Page 1
All manuals and user guides at all-guides.com On-Demand Water Heater Installation Manual and Owner’s Guide Models 110U Indoor (T-KJr2U-IN) 110U Outdoor (T-KJr2U-OS) 310U Outdoor (T-K4U-OS) 310U Indoor (T-K4U-IN) 510U Indoor (T-D2U-IN) 510U Outdoor (T-D2U-OS) WARNING Gas Tankless Water Heater Suitable for potable water heating and space-heating* * Please refer to local codes for space-heating compliance.
Page 2
All manuals and user guides at all-guides.com Contents CONTENTS Installation Manual Owner's Guide ...
Page 3
All manuals and user guides at all-guides.com Installation Manual CONGRATULATIONS...
All manuals and user guides at all-guides.com SPECIFICATIONS 110U 110U 310U 310U 510U 510U Model Indoor Outdoor Indoor Outdoor Indoor Outdoor (T-KJr2U-IN) (T-KJr2U-OS) (T-K4U-IN) (T-K4U-OS) (T-D2U-IN) (T-D2U-OS) Natural Gas Input Gas Connection Water Connections Water Pressure* Natural gas Inlet Pressure Manifold Pressure** Weight...
Page 5
All manuals and user guides at all-guides.com INTRODUCTION...
All manuals and user guides at all-guides.com Safety Guidelines SAFETY GUIDELINES SAFETY DEFINITION DANGER WARNING CAUTION GENERAL GAS TYPE, GAS PRESSURE, WATER PRESSURE and ELECTRIC RATING do not install and consult with the manufacturer WARNING...
All manuals and user guides at all-guides.com Installation and service must be performed by a qualified installer (for example, a licensed plumber or gas fitter), otherwise the warranty will be void. WARNING The installer (licensed professional) is responsible for the correct installation of the water heater and for compliance with all national, state / provincial, and local codes.
All manuals and user guides at all-guides.com HIGH-ALTITUDE INSTALLATIONS Indoor models Altitude 0 (DEFAULT) Up to 2,500 ft Up to 5,000 ft Up to 7,500 ft Over 7,500 ft DIPswitches (Lower bank of DIPswitches) Outdoor models Altitude 0 (DEFAULT) Up to 2,000 ft Up to 4,000 ft Up to 6,000 ft Over 6,000 ft DIPswitches...
All manuals and user guides at all-guides.com VENTING INSTRUCTIONS For indoor models -General- DANGER CAUTION The manufacturer recommends the NovaVent line. General rules for venting water heaters are: General rules for vent terminations: any air intake devices...
Page 14
*For each elbow added, deduct 5 ft. (1.5m) from max. vent length. No. of Elbows Max. Vertical or Horizontal Vent Length -DIPswitch settings for Vent length- For Indoor and direct-vent models 110U Indoor (T-KJr2U-IN) 510U Indoor (T-D2U-IN) Vent length 310U Indoor (T-K4U-IN) (Upper bank of DIPswitches)
Page 15
All manuals and user guides at all-guides.com For the 110U Indoor (T-KJr2U-IN), 310U Indoor (T-K4U-IN) and 510U Indoor (T-D2U-IN) models conversion kit with water heater...
Page 16
All manuals and user guides at all-guides.com...
Page 17
All manuals and user guides at all-guides.com & & CAUTION...
All manuals and user guides at all-guides.com GAS SUPPLY AND GAS PIPE SIZING -General- Check that the type of gas matches the rating plate first. Ensure that any and all gas regulators used are operating properly and providing gas pressures within the specified range shown below. Excess gas inlet pressure may cause serious accidents.
Page 19
All manuals and user guides at all-guides.com Based on energy content of 1,000 BTU/Cubic ft.: The water heater requires 140 Cubic ft./hr for the 110U (T-KJr2U) models, 190 Cubic ft./hr for the 310U (T-K4U) models, and 199 Cubic ft./hr for the 510U (T-D2U) models. Unit: Cubic feet per hour Pipe size Length...
All manuals and user guides at all-guides.com THIS IS ONLY TO BE DONE BY A LICENSED PROFESSIONAL WATER CONNECTIONS CAUTION As Close as Possible inlet Cold Pressure relief valve outlet inlet...
Page 21
All manuals and user guides at all-guides.com -Pressure relief valve- “pressure only” ANSI Z21.22 CAN 1-4.4 ELECTRICAL CONNECTIONS WARNING CAUTION All indoor models come with a power plug instead of a junction box. The following procedure is for outdoor models only. 120 VAC, 60 Hz electrical power supply that is properly grounded Outdoor models only Indoor models only...
