24.0) ••••••••••••••• 2 87152-ZN1-010 LABEL, SPECIFICATION (GX670) 3 87516-ZH7-000 MARK, OPERATOR CAUTION (ENGLISH)(MADE IN JAPAN) 87516-ZH7-810 MARK, OPERATOR CAUTION (PICTOGRAPH)(MADE IN JAPAN) (1) (1) -------- -------- BAF,BDW,BDWN,BXF,BXF5,BXF9,TAF,TWF6,TXA2,TXF,TXF2,TXF4,TXF5,TXF7,TXF8 4 87532-ZH7-800 MARK, THROTTLE INDICATION ••• 5 89218-ZE1-000 WRENCH COMP., SPARK PLUG ••••...
  • Page 65 E-40 Ref. Part No. Description 1 87516-ZH7-000 MARK, OPERATOR CAUTION (ENGLISH)(MADE IN JAPAN) 87516-ZH7-800 MARK, OPERATOR CAUTION (FRENCH)(MADE IN JAPAN) 2 87516-ZH7-810 MARK, OPERATOR CAUTION (PICTOGRAPH)(MADE IN JAPAN) (1) (1) -------- -------- TDW,TDWN 3 87532-ZH7-800 MARK, THROTTLE INDICATION ••• 4 90617-SA0-003 CLIP, WIRE HARNESS ••••••••••...
  • Page 66 E-40-1 OTHER PARTS(CONTROL COVER) Ref. Part No. Description 1 16590-ZJ1-800 COVER ASSY., CONTROL •••••••• 2 16593-ZJ1-800 SEAL, CONTROL COVER ••••••••• 3 16594-ZJ1-800 COVER B, CONTROL •••••••••••• 4 19621-ZJ1-811 PROTECTOR, FAN COVER •••••••• 5 19636-ZJ1-800 BRACKET COMP., R. SHROUD •••• 6 19637-ZJ1-800 BRACKET COMP., L.
  • Page 67 EOP-2 Ref. Part No. Description 1 06192-ZJ1-800 KIT, WINTER ••••••••••••••••• 2 16590-ZJ1-800 COVER ASSY., CONTROL •••••••• 3 16593-ZJ1-800 SEAL, CONTROL COVER ••••••••• 4 16594-ZJ1-800 COVER B, CONTROL •••••••••••• 5 19621-ZJ1-811 PROTECTOR, FAN COVER •••••••• 6 19636-ZJ1-800 BRACKET COMP., R. SHROUD •••• 7 19637-ZJ1-800 BRACKET COMP., L.

  • Page 68: Part No. Index

    Part Number Address Page Ref. Part Number Address 06000 14000 06192-ZJ1-800 14100-Z6D-V40 14100-ZJ1-842 11000 14410-ZJ1-840 14431-ZE2-010 11300-ZJ1-842 14451-ZE1-013 11300-ZJ1-843 14568-Z6D-V40 11381-ZJ1-840 14568-ZJ1-841 11513-MN5-300 14576-ZJ1-840 11911-ZJ1-840 14711-ZE3-000 14721-ZE3-000 12000 14730-ZJ1-841 14730-ZJ1-842 12000-ZN1-405 14751-ZE2-003 12000-ZN1-406 14760-ZJ1-840 12000-ZN1-415 14764-ZJ1-840 12000-ZN1-416 14771-ZE2-000 12105-ZA0-701 14773-ZE2-000 12204-ZE2-306 14775-ZE2-010 12205-ZJ1-405...
  • Page 69 Part Number Address Page Ref. Part Number 30000 32183-ZJ0-890 32340-Z6D-831 30201-PH9-004 32340-Z6D-832 30202-PZ1-003 32345-ZJ1-812 30500-ZJ1-844 32349-ZJ1-840 30500-ZJ1-845 32763-PA0-000 30518-ZJ1-000 32823-ZV5-003 30550-ZJ1-844 32902-892-003 30550-ZJ1-845 30700-ZJ1-841 33000 31000 33713-GC2-000 31110-ZJ1-840 34000 31110-ZJ1-850 31200-ZJ1-841 34150-ZJ1-842 31200-ZJ1-842 34150-ZJ1-843 31203-PH9-004 31204-ZJ1-H01 35000 31204-ZJ1-H02 31206-ZG4-801 35100-ZJ1-841 31207-ZJ1-H01 35100-ZJ1-842 31211-PH9-004...
