Page 1
All manuals and user guides at all-guides.com ORDER NO. MD0101010C3 CD Stereo System SA-AK52 Colour (S)... Silver Type Area (GC)...Asia, Latin America, Africa and Middle Near East TAPE SECTION : AR2 MECHANISM SERIES CD SECTION : RAE0152Z-3 TRAVERSE DECK SERIES...
Mass 9.0 kg Beam source/wave length Semiconductor laser/780 nm SYSTEM Number of channels Stereo SC-AK52(GC) Music Center: SA-AK52(GC) Frequency response 20 Hz - 20 kHz (+1, -2 dB) Speaker: SB-AK52(GC) Wow and flutter Below measurable limit Notes: Digital filter 8 fs 1.
All manuals and user guides at all-guides.com SA-AK52 1 Before Use Be sure to disconnect the mains cord before adjusting the voltage selector. Use a minus(-) screwdriver to set the voltage selector (on the rear panel) to the voltage setting for the area in which the unit will be used.
All manuals and user guides at all-guides.com SA-AK52 5 Handling Precautions For Traverse Deck The laser diode in the traverse deck (optical pickup) may break down due to potential difference caused by static electricity of clothes or human body. So, be careful of electrostatic breakdown during repair of the traverse deck (optical pickup).
All manuals and user guides at all-guides.com SA-AK52 6 Precaution of Laser Diode Caution : This product utilizes a laser diode with the unit turned "ON", invisible laser radiation is emitted from the pick up lens. Wavelength : 780 nm Maximum output radiation power from pick up : 100 µW/VDE...
All manuals and user guides at all-guides.com SA-AK52 8 Operation Checks and Main Component Replacement Procedures “ATTENTION SERVICER” Some chassis components may have sharp edges. Be careful when disassembling and servicing. 1. This section describes procedures for checking the operation of the major printed circuit boards and replacing the main components.
Page 9
All manuals and user guides at all-guides.com SA-AK52 8.1. Disassembly and assembly main unit Step 1 Remove 3 screws each side and 5 screws at rear panel. Step 2 Remove the Top Cabinet Step 3 Remove T-bracket. Step 4 Remove 2 screws each side of the inner chassis and a screw at the rear panel.
Page 10
All manuals and user guides at all-guides.com SA-AK52 Step 4 : Remove the CD lid in the direction of the arrow. Step 5 : Release the two catches shown above to remove the Step 1 : Use a hexagonal wrench and turn clockwise to release front cabinet from the CD Traverse Unit.
Page 11
All manuals and user guides at all-guides.com SA-AK52 Step 7 Remove 2 screws from bottom and 2 screw beside inner bracket to push forward to release the front panel. Step 8 To release inner bracket, remove 4 screws. 8.1.1. Checking for Panel, Main and Deck P.C.B.
Page 12
All manuals and user guides at all-guides.com SA-AK52 8.1.2. Checking for Power P.C.B. 8.1.3. For Live Troubleshooting Procedure Step 6 : Reconnect all connectors. Step 7 : Use extension 14pin FFC wire for CN309. Step 8 : Supply power for troubleshooting.
Page 13
All manuals and user guides at all-guides.com SA-AK52 8.2. Main Component Replacement Procedures 8.2.1. Replacement of the Traverse Deck Step 1 Follow the procedures in ‘Disassembly of the Traverse Unit’ ( Step 1 - Step 4 ). Step 5 Remove the flexible cable CN701.
Page 14
All manuals and user guides at all-guides.com SA-AK52 Note: Before installing the CD servo P.C.B., move the optical pickup towards the outer edge from the marking (black triangle). [Otherwise, the reset detect switch (S701) mounted on the CD servo P.C.B. may be damaged.] 8.2.2.
Page 15
All manuals and user guides at all-guides.com SA-AK52 8.3. Disassembly and assembly of the Traverse Unit Step 1 Push the lever from position A to B. Step 2 Pull the stopper (black) in the direction of arrow 1 and push the lever in the direction of arrow 2.
Page 16
All manuals and user guides at all-guides.com SA-AK52 8.4. Disassembly and assembly of the Disc Tray (clockwise), and then open the disc tray fully. Step 2 With lifting the claw in the direction of arrow 1, draw the Step 6 Upset the CD changer unit again.
Page 17
All manuals and user guides at all-guides.com SA-AK52 Step 1 Slide the drive rack fully in the direction of the arrow. Step 4 Holding the disc tray manually, rotate the pulley gear in the direction of arrow. Step 5 Rotate the gear 5 or 6 times manually, and then push the disc tray.
