Subscribe to Our Youtube Channel
Related Manuals for Vintage Air 1968 NOVA
Summary of Contents for Vintage Air 1968 NOVA
- Page 1 ISO 9001: 2008 Registered Company 1968 NOVA WITH AC 565069 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 1 OF 25...
-
Page 2: Table Of Contents
20. GEN IV WIRING CONNECTION INSTRUCTIONS 21. OPERATION OF CONTROLS 22. TROUBLE SHOOTING INFORMATION 23. TROUBLE SHOOTING INFORMATION CONT. 24. KICK PANEL MODIFICATION TEMPLATE 25. EVAPORATOR KIT PACKING LIST 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 2 OF 25... - Page 3 EVAP. SUB CASE w/ 205 ECU 744003 ACCESSORY KIT NOTE: IMAGES MAY NOT DEPICT ACTUAL PARTS AND QUANTITIES. 784179 REFER TO PACKING LIST FOR ACTUAL PARTS AND QUANTITIES 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 3 OF 25...
- Page 4 HEATER HOSE FROM VINTAGE AIR (31800-VUD) OR FROM YOUR LOCAL PARTS RETAILER SAFETY SWITCHES: YOUR VINTAGE AIR SYSTEM IS EQUIPPED WITH A BINARY PRESSURE SAFETY SWITCH. A BINARY SWITCH (11078-VUS) DISENGAGES THE COMPRESSOR CLUTCH IN CASE OF EXTREME LOW PRESSURE CONDITION (REFRIGERANT LOSS) OR EXCESSIVELY HIGH HEAD PRESSURE (406 PSI), TO PREVENT COMPRESSOR DAMAGE OR HOSE RUPTURE.
- Page 5 AND ECU GROUND MUST BE CONNECTED DIRECTLY TO THE NEGATIVE BATTERY POST. THE HEATER CONTROL VALVE IS A NORMALLY OPEN VALVE. IT MUST BE CONNECTED TO THE ECU TO BLOCK WATER FLOW IN AC MODE. 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 5 OF 25...
-
Page 6: Cover
REFER TO SEPARATE IN STRUC TION S IN C LUDED WITH THE BRAC K ET K IT TO IN STALL THE C OMPRESSOR BRAC K ET. 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 6 OF 25... -
Page 7: Passenger Compartment
PASSENGER SIDE KICK PANEL (RETAIN) DEFROST DUCT GLOVE A/C HEATER ASSEMBLY & RELATED DUCTING PASSENGER SIDE CONTROL KICK PANEL PANEL FIGURE 2 FRESH AIR PASSENGER SIDE COVER KICK PANEL 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 7 OF 25... -
Page 8: Kick Panel Modification
CUT FRESH AIR DOOR ASM USING TEMPLATE PROVIDED ON PAGE 24. SEE FIGURE 4 BELOW. TEMPLATE FRESH AIR DOOR ASM. TEMPLATE CUT THIS SECTION FIGURE 4 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 8 OF 25... -
Page 9: Defrost Duct/ Hose Adapter Installation Figures 5 & 6 10. Fresh Air Cover & Kick Panel Fresh Air Cap Installation
INSTALL S-CLIPS ON HOSE ADAPTERS AS SHOWN IN FIGURE 6 BELOW. INSTALL DRIVER & PASSENGER SIDE HOSE ADAPTERS ON OEM LOUVERS. SEE BELOW LOUVER LOUVER HOSE HOSE ADAPTER ADAPTER 49870-VCI 49870-VCI FIGURE 6 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 9 OF 25... - Page 10 (5) OEM FRESH AIR CAP #10 A/C SCREWS HOSE #10 A/C HOSE #6 A/C HOSE (2) HEATER HOSE FIGURE 8 #6 A/C HOSE (2)HEATER FIGURE 8b HOSES 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 10 OF 25...
- Page 11 HOSE INSTALLATION ON PAGE 16. (NOTE: WRAP THE #10 FITTING CONNECTIONS WITH PRESS TAPE. SEE FIGURE 12, PAGE 13.) (2)1/4-20 x ½” HEX BOLT FIGURE 10 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 11 OF 25...