  • Page 70 Part Number Address Page Ref. Part Number Address 95701-06065-00 E3 37 28 95701-06075-09 D4 22 25 95701-08014-00 E8 95701-08016-00 E12 46 10 95701-08020-00 D2 20 23 41 27 63 13 64 14 95701-08050-00 D6 24 26 95701-08110-00 E16 50 22 95701-10080-00 D2 20 24 95801-06090-08 E3...

  • Page 71: Part Name Index

    Part name Address Page [ A ] ALERT UNIT, OIL •••••••••••••• E1 ARMATURE COMP. ••••••••••••••• E15 ARM COMP., CONTROL ••••••••••• F1 ARM COMP., GOVERNOR •••••••••• F5 ARM, GOVERNOR •••••••••••••••• F1 ARM, THROTTLE LINKAGE •••••••• E3 ARM, VALVE ROCKER •••••••••••• D10 ARRESTER, SPARK ••••••••••••••...
  • Page 72 Part name Address Page Ref. COVER ASSY., CRANKCASE ••••••• D5 COVER ASSY., OIL PUMP •••••••• D5 COVER B, CONTROL ••••••••••••• F13 COVER COMP., AIR CLEANER ••••• E6 COVER, BREATHER •••••••••••••• D3 COVER, FAN ••••••••••••••••••• D16 COVER, FUEL PUMP ••••••••••••• D16 COVER, HEAD ••••••••••••••••••...
  • Page 73 Part name Address Page PANEL COMP., CONTROL ••••••••• F8 PIN, DECOMPER •••••••••••••••• D10 PIN, GOVERNOR WEIGHT ••••••••• D6 PIN, LOCK, 10MM •••••••••••••• F2 PIN, LOCK, 8MM ••••••••••••••• D4 PIN, PISTON •••••••••••••••••• D9 PIN, SPRING, 6X28 •••••••••••• D11 PISTON ••••••••••••••••••••••• D9 PIVOT, ROCKER ARM ••••••••••••...
  • Page 75 FOREWORD INDEX ENGINE GROUP PART NUMBER INDEX PART NAME INDEX...
  • Page 76 Published by Honda Motor Co., Ltd. Printed in Japan E.O A 100.2008.01...
  • Page 77 NOTE A:PART NO.CHANGE D:NEWLY PROVIDED E:PART NO.DELETION K:REQUIRED NO.CORRECTION L:APPLICATION SERIAL NO.CORRECTION T:APPLICATION CORRECTION Z:REMARKS CHANGE Printed in Japan Reqd.QTY Description Serial No. 670 670 (SNORKEL) ------- ------- February 01,2008 13Z6G602 CODE NO. PARTS GX670U CATALOGUE GX670R NEWS NEWS NO. Parts catalogue code TXA2...
  • Page 78 670 670 ------- 1037871 ------- ------- 1037872 ------- ------- ------- 1037872 ------- ------- ------- 1037872 ------- February 03,2008 13Z6G602 CODE NO. PARTS GX670U CATALOGUE GX670R NEWS NEWS NO. Parts catalogue code BAF,BDW,BXF,BXF5,BXF9,TAF,TDW,TWF6,TXF,TXF2,TXF4,TXF5 TXF7,TXF8,TXF9,TXW,VXE1,VXE2,VXE4 BDWN,TDWN BAF,BDW,BXF,BXF5,BXF9,TAF,TDW,TWF6,TXF,TXF2,TXF4,TXF5 TXF7,TXF8,TXF9,TXW,VXE1,VXE2,VXE4 BDWN,TDWN BAF,BDW,BXF,BXF5,BXF9,TAF,TDW,TWF6,TXF,TXF2,TXF4,TXF5 TXF7,TXF8,TXF9,TXW,VXE1,VXE2,VXE4 BDWN,TDWN BAF,BDW,BXF,BXF5,BXF9,TAF,TDW,TWF6,TXF,TXF2,TXF4,TXF5...