Page 22
All manuals and user guides at all-guides.com dDWZ dhZ ZDKd KEdZK>>Z -INCLUDED ACCESSORIES- Temperature Screws Manual Remote controller cable remote controller -INSTALLATION- This remote controller is NOT waterproof CAUTION <Mounting and wiring the remote controller> Back plate (Fig. A and B) Back plate (Fig.
Page 23
All manuals and user guides at all-guides.com "Fork terminals" "Remote controller terminal" (Fig. C-1) (Fig. C-2) Main body "Back plate" "Remote controller cable" Fig. C-1 Fig. C-2 <How to connect the remote controller to the water heater> 110U (T-KJr2U) and 310U (T-K4U) models 9008172005 (TM-RE40) Connect other end to these terminals...
Page 24
All manuals and user guides at all-guides.com * Do NOT jump or short-circuit the wires, or computer will be damaged. 510U (T-D2U) models 9008172005 (TM-RE40) Connect other end to these terminals Front of remote...
Page 25
All manuals and user guides at all-guides.com ^z >/E< ^z^dD h d h -General- Easy-Link connection with allowable heaters Gas In Hot Out Cold In 4 units Only listed models on the table above can be combined together as an CAUTION Easy-Link System These...
Page 26
All manuals and user guides at all-guides.com “PARENT” “PARENT” “PARENT” lower bank of DIPswitches to the ON position “CHILD” “PARENT” “CHILD-1” “PARENT” “PARENT” “1” “CHILD-1” “CHILD-1” “CHILD-2” “2” “CHILD-1” “1” “CHILD-2” “CHILD-2” “CHILD-3” “2” “CHILD-2” “1” “CHILD-3” Type of unit Unit # of easy-link Parent Child...
Page 27
All manuals and user guides at all-guides.com NOTICE (C) Examples of incorrect settings and /or connections CASE 1: Wrong DIPswitch setting on the "PARENT" unit “PARENT” Connectors Connectors CASE 2: Wrong connections between the "PARENT" unit and the "CHILD-1" unit “1"...
Page 28
All manuals and user guides at all-guides.com CASE 3: Wrong connections between the "CHILD-1" unit and the "CHILD-2" unit “PARENT” “CHILD-1” “1” “CHILD-2” “CHILD-2” “PARENT” damage the computer board WARNING CASE 4: Remote controller connected to incorrect unit “PARENT” “CHILD” “CHILD”...
Page 29
All manuals and user guides at all-guides.com Dh>d/ hE/d ^z^dD 510U 9008300005 (T-D2U) (TM-MC02) Hot Out Cold IN Multi-unit system connection diagram ...
Page 30
All manuals and user guides at all-guides.com APPLICATIONS In order to purge air in water pipes within a closed-loop system, an air vent and air separator should be installed in the system. Required circulation flow rates are labeled next to each application diagram. These flow rate WARNING requirements must be followed *The recirculation pump is to be controlled by:...
Page 31
All manuals and user guides at all-guides.com > > through each activated unit in the system. Priority Control Devices NOTICE...
All manuals and user guides at all-guides.com INITIAL OPERATION FOR YOUR SAFETY, READ BEFORE OPERATING Check the GAS and WATER CONNECTIONS Check the GAS PRESSURE Check for PROPER VENTING and COMBUSTIBLE AIR Purge the GAS and WATER LINES IF YOU SMELL GAS: WARNING Operation...
Page 33
All manuals and user guides at all-guides.com Owner's Guide Owner's Guide CONGRATULATIONS...
Page 34
All manuals and user guides at all-guides.com Owner's Guide OPERATING SAFETY FOR YOUR SAFETY READ BEFORE OPERATING WARNING: OPERATING INSTRUCTIONS STOP! TO TURN OFF GAS TO APPLIANCE...
Page 35
All manuals and user guides at all-guides.com Owner's Guide DANGER Vapors from flammable liquids will explode and catch fire causing death or severe burns. WARNING: Do not install water heater where flammable products will be stored. Read and follow water heater warnings and instructions. If owner’s manual is missing, contact the manufacturer.
All manuals and user guides at all-guides.com Owner's Guide NORMAL OPERATION ZDKd KEdZK>>Z Display for Temperature "INFO" Button "COLD" Button "HOT" Button IN USE LED (Green) "ON/OFF" Button STAND BY LED (Orange) GENERAL CAUTION NOTICE...