-
Page 12: Evaporator Bracket Installation Cont
FLAT WASHER 189125-MUR 18040-VUB 1/4” PUSH NUT 3/4” NYLON BOLT RETAINER SPACER (2) 1/4-20 x 1/2” HEX BOLTS REAR FIGURE 11 EVAPORATOR BRACKET 643170-FCB (2) HEATER FITTINGS 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 12 OF 25... -
Page 13: Figure 12
SHEET METAL SCREWS PRESS TAPE FIGURE 13a INNER COWL #6 A/C HOSE KICK PANEL FRESH AIR HOSE #10 A/C CLAMPS HEATER HOSE HOSE FIGURE 12 FIGURE 13 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 13 OF 25... - Page 14 INSTALL LOUVER IN UNDER DASH CENTER LOUVER BEZEL. SEE FIGURE BELOW. UNDER DASH LOUVER BEZEL 494052 LOUVER 49157-VUL FIGURE 15 (2)#10 x 1/2” SHEET METAL SCREWS 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 14 OF 25...
-
Page 15: Modified A/C Hose Kit
SEE FIGURE 12, PAGE 13 AND FIGURE 18 PAGE 16. TIGHTEN EACH FITTING CONNECTION AS SHOWN IN FIGURE 17, ABOVE. MODIFIED A/C HOSE KIT REFER TO SEPARATE INSTRUCTIONS INCLUDED WITH MODIFIED HOSE KIT. 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 15 OF 25... -
Page 16: Ac, Heater Hose & Heater Control Valve Installation
FIGURE 12 PAGE 13 AND FIGURE 18 BELOW. NOTE: INSTALL HEATER CONTROL VALVE IN-LINE WITH INTAKE MANIFOLD (PRESSURE SIDE) HEATER HOSE, SECURE USING HOSE CLAMPS AS SHOWN BELOW. (NOTE PROPER FLOW DIRECTION. IS OPPOSITE OF ARROW MOLDED INTO VALVE BODY.) 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 16 OF 25... -
Page 17: Figure 19
SEE OPERATION OF CONTROLS PROCEDURES PAGE 21. GROMMET 33139-VUI 3 ⅛” FIGURE 19 GLOVE BOX 629964 FIGURE 19a PASSENGER SIDE KICK PANEL FRESH AIR COVER FIGURE 19b 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 17 OF 25... -
Page 18: Control Panel Duct Hose Routing
232001-VUR FIGURE 20 PASS. SIDE CENTER LOUVER CENTER LOUVER LOUVER UNDER DASH 2 ½” x 18” IN DASH 2 ½” x 40” 2 ½” x 20” 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 18 OF 25... -
Page 19: Wiring Diagram
** WARNING: ALWAYS MOUNT CIRCUIT BREAKER UNDER THE HOOD IN THE ENGINE COMPARTMENT AND AS CLOSE TO THE BATTERY AS POSSIBLE. *** WIDE OPEN THROTTLE SWITCH CONTACTS CLOSE ONLY AT FULL THROTTLE, WHICH DISABLES AC COMPRESSOR. 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 19 OF 25... - Page 20 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 20 OF 25...
-
Page 21: Operation Of Controls
MODE LEVER TEMPERATURE) THERE IS NO NEED TO SLIDE THE LEVER TO MODE LEVER ADJUST THIS LEVER. THE RIGHT POSITION SLIDE THE LEVER TO THE CENTER POSITION 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 21 OF 25... - Page 22 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 22 OF 25...
- Page 23 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 23 OF 25...
-
Page 24: Kick Panel Modification Template
KICK PANEL MODIFICATION TEMPLATE 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 24 OF 25... -
Page 25: Evaporator Kit Packing List
EVAP. SUB CASE w/ 205 ECU 744003 ACCESSORY KIT NOTE: IMAGES MAY NOT DEPICT ACTUAL PARTS AND QUANTITIES. 784179 REFER TO PACKING LIST FOR ACTUAL PARTS AND QUANTITIES 905069 REV A 4/21/10, 1968 NOVA w/ AC EVAP INSTR PG 25 OF 25...
Need help?
Do you have a question about the 1968 NOVA and is the answer not in the manual?
Questions and answers