All manuals and user guides at all-guides.com SA-AK52 9 Self-Diagnostic Function 9.1. Self-diagnostic display This unit is equipped with a self-diagnostic display function which, if a problem occurs, will display an error code corresponding to the problem. Use this function when performing maintenance on the unit.
All manuals and user guides at all-guides.com SA-AK52 7. Press “ /TUNE MODE” to indicate Error Code. • If several problem exist, error code will change each time when “ /TUNE MODE” is pressed. (e.g. F15 → F26 → F16 ..etc).
All manuals and user guides at all-guides.com SA-AK52 11 CD Test Mode Function This CD test mode is provided to check CD unit without 11.2. CD Automatically Adjustment connecting to changer loading mechanism. This mode shall result indication operate CD PLAY with CD unit being connected only and CD Automatic Alignment result is shown on FL display.
Page 21
All manuals and user guides at all-guides.com SA-AK52 12.1.3. Bias and Erase Voltage Check 1. Set the unit “AUX” position. 2. Insert the Normal blank tape (QZZCRA) into DECK 2 and the unit to “REC” mode (use “ REC/STOP” key).
Page 22
All manuals and user guides at all-guides.com SA-AK52 12.2.2. AM-RF Alignment SIGNAL GENERATOR OR SWEEP RADIO DIAL SETTING INDICATOR ADJUSTMENT REMARKS GENERATOR (ELECTRONIC (Shown in Fig.3) VOLTMETER CONNECTIONS FREQUENCY OSCILLOSCOPE) Fashion a loop of 522 kHz Tuning capacitor fully closed Headphones Jack (32Ω) Z152 (GC), Adjust for maximum output.
Page 23
All manuals and user guides at all-guides.com SA-AK52 12.3. Alignment Points Cassette Deck section Tuner section...
All manuals and user guides at all-guides.com SA-AK52 14 Terminal Function of ICs 14.1. IC701 (AN8885SBE1) Servo Amplifier Pin No. Mark Function Pin No. Mark Function Tracking signal input 1 /RFDET NRFDET output (“L” : detection) Tracking signal input 2...
Page 26
All manuals and user guides at all-guides.com SA-AK52 Mark Function Mark Function EFM signal output CLVS Spindle servo phase synchronizing signal output PLL extraction clock output ("H" : CLV, "L" : rough servo) (fPCK = 4.321 MHz during normal playback)
Page 27
All manuals and user guides at all-guides.com SA-AK52 Pin No. Mark Function CNVSS Flash mode terminal (connect to ground) /RESET RESET input XCOUT 32.768 kHz sub clock XCIN 32.768 kHz sub clock Ground (0V) 4.19 MHz main clock XOUT 4.19 MHz main clock...
All manuals and user guides at all-guides.com SA-AK52 15 Block Diagram OPTICAL PICKUP IC701 AN8885SBE1 SERVO AMP SEMICONDUCTOR LASER OFTR DET. TENV Q701 LASER OFTR POWER DRIVE OFTR DET. LDON /RFDET /RFDET DET. PHOTO DETECTOR FEOUT VCBA Subtracter VREF Subtracter VCBA N.C.
Page 29
All manuals and user guides at all-guides.com SA-AK52 FM ANT CF201 CF202 Z120 Q101 MIXER IF AMP RF AMP BUFFER IC101 LA1833NMNTLM FM/AM IF AMP, DET/AM OSC, MIX/FM MPX (FM) Q152 Q151 SWITCH SWITCH Z151 COIL COIL DECODER RF AMP...
Page 30
All manuals and user guides at all-guides.com SA-AK52 TA7291P MOTOR DRIVE Vs 8 OUT1 OUT2 POWER SUPPLY CONTROL Q604 STATUS SWITCH Q605 SUBQ SWITCH D614 ST/DO Q350 Q606 SWITCH BLKCK (PLUNGER SWITCH SUPPLY) /CDRST Q351 RESTSW SWITCH (PLUNGER SUPPLY) D619...
Page 31
All manuals and user guides at all-guides.com SA-AK52 IC1001 AN7348STA-E1 P.B. EQ /TPS AMP Q1012(Q1013) REC AMP/ALC (DECK 1) IC1003 P.B. HEAD LCH MUTING 24(23) BA4558FE2 1(2) 20(5) BUFFER 22(3) Q1014 (Q1015) (DECK 2) 21(4) Q1024 R/P HEAD LCH BUFFER...