Page 37
All manuals and user guides at all-guides.com Owner's Guide dDWZ dhZ ^dd/E'^ Operation Screen "ON/OFF" "HOT" "COLD" (Increasing temperature, example 140 °F to 145 °F) -510U (T-D2U) models only- "HOT" "HOT" "INFO" dDWZ dhZ d > K& ZDKd KEdZK>>Z a) For 110U (T-KJr2U) and 310U (T-K4U) models °F °C...
All manuals and user guides at all-guides.com Owner's Guide ADDITIONAL FEATURES "INFO" Operation Screen "INFO" "INFO" "INFO" "INFO" -Unit conversion mode- Operation Screen "ON/OFF" "INFO"...
Page 39
All manuals and user guides at all-guides.com Owner's Guide dDWZ dhZ ^dd/E'^ KE d, W t/d,Khd ZDKd KEdZK>>Z 110U (T-KJr2U) and 310U (T-K4U) models Computer board 510U (T-D2U) models (Lower bank of DIPswitches) Computer board Lower bank of DIPswitches NOTE: WARNING...
Page 40
All manuals and user guides at all-guides.com Owner's Guide FLOW Household Flow Rates Flow rate Appliance/Use GPM (US) L/min Model Flow rate ) &Z WZKdd/KE ^z^dD CAUTION...
All manuals and user guides at all-guides.com Owner's Guide D /EdE E E ^Zs/ WARNING UNIT DRAINING and FILTER CLEANING Unscrew 8. Clean the filter Hand- tighten only...
All manuals and user guides at all-guides.com Owner's Guide ERROR CODES -General- 110U (T-KJr2U) and 310U (T-K4U) models 510U (T-D2U) models Error code on the remote controller 9008172005 (TM-RE40) Error code on the computer board Example: If your unit has the “321” error code (which signifies an inlet thermistor failure) Remote controller 9008172005 (TM-RE40): Water heater: >...
Page 45
All manuals and user guides at all-guides.com Owner's Guide & consult with the manufacturer Green Malfunction Remote Diagnosis description...
Page 46
All manuals and user guides at all-guides.com Owner's Guide Green Malfunction Remote Diagnosis description...
All manuals and user guides at all-guides.com Owner's Guide Components Diagram COMPONENTS DIAGRAM Case assembly Outdoor models Indoor models Temperature remote controller...
Page 48
All manuals and user guides at all-guides.com Owner's Guide Components Diagram Computer board assembly 110U (T-KJr2U) and 310U (T-K4U) models 510U (T-D2U) models Surge box assembly...
Page 49
All manuals and user guides at all-guides.com Owner's Guide Components Diagram Burner assembly Exhaust section (Outdoor models)
Page 50
All manuals and user guides at all-guides.com Owner's Guide Components Diagram Water Way assembly (510U (T-D2U)models) 510U (T-D2U) models To Water inlet section To Water outlet section Water outlet section Water inlet section...
All manuals and user guides at all-guides.com Owner's Guide Parts List PARTS LIST Part # Item # Description 110U, 310U and T-KJr2U, T-K4U 510U models and T-D2U models...
Page 52
All manuals and user guides at all-guides.com Owner's Guide Parts List Part # Item # Description 110U, 310U and T-KJr2U, T-K4U 510U models and T-D2U models...
Page 53
All manuals and user guides at all-guides.com Owner's Guide Parts List Part # Item # Description 110U, 310U and T-KJr2U, T-K4U 510U models and T-D2U models...
All manuals and user guides at all-guides.com Owner's Guide Output Temperature Chart OUTPUT TEMPERATURE CHART 110U (T-KJr2U) models Output Temperature vs. GPM (Max. 6.6 GPM) with Various Inlet Water Temperature 310U (T-K4U) models Output Temperature vs. GPM (Max. 8.0 GPM) with Various Inlet Water Temperature 510U (T-D2U) models Output Temperature vs.
All manuals and user guides at all-guides.com Owner's Guide Warranty LIMITED WARRANTY Application Type Heat Exchanger Parts Labor THIS WARRANTY COVERS ONLY FAILED MECHANICAL AND ELECTRICAL PARTS DUE TO FACTORY DEFECTS UNDER NORMAL USAGE FOR THE PRODUCT’S INTENDED PURPOSES AND WITHIN THE APPLICABLE PERIOD SPECIFIED IN THE FOLLOWING TABLES.
Page 56
All manuals and user guides at all-guides.com Owner's Guide Warranty...