Page 1
Service Manual ViewSonic N2652w-1M Model No. VS11620-1M 26” LCD TV (N2652w-1M_SM Rev.1b_Aug.2008) ® ViewSonic 381 Brea Canyon Road, Walnut, California 91789 USA - (800) 888-8583...
Page 2
Further, ViewSonic reserves the right to revise this publication and to make changes from time to time in the contents hereof without obligation of ViewSonic to notify any person of such revision or changes.
The LCD module should be supplied by power complied with requirements of Limited Power Source (IEC60950 or UL1950), or be applied exemption. (14) The LCD module is designed so that the CFL in it is supplied by Limited Current ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 5
Taking out the monitor by grasping the LCD panel. That may cause “Mura” Place the monitor on a clean and soft foam Placing the monitor on foreign objects. That could pad. scratch the surface of the panel or cause “Mura” ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Typical. 0.35 V Audio Characteristics: AF Output Level Measured via LP 20 kHz Typical. 0.35Vrms Filter, RMS Decoder, 75us De-emphasis 10% (max.) 44 dB (min.) Compatible system TUNER NTSC/ATSC Compatible system AV NTSC M ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 7
Input Current 3.0A @ 115VAC // 1.5A @ 230VAC Max in < 150A (with fully loaded power supply) at Power Supply Inrush 230Vac Shall not result in permanent failure of power supply ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 8
The product firmware of VS11620-1M / VS11335-1M shall have a firmware version of V:P01. Any changes/revisions afterward shall also be pre-approved by ViewSonic in written. For VS11620-1M / VS11335-1M, its firmware shall have a built-in frequency table for NTSC/ATSC off-air TV/CATV, Closed-Caption, and with MTS implementation.
Page 9
Painting Color - PANTONE 427C (Black for front bezel & back cover) Power Key - PANTONE 032C (RED) Key Pads – PANTONE 11C & PANTONE 5C(Cool Gray) Color Texts Printed on Front Cover and Key Pads - PANTONE 427C, PANTONE 433C(Black) ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 10
Molded Plastic Workmanship shall be inspected according to ViewSonic Molded Plastic Parts Specification, VSCMPPSPEC001V1.2. Screen Printed Parts, Bird Logo Artwork shall be provided and confirmed by ViewSonic. Recess Rear Label A label identifying the product name, model/serial number and FCC ID/Logo shall be placed into the rear label recess located on the rear panel of the chassis.
VOL+ and MENU buttons again to unlock it. 2. Press VOL- and VOL+ buttons at the same time to lock OSD menu, and press VOL- and VOL+ buttons again to unlock it. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 12
SPDIF Optical output Connect this port to the SPDIF input of A/V device. Headphone Jack Connect this port to your headphone. Power (AC input) Using power cord provided, connect to a power source. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 13
Remote Control ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 14
Picture function 26 P.INPUT POP/PIP input source select 27 V-CHIP Set V-Chip rating 28 SWAP Switch between main screen and sub-screen Note: PIP means Picture In Picture. POP means Picture Out Of Picture. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 15
Audio Out: To control sound output ON/OFF from the RCA audio out connectors. Note: To adjust the Audio settings, Smart Sound must be set to the User mode. (Select through the Sound button on the remote control) ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 16
Setup Menu — To set up OSD window Setup Menu is active in all input sources. • Language: To select a OSD language from English, French or Spanish. • Parental: To set up parental control. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 17
Aspect Ratio: To select image size between Normal, Full, Wide1, Wide2, Wide3, 4:3, 16:9, and No scale. • OSD Timeout: To setup the display time of OSD. (5, 15, 45, and 60 seconds) • Memory Recall: To restore the factory default settings. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 18
Auto Scan: Press ENTER to start scanning DTV channels automatically. Press MENU at any time to cancel Auto Scan. • Manual Scan: To scan the DTV channels manually. Press ENTER and select Scan Mode with ◄►. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 19
