Related Manuals for MQ Multiquip QP4TK
Summary of Contents for MQ Multiquip QP4TK
- Page 1 OPERATION AND PARTS MANUAL MODEL QP4TK TRASH PUMP (KUBOTA OC95-E4 DIESEL ENGINE) Revision #1 (08/24/17) THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
- Page 2 TO PURCHASE THIS PRODUCT PLEASE CONTACT US Equipment Financing and Extended Warranties Available Discount-Equipment.com is your online resource for commercial and industrial quality parts and equipment sales. 561-964-4949 visit us on line @ www.discount-equipment.com Select an option below to find your Equipment We sell worldwide for the brands: Genie, Terex, JLG, MultiQuip, Mikasa, Essick, Whiteman, Mayco, Toro Stone, Diamond Products, Generac Magnum, Airman, Haulotte, Barreto, Power Blanket, Nifty Lift, Atlas Copco, Chicago Pneumatic, Allmand, Miller Curber, Skyjack, Lull,...
-
Page 3: Proposition 65 Warning
PROPOSITION 65 WARNING Diesel engine exhaust and some of PAGE 2 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) -
Page 4: Table Of Contents
Engine Service Parts ........36-37 Terms And Conditions Of Sale — Parts ....38 NOTICE Specifications and part numbers are subject to change without notice. QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 3... -
Page 5: Safety Information
COULD result in DEATH or SERIOUS INJURY. CAUTION Indicates a hazardous situation which, if not avoided, COULD result in MINOR or MODERATE INJURY. NOTICE Addresses practices not related to personal injury. QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 5... - Page 6 Also, know the phone numbers of the nearest ambulance, doctor and fi re department. This information will be invaluable in the case of an emergency. PAGE 6 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17)
- Page 7 Allow these parts to cool comes into contact with hot engine parts or sparks from before servicing equipment. the ignition system. QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 7...
- Page 8 „ DO NOT lift machine to unnecessary heights. seek medical attention. „ ALWAYS tie down equipment during transport by securing the equipment with rope. PAGE 8 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17)
- Page 9 Recyclers and manufacturers alike promote the process of recycling metal. Using a metal recycling center promotes energy cost savings. QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 9...
-
Page 10: Specifications (Pump)
37.7 psi (260 kPa) Dry Net Weight 286 lbs. (130 Kg.) Table 2. Dimensions Reference Dimension in. (mm) Letter 28.3 (719) 24.4 (620) 30.3 (770) Figure 1. Dimensions PAGE 10 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) -
Page 11: Specifications (Engine)
10.1 x 7.0 x 1.2 in. (256.5 x 178 x 30.5 mm) Weight 124 lbs (56 Kg.) Ｄ Ｄ ｉ ｉ ｅ ｅ ｓ ｓ ｅ ｅ ｌ ｌ Figure 2. QP4TK Performance Curve QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 11... -
Page 12: General Information
A small suction leak in the hose or fittings could prevent the pump from priming. PAGE 12 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) -
Page 13: Pump Components
PUMP COMPONENTS Figure 3 shows key component areas of the QP4TK. Figure 3. QP4TK Key Component Callouts PAGE 14 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) - Page 14 (Cam and Groove lock) hose. For quick disconnect connections, an optional coupler (A400A) is necessary. Contact MQ Parts Department for ordering assistance. QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 15...
