Page 1
SERVICE MANUAL CR9040 / CR9060 / CR9065 / CR9070 / CR9080 Combine from PIN HAJ110001 and Above Part number 84235773 English November 2010 Replaces part number 84163557...
Page 17
INTRODUCTION 12. Never travel at high speed in crowded areas. 13. Avoid making turns at high speed. 14. When driving on public roads, either with the grain header loaded on a trailer and attached to the rear of the machine, or with the grain header still attached to the machine (provided local legislation allows), always be aware and conscious of its size.
Page 18
INTRODUCTION Damaged or missing hose retaining clamps, guards, shields, etc. • DO NOT stand on or use a hose as a step. DO NOT pull or apply external forces to the hose. The hose may fail • and cause injury. Keep all persons away from the working area.
Page 19
5. Wipe up spilled fuel immediately. 6. Always tighten the fuel tank cap securely. 7. If the original fuel tank cap is lost, replace it with an NEW HOLLAND cap. A non-approved, proprietary cap may not be safe. 8. Keep equipment clean and properly maintained.
Page 20
INTRODUCTION WARNING Battery acid causes burns. Batteries contain sulfuric acid. Battery electrolyte contains sulfuric acid. Contact with skin and eyes could result in severe irritation and burns. Always wear splash-proof goggles and protective clothing (gloves and aprons). Wash hands after handling. Failure to comply could result in death or serious injury.
Page 21
INTRODUCTION Wheels and tires The life and performance of the tires depends largely upon maintaining the correct pressure. Keep the tires inflated to the pressures given in SPECIFICATIONS. Check the wheel nuts torque daily during the first week of operation and thereafter on a weekly basis. The wheel nut torque is given in SPECIFICATIONS.
Page 23
INTRODUCTION Safety rules CR9040 NA, CR9060 NA, CR9070 NA, CR9080 NA, CR9065 NA Header Safety Stop WARNING Avoid injury! Always do the following before lubricating, maintaining, or servicing the machine. 1. Disengage all drives. 2. Engage parking brake. 3. Lower all attachments to the ground, or raise and engage all safety locks.
Page 24
INTRODUCTION When not in use, the header safety stop (1) must be stored with storage latch (2) . 10021813 NOTICE: Do not use header safety stop (1) as a support for the header when travelling along public roads otherwise damage may occur to the cylinder. 84235773 16/11/2010...
Page 28
INTRODUCTION How to Use this Manual This manual is divided into Sections. Each Section is then divided into Chapters. Contents pages are included at the beginning of the manual, then inside every Section and inside every Chapter. An alphabetical Index is included at the end of a Chapter.
Page 29
INTRODUCTION Section Contents SECTION LETTER DESCRIPTION HYDRAULIC – This Section covers the main systems that interact with most of PNEUMATIC – the functions of the product. It includes the central parts of the ELECTRICAL – hydraulic, electrical, electronic, pneumatic, lighting and grease ELECTRONIC lubrication systems.
Page 30
INTRODUCTION This manual contains these Sections: Contents INTRODUCTION HYDRAULIC – PNEUMATIC – ELECTRICAL – ELECTRONIC SYSTEMS ENGINE AND PTO IN FRAME POSITIONING CROP PROCESSING Chapters Each Chapter is identified by a letter and number combination e.g. Engine B.10.A The first letter is identical to the Section letter i.e.
Page 31
INTRODUCTION Information Units and Information Search Each chapter is composed of information units. Each information unit has the SAP code shown in parentheses which indicates the function and the type of information written in that information unit. Each information unit has a page ref- erence within that Chapter.
Page 33
Call physician immediately. EYES: flush with water for 15 minutes and get prompt medical attention. 84-110 TOOLS The tools that NEW HOLLAND suggests and illustrate in this manual have been: specifically researched and designed for use with NEW HOLLAND machines • essential for reliable repair operations •...
Page 37
INTRODUCTION PIPE THREAD FITTING TORQUE PIPE THREAD FITTING Before installing and tightening pipe fittings, clean the Torque (Maximum) Thread Size threads with a clean solvent or Loctite cleaner and apply 1/8-27 13 N·m (10 lb ft) sealant L ® 567 PST P for all fittings OCTITE EALANT...
