Related Manuals for Yanmar YDG5001SE
Summary of Contents for Yanmar YDG5001SE
- Page 1 OPERATION MANUAL OPERATION MANUAL Be sure to read this manual for safe and Be sure to read this manual for safe and proper operation. proper operation. Store this manual carefully after use. Store this manual carefully after use.
- Page 2 Yanmar dealer. WARNING: WARNING: The Yanmar generator is designed to give saf The Yanmar generator is designed to give saf e e and dependable and dependable service provided that it is service provided that it is operated accord operated according to instructions.
-
Page 3: Tips On Safety
1. Handling your generator 1. Handling your generator TIPS ON SAFETY TIPS ON SAFETY WARNING: WARNING: 1. 1. PREVENTING PREVENTING FIRES FIRES Never add fuel to the fuel Never add fuel to the fuel tank while the engine is running. tank while the engine is running. - Page 4 1. Handling your generator 5. ELECTRIC SHOCKS, SHORT CIRCUITS In order to avoid electric shocks or short circuiting, do not touch the generator when either it or your hands are wet. This generator is not waterproof, so it should not be used in a place exposed to rain, snow or water sprays.
-
Page 5: Other Safety Tips
1. Handling your generator 6. OTHER SAFETY TIPS Know how to stop the generator quickly and understand how to operate all of the controls. Never permit anyone to operate the generator without proper instruction. Always wear suitable clothes when operating its generator. Do not operate under influence of alcohol. - Page 6 1. Handling your generator CONTENST 1. Specification …………………………………………………………. 1 2. Part Names …………………………………………………………… 2 3. Handling your generator ………………………………………… 3 4. Preparation for starting ………………………………………….. 5 5. How to start your generator …………………………………… 12 6. Operating your generator ………………………………………. 14 7.
- Page 7 4. Preparation for starting 5. How to start your generator Direction to Open 2). Turn the starting key clockwise to “START” position Turn the starting key 3). Remove your hand from the key as soon as the engine starts 4). If the engine doesn’t start after 10 seconds, wait a while (for about 15 seconds) before attempting to start again.
- Page 8 5. How to start your generator 6. Operating your generator Caution: If the starting motor is turned for too long, the battery will go flat. Always leave the starting key turned on, in the “ON” position, while the engine is running. 6.
- Page 9 (3) What about the color of the exhaust gas? (Is it black or too white?) If you notice any of the above, stop the engine and contact your nearest Yanmar dealer. WARNING: If the engine has been running, the muffler will be very hot.
- Page 10 7. Load 8. Stopping your generator When a large capacity battery is charged, excessive current flows (the value varies depending on the discharging condition), and the fuse for the direct current will burnout. When charging a battery, the total load of the AC and DC ...
- Page 11 “CLOSE” position (SE type only) or loosen the nut of high pressure fuel pipe on the pump side to stop the engine. In such case, contact your nearest Yanmar to locate the cause and have them e the generator. Loosen...
- Page 12 The mark ( ) indicates that special tools and skills are required. Consult your Yanmar dealer. WARNING: Shut off the engine before performing any maintenance. If the engine must be run, make sure the area is well ventilated.
- Page 13 9. Periodic checks and maintenance 14. Electrical circuit diagram 14. Electrical circuit diagram - No illustration intended for this section -...
- Page 15 Date of purchase Place of purchase (name of dealer)
Need help?
Do you have a question about the YDG5001SE and is the answer not in the manual?
Questions and answers