  • Page 79 TXF9,TXW,VAB2,VXE1,VXE2 and VXE4 types sales information NOTE: This Parts Catalogue News explains only the parts of the different model that are produced to conform to addition of the GX670R-BAF,BXF,BXF5,BXF9,TWF6,TXA2,TXF,TXF2,TXF4,TXF5,TXF7,TXF8,TXF9,TXW,VAB2, VXE1,VXE2 and VXE4 types. As for the parts not listed on this Parts Catalogue News, use the parts of the GX670U-BAF,BXF,BXF5,BXF9,TWF6, TXA2,TXF,TXF2,TXF4,TXF5,TXF7,TXF8,TXF9,TXW,VAB2,VXE1,VXE2 and VXE4 types.
  • Page 80 BOOKNo.:13Z6G602 ・ Models, parts catalogue codes and applicable serial numbers Model Type GX670U Base type GX670R Additional type GX670U Base type GX670R Additional type GX670U BXF5 Base type GX670R BXF5 Additional type GX670U BXF9 Base type GX670R BXF9 Additional type...
  • Page 81 BOOKNo.:13Z6G602 Model Type GX670U TXF7 Base type GX670R TXF7 Additional type GX670U TXF8 Base type GX670R TXF8 Additional type GX670U TXF9 Base type GX670R TXF9 Additional type GX670U Base type GX670R Additional type GX670U VAB2 Base type GX670R VAB2 Additional type...
  • Page 82 3/16" Tapered Standard Air cleaner Snorkel Control box Winter kit PARTS CATALOGUE NEWS Base Additional Base Additional Base type type type type type GX670R GX670U GX670R GX670U BXF5 Base Additional Base Additional Base type type type type type GX670R GX670U...
  • Page 83 3/16" Tapered Standard Air cleaner Snorkel Control box Winter kit PARTS CATALOGUE NEWS Base Additional Base Additional Base type type type type type GX670R GX670U GX670R GX670U TXF4 TXF4 TXF5 TXF5 TXF7 Base Additional Base Additional Base type type type...
  • Page 84 Model GX670U Type Specifications 28.575mm Ø Straight 36.5mm Ø Straight Crankshaft 1/10" Tapered 3/16" Tapered Standard Air cleaner Snorkel Control box Winter kit PARTS CATALOGUE NEWS Base Additional Base Additional type type type type GX670R GX670U GX670R VXE2 VXE2 VXE4 VXE4...
  • Page 85 BOOKNo.:13Z6G602 Block Ref. Part No. Description PLUG, SPARK (BPR2ES)(NGK) ... 12000-ZN1-416 BARREL ASSY., CYLINDER ... 35480-ZJ1-842 SWITCH ASSY., OIL LEVEL ... 14730-ZJ1-842 LIFTER ASSY., VALVE ... E-12 34150-ZJ1-843 ALERT UNIT, OIL ... E-15-1 AIR CLEANER (SNORKEL) E-15-1 JOINT B, CONNECTING TUBE ... 17415-Z6G-000 JOINT B, CONNECTING TUBE ...
  • Page 86 BOOKNo.:13Z6G602 Block Ref. Part No. Description E-23 31620-ZG5-033 RECTIFIER ASSY., REGULATOR 32340-Z6D-832 BOX ASSY., CONTROL ... 35100-ZJ1-842 SWITCH ASSY., COMBINATION ... E-28 LABEL, SPECIFICATION (GX670) . PARTS CATALOGUE NEWS Reqd.QTY Base Part No. 670 670 31620-ZG5-023 (20A) BXF9,TWF6 32340-Z6D-831 TWF6 35100-ZJ1-841 TWF6 87152-ZN1-010...