Page 39
INTRODUCTION NOTICE: Be aware that not fulfilling the requirements and conditions of Biodiesel Fuel usage will void your machine’s NEW HOLLAND Warranty coverage. 84235773 16/11/2010...
Page 41
INTRODUCTION Heavy Duty Adjustable Steering Axle in the rear position 1.97 m (6.46 ft) 3.76 m (12.34 ft) 2.42 m (7.94 ft) 2.49 m (8.17 ft) Dimension H: (Centerline Drive Wheel to Rear Edge of Unloading Tube) With 21 ft unloading tube - 7.01 m (23 ft) With 24 ft unloading tube - 7.92 m (26 ft) ZEIL05CR0001F0B Dimension I (Unloading Tube Maximum Open)
Page 43
INTRODUCTION CR9040 CR9060/CR9065 CR9060/CR9065 CR9070 CR9080 Main Drive 4HB belt, engine 4HB belt, engine 4HB belt, engine 4HB belt, engine 4HB belt, engine gearbox to main gearbox to main gearbox to main gearbox to main gearbox to main jackshaft jackshaft...
Page 44
INTRODUCTION CR9040 CR9060/CR9065 CR9070 CR9080 Setting Electric Electric Electric Electric Read out IntelliView IntelliView IntelliView IntelliView Fine Adjustment At suspension points At suspension points At suspension points At suspension points Concave Options Small grain, Rice/ Small grain, Rice/ Small grain, Rice/...
Page 48
INTRODUCTION CR9040 CR9060 CR9065/CR9070 CR9080 Instructional seat Padded Padded Padded Padded Air conditioning Heating Powered heated Optional Optional Optional Optional mirrors Windshield Wipers Standard Standard Standard Standard Traction Transmission 4 speed hydrostatic 4 speed hydrostatic 4 speed hydrostatic 4 speed hydrostatic...
Page 49
INTRODUCTION DECALS AND PLATES - Product identification CR9040 NA, CR9060 NA, CR9070 NA, CR9080 NA, CR9065 NA Your NEW HOLLAND combine is identified using a Product Identification Number. Product Identification Number and model can be found on the PIN (Product Identification Number) plate. According to the destination and specification, additional data is given (e.g.
Page 50
INTRODUCTION On a plate (1) on the breather cover. • 93094775 On a plate on the engine block. • 86063483 84235773 16/11/2010...
Page 62
HYDRAULIC - PNEUMATIC - ELECTRICAL - ELECTRONIC SYSTEMS - PRIMARY HYDRAULIC POWER SYSTEM Lateral Float Accumulators Pre-charge pressure, rod end accumulator 80 bar (1160 psi) Pre-charge pressure, base end accumulator 100 bar (1450 psi) Volume 0.5 l (0.13 US gal) Rotor/Feeder Variator Circuits Pressure-compensated flow control valve 0.16 l/min (0.04 US gpm)
Page 64
SYSTEM PRIMARY HYDRAULIC POWER SYSTEM - Static description CR9040 [HAJ110001 - HAJ111000 ] NA, CR9040 [HAJ111001 - HAJ111579 ] NA, CR9040 [Y8G112001 - Y9G112788 ] NA, CR9040 [Y9G113001 - YAG113831 ] NA, CR9040 [YAG113901 - ] NA The primary hydraulic power system is the high-pressure circuit that operates all of the work hydraulics and steering.
Page 65
HYDRAULIC - PNEUMATIC - ELECTRICAL - ELECTRONIC SYSTEMS - PRIMARY HYDRAULIC POWER SYSTEM If the combine is equipped with an autoguidance system (SMARTSTEER or INTELLISTEER*), the autoguidance steering valve (1) takes over control of the vehicle steering under command of the autoguidance system. * SMARTSTEER and INTELLISTEER are registered trademarks of CNH America LLC.
Page 68
HYDRAULIC - PNEUMATIC - ELECTRICAL - ELECTRONIC SYSTEMS - PRIMARY HYDRAULIC POWER SYSTEM In-line High Pressure Filter (1) A replaceable filter located between the CCLS pump output and the high pressure system priority valve. 73076725 Return Filter with Bypass (1) 73076708 84235773 16/11/2010 A.10.A / 15...
