Maintenance Schedule; Refueling - Honda GXR120UT Owner's Manual

37ZDJ6010.fm 7 ページ ２０１９年１１月１８日 月曜日 午後３時５７分

MAINTENANCE SCHEDULE

REGULAR SERVICE PERIOD (3) Each
Perform at every
indicated month or
operating hour interval,
whichever comes first.
ITEM
Engine oil Check level
Change
Air cleaner Check
Clean
Replace
Spark plug Check-adjust
Replace
Timing belt Check
Spark arrester Clean
(applicable
types)
Idle speed Check-adjust
Valve clearance Check-adjust
Combustion chamber Clean
Fuel tank & filter Clean
Fuel tube Check
(1) Service more frequently when used in dusty areas.
(2) These items should be serviced by your servicing dealer, unless you
have the proper tools and are mechanically proficient. Refer to the
Honda shop manual for service procedures.
(3) For commercial use, log hours of operation to determine proper
maintenance intervals.
(4) Check that there is no crack and abnormal wear-out in the belt, and
replace if it is abnormal.
(5) In Europe and other countries where the machinery directive 2006/
42/EC is enforced, this cleaning should be done by your servicing
dealer.
Failure to follow this maintenance schedule could result in non-
warrantable failures.

REFUELING

Recommended Fuel
Unleaded gasoline
U.S. Pump octane rating 86 or higher
Except U.S. Research octane rating 91 or higher
Pump octane rating 86 or higher
This engine is certified to operate on unleaded gasoline with a pump
octane rating of 86 or higher (a research octane rating of 91 or higher).
Refuel in a well ventilated area with the engine stopped. If the engine has
been running, allow it to cool first. Never refuel the engine inside a
building where gasoline fumes may reach flames or sparks.
First Every 3 Every 6 Every Refer
use month months months year
or or or or page
20 hrs. 50 hrs. 100 hrs. 300 hrs.
o
o o
o
o (1)
o (1)
o
o
After every 500 hrs. (2) (4) Shop
manual
o (5)
o (2) Shop
manual
o (2) Shop
manual
After every 500 hrs. (2) Shop
manual
o (2) Shop
manual
Every 2 years (Replace if necessary) (2) Shop
manual
You may use unleaded gasoline containing no more than 10% ethanol
(E10) or 5% methanol by volume. In addition, methanol must contain
cosolvents and corrosion inhibitors. Use of fuels with content of ethanol
to
or methanol greater than shown above may cause starting and/or
performance problems. It may also damage metal, rubber, and plastic
parts of the fuel system. Engine damage or performance problems that
result from using a fuel with percentages of ethanol or methanol greater
8
than shown above are not covered under the Warranty.
If your equipment will be used on an infrequent or intermittent basis,
9
please refer to the ''Fuel'' section of the ''STORING YOUR ENGINE'' chapter
(see page 11) for additional information regarding fuel deterioration.
10
Never use stale or contaminated gasoline or an oil/gasoline mixture.
Avoid getting dirt or water in the fuel tank.
10
Gasoline is highly flammable and explosive.
You can be burned or seriously injured when handling fuel.
• Stop the engine and let it cool before handling fuel.
• Keep heat, sparks, and flame away.
• Handle fuel only outdoors.
• Keep away from your vehicle.
• Wipe up spills immediately.
Fuel can damage paint and some types of plastic. Be careful not to spill fuel
when filling your fuel tank. Damage caused by spilled fuel is not covered
under the Distributor's Limited Warranty.
Never use gasoline that is stale, contaminated, or mixed with oil. Avoid
getting dirt or water in the fuel tank.
1. With the engine stopped and on a level surface, remove the fuel filler
cap and check the fuel level. Refill the tank if the fuel level is low.
2. Add fuel to the bottom of the fuel level mark of the fuel tank.
Do not overfill. Wipe up spilled fuel before starting the engine.
FUEL LEVEL MARK
MAXIMUM
FUEL LEVEL
ENGLISH
FUEL FILLER CAP
7