Sharp SW-120NC Instruction Manual page 79

Every month
1. Clean the filter of the oil tank.
2. Please apply grease to the blade tension device.
Recommended Grease:
• Shell Alvania EP Grease 2
• Mobil Mobilplex 48
Every 600 hours / every 1200 hours
After 600 hours of initial operation, drain away the oil and clean the internals of the machine, then
refill new oil. Do so hereafter every 1200 hours of operation.
Recommended gear oil:

Shell Omala oil R220

Mobil gear 630
Recommended hydraulic oil:

Shell Tellus 32

Mobil DTE Oil Light Hydraulic 24
Every six months
Clean or change hydraulic circuits and inner filter if there is an oil tank.
STORAGE CONDITIONS
Generally, this machine will be stored on the following conditions in future:
1. Turn off the power.
2. Ambient temperature: 5℃ ~ 40℃
3. Relative humidity: 30%~95% (without condensation)
4. Atmosphere: use a plastic canvas to cover machine to avoid excessive dust, acid fume,
corrosive gases and salt.
5. Avoid exposing to direct sunlight or heat rays which can change the environmental
temperature.
6. Avoid exposing to abnormal vibration.
7. Must be connected to earth.
TERMINATING THE USE OF THE MACHINE
Waste disposal:
When your machine can not work anymore, you should leak out the oil from machine body. Please
storage the oil in a safe place. Ask an environment specialist how to handle the oil to avoid soil
pollution. The oil in machine:
 Hydraulic oil
 Cutting fluid
 Drive shaft grease oil
8‐3