-
Page 15: Basic Engine
13. Electric Starter — Starts engine when ignition key is 5. Ignition Switch — With ignition key inserted, turn key rotated to the "START" position. clockwise to start engine. PAGE 16 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) -
Page 16: Inspection (Engine)
QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 17... -
Page 17: Setup
Figure 8. Pump Placement PAGE 18 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) -
Page 18: Operation
7” x 12” and will accept any quality 12V “C” post 12N24- 3A type battery (ex. Interstate, YUASA, and Champion). Figure 10. Ignition Switch (Start Position) QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 19... - Page 19 4. Remove all hoses from the pump. CAUTION When stopping the engine, reduce the load slowly. DO NOT stop engine suddenly since it may cause the temperature to rise abnormally. PAGE 20 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17)
-
Page 20: Maintenance (Pump)
This prevents backflow and allows for faster priming when the engine is restarted. QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 21... - Page 21 INTO 25 FEET OF LIFT SHOULD BE BETWEEN -100 AT SEA LEVEL. -25 AND -20 IN. HG. in. Hg PUMP VACUUM WIKA TESTER Figure 11. Pump Vacuum Tester PAGE 22 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17)
-
Page 22: Maintenance (Engine)
Refer to the KUBOTA shop Manual for service procedures. 3. For commercial use, log hours of operation to determine proper maintenance intervals. NOTICE Refer to manufacturer engine manual for specific servicing instructions. QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 23... - Page 23 PAGE 24 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17)
-
Page 24: Storage
This will prevent excessive corrosion and also keep the mechanical seal lubricated. „ Disconnect the battery cables from the battery. QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 25... -
Page 25: Troubleshooting (Engine)
Correct engine oil level. Use No. 2-D diesel fuel only. Check the fuel Injection pump wear? injection pump element and delivery valve assembly and replace as necessary. PAGE 26 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) -
Page 26: Troubleshooting (Engine/Pump)
Impeller does not turn, pump is hard to start. Adjust clearance by removing shim from behind Impeller and volute binding? impeller. Defective engine? See Engine Owner's Manual. QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 27... -
Page 27: Explanation Of Code In Remarks Column
“Remarks” Column. assembly/kit that can be purchased, or is not available for sale through Multiquip. PAGE 28 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) -
Page 28: Suggested Spare Parts
1....KIT4TK ......KIT, MECHANICAL SEAL NOTICE Part numbers on this Suggested Spare Parts list may supersede/replace the part numbers shown in the following parts lists. QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 29... -
Page 29: Pump Assembly
PUMP ASSEMBLY PAGE 30 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) - Page 30 CAP SCREW, M12 X 30 (CASING) 0105051040 BOLT, M10 X 40 (PUMP) 0520040440 0458220100 WASHER, SEAL (IMPELLER) 0191190750 BOLT, (IMPELLER) 1466200270 HINGE BOLT, M10 X 65 1466220280 HINGE PIN QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 31...
- Page 31 PUMP ASSEMBLY PAGE 32 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17)
- Page 32 CAP SCREW, M12 X 20 (DELIVERY COVER) KIT4TK KIT, MECHANICAL SEAL, SLEEVE, O-RINGS ..1....INCLUDES ITEMS W/# 24820006000014 CASING COVER SET PLATE 0141090820 SCREW, (CASING COVER SET PLATE) QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 33...
-
Page 33: Engine Mounting Assembly
ENGINE/BATTERY MOUNTING ASSEMBLY NOTE: INCLUDED WITH ITEM 12. PAGE 34 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) - Page 34 WASHER, ENGINE..........4....REPLACES P/N 0401450100 0451250120 LOCK WASHER (BATTERY TRAY) 0205450120 NUT (BATTERY TRAY) 0451250080 LOCK WASHER 0401450080 WASHER (BATTERY) 09592280000014 BATTERY TRAY 0105051225 BOLT (BATTERY TRAY) QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 35...
-
Page 35: Engine Service Parts
ENGINE SERVICE PARTS PAGE 36 — QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) - Page 36 PART NAME QTY. REMARKS 1142011180 AIR FILTER 1491132110 OIL FILTER 1142043012 FUEL FILTER 1390141340 GASKET 1142041030 CAP, FUEL TANK ...........1....INCLUDES ITEM W# 1390141350 FUEL STRAINER QP4TK TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #1 (08/24/17) — PAGE 37...
- Page 37 Discount-Equipment.com is your online resource for quality parts & equipment. Florida: 561-964-4949 Outside Florida TOLL FREE: 877-690-3101 Need parts? Click on this link: http://www.discount-equipment.com/category/5443-parts/ choose one of the options to help get the right parts and equipment you are looking for.
Need help?
Do you have a question about the QP4TK and is the answer not in the manual?
Questions and answers
On top of motor housing is a small oil plug if you look inside you can see a linkage operated by a small black lever on side . What does that lever do. Thank you
The small black lever on the side of the MQ Multiquip QP4TK motor housing is the engine speed control lever. It is connected to the throttle control and is used to control engine speed.
This answer is automatically generated