Press ENTER to start scanning, and press MENU at anytime to cancel scanning. • Channel Skip: To skip channels when viewing channels with CH ▲ and ▼. Press ENTER, and then use ENTER to check/uncheck the channel you want to skip. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 20
Font Opacity: To select font opacity from Solid, Translucent, or Transparent. Background Color: To select background color. Background Opacity: To select background opacity. Window Color: To select window color. Window Opacity: To select window opacity. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 21
Use ▲▼ to select your desired optional item, and press ENTER. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 22
7 and above that is unsuitable for children under 14 years of age TV-G General audience TV-MA Mature audience only Use ENTER button to block or unblock the ratings, and use MENU to exit. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 23
Use ENTER button to block or unblock the ratings, and use MENU to exit. • Block MPAA Unrated: To block unrated movies. • Block TV None Rating: To block unrated TV programs. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 24
Note: To select the input source for main screen, press INPUT button. • SWAP: Press SWAP to exchange main screen to sub-screen, including video and sound. The function is available both in PIP and POP. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 25
If you forget your initial password,you can press "3660" to resume. "MENU" Lock & Un-lock: Pressing "Vol+" and "Vol-" from Front Panel Keys. "POWER" Lock & Un-lock: Pressing "Vol+" and "MENU" from Front Panel Keys. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
MT8202 supports alpha blending for Video and two OSD planes. It also supports 10bit gamma correction and advanced dithering processing for LCD display with 6/8/10 bit output. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 27
PES, analyzing the PES header, and transferring the PES to the audio and video decoders. MT8293 is fully HDMI-compliant receiver that fits directly into home theater products such as LCD TVs, plasma TVs and HDTVs. The receiver is capable of supporting bandwidths up to ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 28
MT8293 via 3 Data TMDS pairs & 1 CLOCK TMDS pairs. Digital video signals are directly output from the MT5351AG and MT8293 and then transfer them to the MT8202 for advanced processing. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 29
Digital audio, such as HDMI and DTV, have decoded by MT5351 and MT8293, is converted to I2S digital audio already. The I2S digital audio data is decoded and processed by MT8202, and then be delivered to AD8256 for audio amplifying. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
BALANCE and press ENTER, The color warm will auto adjust. The act of EHITE BALANCEL is completed when the picture is steady. 2.After adjusting, switch to FULL WHITE and check the value of each color. Preset color for N2652WM x=0.283±0.015 y=0.298±0.015 ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 31
1.4.10 EARPHONE FUNCTION TEST Under PC MODE, input PC AUDIO signal, determines whether the action of INT SPEAKER output is right. Meets earphone with the EARPHONE, Determined whether ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 34
B.CHANNEL36: Check whether the color of the color bar is normal. C.CHANNEL69: Turn RF attenuator and check the critical point of the change of the image’s S/N is under LEVEL<45~85> dBu, regards as normally. TIMING TABLE (FACTORY PRESET MODE) (TABLE 3) ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 35
H B-Porch 1.310us 1.037us H Width 0.000us 0.000us H Border 16.662ms 16.661ms V TOTAL 16.097ms 16.005ms V DISPLAY 0.377ms 0.594ms V B-Porch 0.126ms 0.047ms Vs Width 0.00ms 0.00ms V Border H/V Sync Interlace ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 36
N2652WM LCD TV DDC Card RS-232 Cable VGA Cable Barcode Reader 2.2 Setup Procedure 2.2.1 Connect VGA Card and DDC Card with RS-232 cable. 2.2.2Barcode Reader connects with keyboard and PC keyboard port. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 37