  • Page 87 Serial No. 670 670 ------- 1039076 1039077 ------- ------- ------- 1039077 ------- ------- ------- 1039077 ------- ------- ------- May 04,2008 13Z6G602 CODE NO. PARTS GX670U CATALOGUE GX670R NEWS NEWS NO. Parts catalogue code TXA2 TXA2 TXA2 TXA2 TXA2 TXA2 TXA2...
  • Page 88 1050819 ------- 1050819 ------- 1050818 1035450 ------- 1035450 1050818 ------- 1050818 1036000 1050818 ------- 1050818 July 07,2008 13Z6G602 CODE NO. PARTS GX670U CATALOGUE GX670R NEWS NEWS NO. Parts catalogue code BDWN,TDWN BXF9,TWF6 BAF,BDW,BXF,BXF5,TAF,TDW,TXF,TXF2,TXF4,TXF5,TXF7,TXF8 TXF9,TXW,VAB2,VXE1,VXE2,VXE4 TXA2 BAF,BDW,BDWN,BXF,BXF5,TAF,TDW,TDWN,TXA2,TXF,TXF2,TXF4 TXF5,TXF7,TXF8,TXF9,TXW,VAB2,VXE1,VXE2,VXE4 BDWN,TDWN BXF9,TWF6 BAF,BDW,BXF,BXF5,TAF,TDW,TXF,TXF2,TXF4,TXF5,TXF7,TXF8...
  • Page 89 BOOKNo.:13Z6G602 Block Ref. Note Part No. 16855-Z6C-842 16855-Z6C-852 NOTE A:PART NO.CHANGE D:NEWLY PROVIDED E:PART NO.DELETION K:REQUIRED NO.CORRECTION L:APPLICATION SERIAL NO.CORRECTION T:APPLICATION CORRECTION Z:REMARKS CHANGE PARTS CATALOGUE NEWS Reqd.QTY Description Serial No. 670 670 1050819 ------- 1050819 ------- 1050819 ------- Parts catalogue code BAF,BDW,BDWN,BXF,BXF5,TAF,TDW,TDWN,TXF,TXF2,TXF4,TXF5 TXF7,TXF8,TXF9,TXW,VAB2,VXE1,VXE2,VXE4 BXF9,TWF6...
  • Page 90 NOTE A:PART NO.CHANGE D:NEWLY PROVIDED E:PART NO.DELETION K:REQUIRED NO.CORRECTION L:APPLICATION SERIAL NO.CORRECTION T:APPLICATION CORRECTION Z:REMARKS CHANGE Printed in Japan Reqd.QTY Description Serial No. 670 670 ------- 1057372 (1) (1) ------- 1057372 October 16,2008 13Z6G602 CODE NO. PARTS GX670U CATALOGUE GX670R NEWS NEWS NO. Parts catalogue code TXF7,TXF8 BAF,BDW,BDWN,BXF,BXF5,TAF,TDW,TDWN,TWF6,TXA2,TXF,TXF2 TXF4,TXF5,TXF9,TXW,VAB2,VXE1,VXE2,VXE4...
  • Page 91 BOOKNo.:13Z6G602 Block Ref. Note Part No. 18310-ZJ1-802 18321-ZN1-003 PROTECTOR, MUFFLER ... 18321-ZJ1-000 PROTECTOR, MUFFLER (HIGH) ... 18338-ZJ1-841 STAY, MUFFLER (HIGH) ... 18338-ZJ1-000 18355-ZN1-003 ARRESTER, SPARK ... NOTE A:PART NO.CHANGE D:NEWLY PROVIDED E:PART NO.DELETION K:REQUIRED NO.CORRECTION L:APPLICATION SERIAL NO.CORRECTION T:APPLICATION CORRECTION Z:REMARKS CHANGE PARTS CATALOGUE NEWS Reqd.QTY Description...