Page 69
HYDRAULIC - PNEUMATIC - ELECTRICAL - ELECTRONIC SYSTEMS - PRIMARY HYDRAULIC POWER SYSTEM 53070846 Main Frame Stack Valve Assembly Priority Valve (1) Located in the main frame stack valve, receives the output oil from the CCLS pump and provides steering with the priority for oil.
Page 70
HYDRAULIC - PNEUMATIC - ELECTRICAL - ELECTRONIC SYSTEMS - PRIMARY HYDRAULIC POWER SYSTEM Main Stack Plumbing Flow from CCLS pump (1) Return from feeder stack valve (2) Return flow (combined) to filter and reservoir (3) Steering load sense (4) Steering return flow (5) Flow to feeder stack valve (6) Feeder stack valve load sense (7) Pressure--compensated flow control valve [0.16 liters/min (5.4 fl oz/min)] (8)
Page 71
HYDRAULIC - PNEUMATIC - ELECTRICAL - ELECTRONIC SYSTEMS - PRIMARY HYDRAULIC POWER SYSTEM Front of Main Stack HHC Module (1) Header lower solenoid (2), LH side Header raise solenoid (3), RH side Pressure sensor (4) Accumulator solenoid (5) Steering relief valve (6) Rotor decrease solenoid (7) Unload auger swing-out solenoid (8) Feeder decrease solenoid (9)
Page 72
HYDRAULIC - PNEUMATIC - ELECTRICAL - ELECTRONIC SYSTEMS - PRIMARY HYDRAULIC POWER SYSTEM Steering Motor (1) The priority valve in the main frame stack supplies oil to the steering motor. The steering motor directs and controls oil to the steering cylinders, based on input via movement of the steering wheel. BSC1257A Autoguidance Steering Valve (1) If the combine is equipped with an autoguidance system (SMARTSTEER or INTELLISTEER), the autoguidance steer-...
Page 73
HYDRAULIC - PNEUMATIC - ELECTRICAL - ELECTRONIC SYSTEMS - PRIMARY HYDRAULIC POWER SYSTEM Autoguidance Steering Cylinder (1) If the combine is equipped with autoguidance, the left-hand steering cylinder is equipped with a sensor (2) to provide rear wheel position information to the autoguidance system. 53060528 Header Lift Cylinders (1) Stone Trap Door Latch Cylinder (2)
Page 74
HYDRAULIC - PNEUMATIC - ELECTRICAL - ELECTRONIC SYSTEMS - PRIMARY HYDRAULIC POWER SYSTEM Unloading Auger Lockout Valve (1) Isolates the unloading auger cylinder from the control valve and pipework. Ensures that the unload auger will remain in the required position until the control valve is activated. When pressure oil is applied to the lock out valve, a bleed line is supplied to the opposite side which releases the lock valve and allows oil to escape.
Page 75
HYDRAULIC - PNEUMATIC - ELECTRICAL - ELECTRONIC SYSTEMS - PRIMARY HYDRAULIC POWER SYSTEM 73080103 Feeder Valve Stack Top Plate (1) - Provides the connection point for the pressure, return and load sense lines. Feeder and Header Reversing Valve (2) - Controls the motor for the feeder and header reverser. Contains two solenoids which move a spool to obtain forward, reverse or a float position on the motor Lateral Flotation Control Valve (3) - Controls the lateral flotation cylinder.
Page 76
HYDRAULIC - PNEUMATIC - ELECTRICAL - ELECTRONIC SYSTEMS - PRIMARY HYDRAULIC POWER SYSTEM Feeder and Header Reversing Motor (1) 10020041 Lateral Flotation Cylinder (1) Adjusts header angle in relation to the combine. Lateral Float Accumulator -- Rod End (2) 80 bar (1160.0 psi) Lateral Float Accumulator -- Base End (3) 100 bar (1450.0 psi) Header Hoses Quick Release Coupling (4) 10020040...
Need help?
Do you have a question about the CR9040 and is the answer not in the manual?
Questions and answers