Page 32
All manuals and user guides at all-guides.com SA-AK52 FILTER FILTER 23~27 (10) (13) (14) IC302 M5218AP Q400(Q200) (31) BUFFER MUTING OUTL(R) 45(46) INLC(R) Q300 MUTING IC301 SWITCH BH3874AKS2 ASP IC Q309,Q310 51(52) RECL(R) MUTING SWITCH 43(44) INLB(R) 47(48) IC304 INLD(R)
Page 33
All manuals and user guides at all-guides.com SA-AK52 SIGNAL LINES MAIN SIGNAL LINE CD SIGNAL LINE AM SIGNAL LINE PLAYBACK SIGNAL LINE H_OUT_L(R) FM OSC SIGNAL LINE AM OSC SIGNAL LINE FM & AM SIGNALS LINE RECORDING SIGNAL LINE AUX SIGNAL LINE...
All manuals and user guides at all-guides.com SA-AK52 16 Schematic Diagram (All schematic diagrams may be modified at any time with the S944 3D AI EQ switch development of the new technology) S945 Super sound EQ switch S950 Disc 2 switch...
Page 35
All manuals and user guides at all-guides.com SA-AK52 SCHEMATIC DIAGRAM -1 : +B SIGNAL LINE : +B SIGNAL LINE : CD SIGNAL LINE CD SERVO CIRCUIT R701 OPTICAL PICKUP CIRCUIT Q701 C701 2SA1037AKSTX 6.3V33 3.2V C703 LASER POWER DRIVE LASER DIODE 6.3V100...
Page 36
All manuals and user guides at all-guides.com SA-AK52 SCHEMATIC DIAGRAM - 2 : +B SIGNAL LINE : +B SIGNAL LINE : CD SIGNAL LINE R717 C727 50V1 C725 1000P R721 C726 1000P R718 C728 50V1 C731 6.3V220 CN702 Lch OUT...
Page 37
All manuals and user guides at all-guides.com SA-AK52 SCHEMATIC DIAGRAM - 3 : AM SIGNAL LINE : FM SIGNAL LINE : +B SIGNAL LINE : FM OSC SIGNAL LINE : AM OSC SIGNAL LINE MAIN/TUNER CIRCUIT Z120 (RAL0029) C103 0.01...
Page 38
All manuals and user guides at all-guides.com SA-AK52 SCHEMATIC DIAGRAM - 4 : AM SIGNAL LINE : FM SIGNAL LINE : +B SIGNAL LINE : FM OSC SIGNAL LINE : AM OSC SIGNAL LINE : FM/AM SIGNAL LINE R104 CF202...
Page 39
All manuals and user guides at all-guides.com SA-AK52 SCHEMATIC DIAGRAM - 5 : +B SIGNAL LINE : MAIN SIGNAL LINE : FM/AM SIGNAL LINE : -B SIGNAL LINE : RECORD SIGNAL LINE : CD SIGNAL LINE PANEL CIRCUIT (CP605) ON SCHEMATIC DIAGRAM-9...
Page 40
All manuals and user guides at all-guides.com SA-AK52 SCHEMATIC DIAGRAM - 6 : -B SIGNAL LINE : +B SIGNAL LINE : MAIN SIGNAL LINE PANEL CIRCUIT (CP607) ON SCHEMATIC DIAGRAM-9 CN302 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10...
Page 41
All manuals and user guides at all-guides.com SA-AK52 SCHEMATIC DIAGRAM - 7 : +B SIGNAL LINE : -B SIGNAL LINE : MAIN SIGNAL LINE (-29.86V)<-29.85V> (-44.1V)<-43.8V> -29.89V((-29.84V)) -43.9V((-42.9V)) RL1N4003S-P [-29.94V] [-44.2V] R332 D313 C359 R331 (-30.45V) 0.01 4.7K <-30.48V> Q308 -30.5V...
Page 42
All manuals and user guides at all-guides.com SA-AK52 SCHEMATIC DIAGRAM - 7 : +B SIGNAL LINE : MAIN SIGNAL LINE : CD SIGNAL LINE PANEL CIRCUIT FL600 RSL0310-F C600 35V22 TACT SWITCH (1) CIRCUIT IC602 Z940 BU2090AF-E2 RCD37142TC5 IO EXP 2 REMOTE CONTROL SENSOR <0.45V>...
