Table of Contents
Advertisement
INTRODUCTION
The gases released during charging are explosive.
Never allow naked flames or sparks near batteries that are charging or have recently been charged.
BRAKE AND CLUTCH FLUIDS (polyalkylene-glycol)
See Fire.
Combustible.
Splashes on the skin and in the eyes cause mild irritation.
Avoid contact with the eyes and the skin as far as possible.
The danger of fume inhalation does not increase at room temperature because of very low vapor pressure.
BRAZING
See Welding.
CHEMICALS – GENERAL
See Legal aspects.
You must always take care when using and handling chemicals such as solvents, sealants, adhesives, paints, foam
resins, battery acids, anti-freeze, brake fluid, oils and greases. They may be harmful, toxic, corrosive, irritant, or highly
flammable. They may also emit hazardous fumes or dust.
The effects of excessive exposure to chemicals may manifest themselves immediately of after a delay; they may be
brief or permanent; they may be cumulative; they may be superficial; and they may cause a risk of death or reduce
life expectancy.
DO
Remove chemicals from skin and clothing as soon as possible after contact. Change very dirty clothes and make
provision for cleaning them.
Read and comply scrupulously with the safety recommendations on chemicals' containers (labels), and on the pam-
phlets, posters, or other instructions that accompany them. Manufacturers supply health and safety information
sheets.
Organize working methods and protective equipment to prevent contact with the skin and the eyes; inhalation of
fumes/aerosols/dust/smoke; incorrect container identification; and fire and explosion risks.
When working with chemicals, wash before breaks, and before eating, smoking, drinking, or using the bathroom.
Keep work areas clean, organized, and free of spillages.
Store according to local and national legislation.
Keep chemicals out of the reach of children.
DO NOT
Do not mix chemicals, except in accordance with the manufacturer's instructions. Some substances could form other
chemical substances that are toxic or harmful, emit toxic or harmful fumes, or become explosive after mixing.
Do not spray chemicals, especially solvent-based chemicals, in enclosed spaces, e.g. when there are people inside
the vehicle.
Do not apply heat or flames to chemicals, except in accordance with the manufacturer's instructions. Some are highly
flammable or could release toxic or harmful fumes.
Do not leave containers open. The fumes emitted could accumulate in toxic, harmful, or explosive concentrations.
Some fumes are heavier than air and will accumulate in confined areas, trenches etc.
Do not put chemicals into unmarked containers.
Do not clean your hands or clothes with chemicals. Chemicals, particularly solvents and fuels, dry out the skin and
can cause irritation and dermatitis. Some can be absorbed through the skin in toxic or harmful quantities.
Do not use empty containers to store other chemicals, except when they have been cleaned under supervision.
Do not attempt to sniff or inhale chemicals. Rapid exposure to high concentrations of fumes can be toxic or harmful.
Clutch fluids
See Brake and clutch fluids.
48079508 27/07/2017
12
Advertisement
Table of Contents