  • Page 92 BOOKNo.:13Z6G602 Block Ref. Note Part No. 90009-ZJ1-801 SCREW (NELSON) ... 18355-ZJ1-000 ARRESTER, SPARK ... 90050-ZE1-000 SCREW, TAPPING, 5X8 ... NOTE A:PART NO.CHANGE D:NEWLY PROVIDED E:PART NO.DELETION K:REQUIRED NO.CORRECTION L:APPLICATION SERIAL NO.CORRECTION T:APPLICATION CORRECTION Z:REMARKS CHANGE PARTS CATALOGUE NEWS Reqd.QTY Description Serial No.
  • Page 93 NOTE A:PART NO.CHANGE D:NEWLY PROVIDED E:PART NO.DELETION K:REQUIRED NO.CORRECTION L:APPLICATION SERIAL NO.CORRECTION T:APPLICATION CORRECTION Z:REMARKS CHANGE Honda Motor Co., Ltd. Service Division Printed in Japan Reqd.QTY Description 670 670 ------- 1062141 1062142 ------- CODE NO. PARTS CATALOGUE NEWS NEWS NO. Serial No. Parts catalogue code TXA2 TXA2 13Z6G602 GX670U GX670R...
  • Page 94 BOOKNo.:13Z6G602 Block Ref. Note Part No. E-16 18310-ZJ1-004 MUFFLER COMP. (HIGH-R)(FUTABA) (FOR SILVER MUFFLER) 18310-ZN1-003 MUFFLER COMP. (HIGH-R)(NELSON) (FOR BLACK MUFFLER) 18321-ZJ1-000 PROTECTOR, MUFFLER (HIGH) (FOR SILVER MUFFLER) 18321-ZN1-003 PROTECTOR, MUFFLER (HIGH) (FOR BLACK MUFFLER) 18338-ZJ1-000 STAY, MUFFLER (HIGH) (FOR SILVER MUFFLER) 18338-ZJ1-841 (FOR BLACK MUFFLER) 18355-ZN1-003...
  • Page 95 BOOKNo.:13Z6G602 Block Ref. Note Part No. E-16-1 MUFFLER (HIGH-L) Ref. (Relative ref. Number) No. LON Description 11 3131C3 MUFFLER ASSEMBLY, EXHAUST ････ E-16-1 18310-ZJ1-802 MUFFLER COMP. (HIGH-L)(FUTABA) (FOR SILVER MUFFLER) (FOR SILVER MUFFLER) 18310-ZN1-802 MUFFLER COMP. (HIGH-L)(NELSON) (FOR BLACK MUFFLER) (FOR BLACK MUFFLER) (FOR BLACK MUFFLER) (FOR BLACK MUFFLER)
  • Page 96 BOOKNo.:13Z6G602 Block Ref. Note Part No. 18321-ZN1-003 PROTECTOR, MUFFLER (HIGH) (FOR BLACK MUFFLER) (FOR BLACK MUFFLER) (FOR BLACK MUFFLER) (FOR BLACK MUFFLER) 18321-ZJ1-000 *PARTS NO. DELETION 18338-ZJ1-000 STAY, MUFFLER (HIGH) (FOR SILVER MUFFLER) (FOR SILVER MUFFLER) 18338-ZJ1-841 (FOR BLACK MUFFLER) (FOR BLACK MUFFLER) (FOR BLACK MUFFLER) (FOR BLACK MUFFLER)
  • Page 97 BOOKNo.:13Z6G602 Block Ref. Note Part No. 90050-ZE1-000 *PARTS NO. DELETION 93901-250J0 SCREW, TAPPING, 5X8 (FOR SILVER MUFFLER) 18300-ZJ1-890 MUFFLER ASSY. (HIGH-L)(FUTABA) NOTE A:PART NO.CHANGE D:NEWLY PROVIDED E:PART NO.DELETION K:REQUIRED NO.CORRECTION L:APPLICATION SERIAL NO.CORRECTION T:APPLICATION CORRECTION Z:REMARKS CHANGE Reqd.QTY Description Serial No. 670 670 (1) (1) (SILVER MUFFLER)

This manual is also suitable for:

Gx670u

Table of Contents