Page 43
All manuals and user guides at all-guides.com SA-AK52 SCHEMATIC DIAGRAM - 8 DECK CIRCUIT : +B SIGNAL LINE : MAIN SIGNAL LINE (CN1001) ON SCHEMATIC DIAGRAM-10 : -B SIGNAL LINE : CD SIGNAL LINE H600 Q603 2SA933SSTA SWITCH C634 DECK +6V SUPPLY...
Page 44
All manuals and user guides at all-guides.com SA-AK52 SCHEMATIC DIAGRAM - 9 : +B SIGNAL LINE : PLAYBACK SIGNAL LINE : -B SIGNAL LINE : RECORD SIGNAL LINE DECK CIRCUIT R1055 2.2K C1038 R1098 220P R1017 8.2K CS1001 R1095 100K...
Page 45
All manuals and user guides at all-guides.com SA-AK52 SCHEMATIC DIAGRAM - 10 : +B SIGNAL LINE : PLAYBACK SIGNAL LINE : -B SIGNAL LINE : RECORD SIGNAL LINE MAIN CIRCUIT (CN304) ON SCHEMATIC DIAGRAM-4 H1001/W1001 10 9 R1072 R1077 R1074...
Page 46
All manuals and user guides at all-guides.com SA-AK52 SCHEMATIC DIAGRAM - 12 : +B SIGNAL LINE : -B SIGNAL LINE : MAIN SIGNAL LINE POWER CIRCUIT IC500 IC500 RSN309W44B POWER IC DISP -VCC +VCC -VCC +VCC L IN R IN...
Page 47
All manuals and user guides at all-guides.com SA-AK52 SCHEMATIC DIAGRAM -13 AC TRANSFORMER CIRCUIT (9.74V) <9.74V> Q573 (15.04V) <15.04V> 10.04V ((9.60V)) 15.05V ((14.94V)) D570 R570 R571 R572 2SD2144STA [10.23V] [15.02V] Q573 REGULATOR (8.73V) <8.73V> 9.07V ((8.62V)) (5.92V) <5.96V> [9.15V] 5.96V ((5.94V))[5.97V]...
All manuals and user guides at all-guides.com SA-AK52 17 Printed Circuit Board Note: Circuit board diagrams may be modified at any time with the development of new technology. CD SERVO P.C.B (REPX0192D) (RF) TP20 X701 TJ701 TP23 C717 R714 TP19...
Page 49
All manuals and user guides at all-guides.com SA-AK52 MAIN / TUNER P.C.B. (REPX0250A) FM LOOP ANTENNA MW ANT SW ANT 75OHMS JK101 R402 R171 C374 C402 L104 C202 R401 C159 R202 J260 C376 Z120 (TUNER PACK) JK305 R156 R168 R165...
Page 56
All manuals and user guides at all-guides.com SA-AK52 POWER P.C.B. (REPX0233B) HIGH-CHANNEL LOW-CHANNEL SPEAKERS SPEAKERS J508 J513 J524 C526 C530 J529 R535 R537 J541 C524 C528 R534 C500 J534 J540 J520 R502 CP501 J547 R516 C505 E500 D508 D503 C508...
Page 57
All manuals and user guides at all-guides.com SA-AK52 AC TRANSFORMER P.C.B. (REPX0251A) CAUTION RISK OF ELECTRIC SHOCK AC VOLTAGE LINE. PLEASE DO NOT TOUCH THIS P.C.B RL502 T501 (POWER TRANSFORMER) D574 R582 Q572 D580 R580 R574 W500 C578 R577 D576...
All manuals and user guides at all-guides.com SA-AK52 18 Wiring Connection Diagram H-CHANNEL L-CHANNEL FM ANT AM ANT SPEAKERS SPEAKERS OPTICAL L- R- L+ R+ L- R- L+ R+ SOLDER SIDE JK501 JK500 JK101 TUNER PACK P.C.B CN300 CD LOADING P.C.B Z101 MIC P.C.B...
All manuals and user guides at all-guides.com SA-AK52 20 Parts Location and Replacement Parts List Notes: • Important safety notice: Components identified by mark have special characteristics important for safety. Furthermore, special parts which have purposes of fire-retardent (resistors), high-quality sound (capacitors), low noise (resistors), etc are used.
Page 61
All manuals and user guides at all-guides.com SA-AK52 20.1. Deck Mechanism (RAA3408) 20.1.1. Deck Mechanism Parts Location...
