Table of Contents Warnings…………………………………………………………….…..2-5 Tools and Parts List………………………………………………………6 Hardware List and Expanded View……………………………………... 7 Assembly Instructions………………………………………………...8-10 General Information and Operation Instructions......11-12 Care and Maintenance……………………………………………... 13-14 Trouble Shooting................15 Frequently Asked Questions……………………………………..….16 Warranty Information………………………………………....17 Note: Before beginning assembly of product, make sure all parts are present.
WARNINGS THIS GRIDDLE IS FOR OUTDOOR USE ONLY. THIS GRIDDLE IS NOT INTENDED FOR COMMERCIAL USE. SAFETY SYMBOLS: When using this appliance, basic safety precautions should always be observed. Read and understand the meaning of these symbols before assembling and using this griddle.
Page 4
If you continue to smell gas, immediately contact the fire department (e.g. 911) and do not go near the griddle. Model No.158686 Main Max. Input Rating:17,600 BTU/H Equipped for use with: Propane.
Page 5
WARNINGS Safety Precautions Always read and follow all DANGER, WARNING, AND FOR YOUR SAFETY notices in this User Manual. Failure to follow these notices may result in property damage, bodily or physical injury, or death. 1. Griddle installation must conform with local codes, or in their absence, with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54,Natural Gas and Propane Installation Code, CSA B149,or Propane Storage and Handing Code,B149.2.
Page 6
WARNINGS LEAK TESTING THE REGULATOR,VAVLES, HOSES, AND CONNECTIONS 1. Ensure all burners are “OFF”. 2. Ensure the 1LB tank is connected to the regulator. 3. If the information above is not followed exactly, a fire causing death or serious injury may occur. 4.
Tools Required Phillips Screw driver (not included) Parts List Feet Drip pan Left lock ① ② ③ 4pcs Right lock Body 1pc ⑥ Regulator ④ ⑤ ⑦ Griddle Top 1pc Note: Before beginning assembly of product, make sure all parts are present. Compare parts with package content list and hardware contents.
Assembly Instructions Step 1: Turn over the body ( part # ). Assemble the feet (part# ⑤ ) 4pcs by hand tightening them clockwise to the body. Step 2: Turn over the body (part # ⑤ assemble the regulator (part# on the left side of the ⑥) body.Tighten regulator by hand.
Page 10
Assembly Instructions Step 3: Place the griddle top (part#⑦) on top of the body (part #⑤ ). Post under the griddle with the holes on body. Slide the drip pan in right side of the body. Step 4: Assemble left lock (part#)& right lock (part#④) to right side of body (part#⑤) using bolt M4X12 (part#A) 4pcs.
General Information and Instructions Your new Outdoor Gourmet Griddle has been designed and manufactured to high quality standards. It will provide you with many years of enjoyment with a minimal amount of maintenance, please keep in mind the following FOR YOUR SAFETY.
Page 13
Operation Instructions LIGHTING Always visually inspect your griddle before lighting. Look for anything that may be blocking spaces for ventilation and remove. After lighting, always check the flame to ensure you have a good flame all along each burner. If not able to light, or the flame is not even along the entire burner(s),then see the Trouble Shooting section.
Care and Maintenance TURNING OFF YOUR GRIDDLE 1. Turn off the gas supply. 2. Turn all burner control knobs to the "OFF" position. Cleaning Your Griddle WARNING Do not clean any part of your griddle in a self-cleaning oven. Do not use oven cleaners,abrasive kitchen cleaners,cleaners that contain citrus products,or mineral spirits.
Page 15
Care and Maintenance Griddle Top The griddle top has a Non-Stick Property and is easy to clean and maintain.In order to keep the good performance of coating, please follow the below steps before and after cooking: - Please clean the griddle before use. - It is better to use warm/hot water only.
Trouble Shooting Guide BURNER WILL NOT LIGHT 1. Replace the propane tank. 2. Regulator is not properly seated into the tank valve. Remove and reattach. Hand tighten only. 3. Regulator failure. Order replacement part and replace. 4. Blockage in the gas system. Remove insects,spider webs or other blockage . Clean if necessary .Inspect under the control panel to be sure the burners are aligned properly with the valves.
Frequently Asked Questions Can I convert my gas griddle from one fuel source to another? NO.Your gas griddle is manufactured to specific standards developed by CSA and ANSI for your safety and griddle performance for either LP or Natural Gas.We do not offer conversion kits nor do we recommend you change the fuel type.
Warranty Information The appliance has been manufactured under the highest standards of quality and workmanship. We warrant to the original consumer purchaser that all aspects of this product will be free of defects in material and workmanship for one year from the date of purchase. A replacement for any defective part will be supplied free of charge for installation by the consumer.
Need help?
Do you have a question about the 158686 and is the answer not in the manual?
Questions and answers