(When key in DVI DDC information, use VGA transform to DVI port.) 2.2.4 Connect Power Cord to N2652WM LCD TV. 2.3 DDC Key In Procedure 2.3.1Run DDC.exe 2.3.2 Choose model number then ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 38
2.3.3 Press “ENTER” key. 2.3.4 Input barcode 2.3.5 Press “ENTER” key, then the successful picture is as follows. “DDC DOWNLOED 3.3.6 Exit program. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 39
HDMI Cable N2652WM LCD TV RS-232 Cable HDMI Cable Barcode Reader 3.2 Setup Procedure 3.2.1Connect HDMI Card and DDC Card with RS-232 cable. 3.2.2Barcode Reader connects with keyboard and PC keyboard port. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 40
3.2.3 Connect DDC Card and N2652WM LCD TV with HDMI Cable. 3.2.4 Connect Power Cord to N2652WM LCD TV. 3.3 DDC Key In Procedure 3.3.1Run DDC.exe 3.3.2 Choose model number then ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 41
3.3.3 Press “ENTER” key. 3.3.4 Input barcode 3.3.5 Press “ENTER” key, then the successful picture is as follows. “DDC DOWNLOED 3.3.6 Exit program. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 42
4.4 Execute the Mtktool to start download the file. The Mtktool program will be upgraded if necessary. "MtkTool Auto BaudRate.exe" 4.5 The Mtktool Operate 4.5.1 Select Platform : MT8105 , MT1389 or MT8205 ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 43
4.5.2 Select COM port. Depends on the COM port assigned in System Device Manager (Refer below right). 4.5.3 Select Baud Rate. 115200x 8 (Suggestion) ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 44
4.5.4 Enable the USB Bridge. 4.5.5 Browsing the File to download. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 45
2. You can slow down the baud rate if some Flash memory can not works properly in high-speed download. 3. Please call the MediaTek contact window if any problem found like unsupported Flash Type or fail to download. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 46
At last, close the carton and seal it with tape. (Figure 4) 1.Power Cord 2.VGA Cable 3.RF Cable 4.RCA Cable 5.User’s Guide 6.Remote contrl 7.Guarant Card 8.Battery Figure 4 Figure 3 ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 48
Disassembly Procedure Disassembly of Stand and Dust Cover from LCD TV. 1.1 Detach Dust Cover from the LCD TV and Unscrew 4 screws that secure Stand Unit. Dust Cover Dust Cover Stand ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 49
2.1 Unscrew 6 screws to remove Rear Cover. Rear Cover 3. Disassembly of Main Board,Power Board,IR Board,Speakers,Front Cover and Panel Unit. 3.1 Disconnect the wires to remove Speakers. 3.2 Unscrew 2 screws to remove dust cover. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 50
3.3 Unscrew 11 screws to remove Shield Plate and dust cover. Shield Plate 3.4. Unscrew 13 screws to remove Metal Fittg-I/O(side) and Metal Fittg-I/O(down). ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 51
3.5. Unscrew 5 screws and disconnect the wires to remove Main Board. 3.6. Unscrew 4 screws and disconnect the wires to remove Power Board. 3.7. Unscrew 4 screws to remove Front Cover. ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 52
3.8. Lay Panel Unit facedown and unscrew 4 screws on its up and down sides, to remove Panel Unit and Panel Bracket. Metal fittg panel ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Replace I106 Replace I135 signal output to I145? defective? Check I136 is Replace I136 defective? Check Pin37 of I145 is Check Earphone high? circuit Check I145 is Replace I145 defective? Check Speaker Wire ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 54
OK? Check 3.3V is on C113? Replace I101 1.9V is on I102 Pin2? Replace I102 Check IR Board Replace IR Board Check X100 is OK? Replace x100 Replace I106 & I107 ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 55
NTSC YPb Pr S-VIDEO Check Check Video wave form is Replace L221,R172 Check L224,R197,C340 is Replace L224,R197 or Replace I112 L221,R172,R173,C332,C33 on I112 Pin12 ? R173,C332,or C334 C340 4 is OK? Check Replace L215,R501,R170,C331 is L215.R501,R170 or C331 Check L226,R203,C335 is Replace L226,R203, or C335 Check I106 has output...