Page 62
All manuals and user guides at all-guides.com SA-AK52...
Page 63
All manuals and user guides at all-guides.com SA-AK52 20.1.2. Deck Mechanism Parts List Ref. No. Part No. Part Name & Description Remarks CASSETTE DECK RED0050 R/P HEAD BLOCK UNIT 101-1 RHE5152ZB SCREW RED0051 P/B HEAD BLOCK UNIT 102-1 RHE5152ZB SCREW...
Page 64
All manuals and user guides at all-guides.com SA-AK52 20.2. CD Loading Mechanism (RD-DAC026-S) 20.2.1. CD Loading Mechanism Parts Location...
Page 65
All manuals and user guides at all-guides.com SA-AK52...
Page 66
All manuals and user guides at all-guides.com SA-AK52 20.2.2. CD Loading Mechanism Parts List Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks TRAVERSE DECK XTN2+6G SCREW RMX0141 PUSH SPACER RML0517...
Page 67
All manuals and user guides at all-guides.com SA-AK52 20.3. Cabinet 20.3.1. Cabinet Parts Location...
Page 68
All manuals and user guides at all-guides.com SA-AK52...
Page 69
All manuals and user guides at all-guides.com SA-AK52...
Page 70
All manuals and user guides at all-guides.com SA-AK52 20.3.2. Cabinet Parts List Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks CABINET AND CHASSIS RKWX0156A-1 FL FILTER RMBX0016-1 CASS. OPEN SPRING...
Page 71
All manuals and user guides at all-guides.com SA-AK52 Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks Q307 KRC111STA TRANSISTOR D316 RL1N4003S-P DIODE Q308 2SB621ARSTA TRANSISTOR D318 UDZSTE177R5B DIODE Q309 KTA1504GRTA...
Page 72
All manuals and user guides at all-guides.com SA-AK52 Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks D1003 1SS355TE17 DIODE CN900 RJT066H12F 12P BTB CONNECTOR D1004 UDZTE173R6B DIODE CN1001 RJS8T7ZA 8P MOLEX...
Page 73
All manuals and user guides at all-guides.com SA-AK52 Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks EYF52BC FUSE HOLDER R104 ERJ3GEYJ102V 1K 1/16W EYF52BC FUSE HOLDER R105 ERJ3GEYJ471V 470 1/16W...
Page 74
All manuals and user guides at all-guides.com SA-AK52 Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks R225 ERJ3GEYJ392V 3.9K 1/16W R401 ERJ3GEYJ272V 2.7K 1/16W R226 ERJ3GEYJ121V 120 1/16W R402 ERJ3GEYJ103V...
Page 75
All manuals and user guides at all-guides.com SA-AK52 Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks R583 RSFMB40KT-L FUSE PROTECTOR R676 ERDS2TJ472T 4.7K 1/4W R600 ERDS2TJ472T 4.7K 1/4W R677 ERDS2TJ681T...
Page 76
All manuals and user guides at all-guides.com SA-AK52 Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks R931 ERDS2TJ334T 330K 1/4W R1047 ERJ3GEYJ102V 1K 1/16W R932 ERDS2TJ822T 8.2K 1/4W R1048 ERJ3GEYJ102V...
Page 77
All manuals and user guides at all-guides.com SA-AK52 Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks C107 ECUV1H472KBV 4700P 50V C310 ECUV1C473KBV 0.047 16V C109 ECUV1H102KBV 1000P 50V C311 ECEA1HKAR33B 0.33 50V...
Page 78
All manuals and user guides at all-guides.com SA-AK52 Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks C434 ECEA1HKA4R7B 4.7 50V C629 ECBT1H561KB5 560P 50V C435 ECEA1HKA2R2B 2.2 50V C630 ECBT1H561KB5...
Page 79
All manuals and user guides at all-guides.com SA-AK52 Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks C919 ECBT1H101KB5 100P 50V C920 ECBT1E223ZF5 0.022 25V CHIP JUMPER C921 ECBT1E223ZF5 0.022 25V...
Page 80
All manuals and user guides at all-guides.com SA-AK52 20.5. Packing Materials & Accessories Parts List Ref. No. Part No. Part Name & Description Remarks Ref. No. Part No. Part Name & Description Remarks PACKING MATERIALS N2QAGB000004 REMOTE CONTROLLER A1-1 RKK-HTR0280...