Page 56
RP32~RP41? Pin19~22 of P114 ? Check the LVDS wire from Replace LVDS Wire P114 to panel is OK? Check inverter wire from power board to panel is Replace Inverter Wire Replace Panel ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 68
TSSOP16 DV18 POWER +1V8 MT5111 POWER DV33 POWER +3V3 MT5351 POWER DIGITAL OUTPUT AV33 POWER +3V3 MT5351 ANALOG POWER DV25 POWER +2V5 MT5351 DDR POWER DV12 POWER +1V2 MT5351 POWER GROUND GROUND ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 69
R416 15,16,18 B9105B_3V3 SHDN DV12 11.5K1% 15,18 DV12 R0603 Regulator AP1522 SOT23-5/SMD 11,13,14,15,16,17,18 Vout = 1.25 x ( 1 + Rb / Ra ) GLOBAL SIGNAL POWER SUPPLY +30V FOR SAMSUNG TUNER ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 70
R160 100 R0603 T_SDA_5111 C314 CVBS 0.1U 10U/50V C0603 CE025050 PORT TUNER DTVS203CH201M IF_AGC IF_AGC 2nd_IF+ 2nd_IF+ 2nd_IF- +30V_TUNER 2nd_IF- +30V_TUNER +5V_TUNER +5V_TUNER T_SDA_5111 T_SDA_5111 [1,2,4,5,6,7,8] T_SCL_5111 T_SCL_5111 GLOBAL SIGNAL TUNER INTERFACE ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 71
C486 C0603 0.1U 0.1U 0.1U 0.1U 0.1U Digital 1.8V Bypass Caps CE025050 L0805 C481 C487 0.1U C0603 C0603 C0603 C0603 C0603 Digital 3.3V Bypass Caps 10U/50V C0603 CE025050 Analog 3.3V Bypass Caps ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 72
AVDD_APLL0 CAPVPLL CAPVPLL CAPVGND CAPVGND APLLCAP1 APLLCAP1 APLLCAP0 APLLCAP0 ATP1 ATP1 ATP2 ATP2 ANALOG PART 5VDD L198 R121/0603 C743 0.1U OPTICAL MT5351 BGA471/SMD/SOCKET ASPDIF R493 DV25 SPDIF CIRCUIT P116 S/PDIF OUT RCA/SPDIF/DIP ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 73
CE025063 C0603 C0603 C0603 C0603 C0603 C0603 C0603 C0603 BYPASS CAP. FOR TERMINATOR C546 C547 FOR DDR#2 0.1U 0.1U (EVERY 2 RESISTOR PUT 1 C0603 C0603 BYPASS CAP.) BYPASS CAP. FOR DDR ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 74
TP75 TP/SMD/D0.6 JTMS JTMS TP/SMD/D0.6 TP76 SOFTWARE DEBUG PORT JTCK JTCK TP/SMD/D0.6 TP77 JRTCK JRTCK TP/SMD/D0.6 TP78 DV33 JTDO JTDO TP/SMD/D0.6 R309 R310 4.7K 4.7K R0603 R0603 U2RX U2TX FOR SOFTWARE LINK ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
10. Exploded View And Exploded Parts List ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 92
ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...
Page 93
EXPLODED PARTS LIST ( N2652w-1 ) Model Number: VS11620-1M Rev: 1a Serial No. Prefix: QJ2 Item ViewSonic P/N Ref. P/N Description Q'ty 2024277501P FRONT BEZEL 26U BLACK C VSC-HDMI-DOLBY94HB 2054256502P ORNAMENT 268 FRONT BAR BLACK C ABS94HB 2033150600P IR COVER JC278UB PC LIMPID 476C 2053754201P LED INDIC.-PWR...
Remark 2: All revised RSPLs with newly added items or any change made should be highlighted and correlated with the ECN/ECR approved by ViewSonic Corporation. This is to eliminate repeated cross checks of each item between this version and prior versions.
Page 95
BOM LIST (N2652w-1) ViewSonic Model Number: VS11620-1M Rev: 1a Serial No. Prefix: QJ2 Item ViewSonic P/N Ref. P/N Description Location Universal number# Q'ty 2346110496P CAP,CHIP 125'C CS 0603/X7R/50V 0.1u K T C100 2346110496P CAP,CHIP 125'C CS 0603/X7R/50V 0.1u K T...
Page 96
Item ViewSonic P/N Ref. P/N Description Location Universal number# Q'ty 2346110496P CAP,CHIP 125'C CS 0603/X7R/50V 0.1u K T C717 83 N/A 2346110496P CAP,CHIP 125'C CS 0603/X7R/50V 0.1u K T C719 84 N/A 2346110496P CAP,CHIP 125'C CS 0603/X7R/50V 0.1u K T...
Page 111
Company: Add: Tel: Fax: E-mail: After completing this form, please return it to ViewSonic Quality Assurance in the USA at facsimile 1-909-839-7943. You may also e-mail any suggestions to the Director, Quality Systems & Processes (marc.maupin@viewsonic.com) ViewSonic Corporation N2652w-1M Confidential - Do Not Copy...