Table of Contents
Advertisement
Quick Links
Factory ID: 001
CONSUMER: READ AND SAVE THESE INSTRUCTIONS
GENERAL HAZARD WARNING:
DANGER
READ AND UNDERSTAND ALL OF THE INSTRUCTIONS IN THIS MANUAL
BEFORE ASSEMBLING, STARTING, OR SERVICING THE HEATER. Be sure to comply with the
instructions and warnings provided with this heater. Failure to comply can result in fire or explosion
that can cause property loss, bodily injury, or loss of life. Only persons who can follow and
understand these instructions should operate or service this heater. If you need heater info; such as
an operating manual, labels, etcetera, contact Pinnacle Products International at 800-641-6996.
NOT FOR USE IN RESIDENTIAL LIVING AREAS OR IN ENCLOSED SPACES
DANGER
WITHOUT ADEQUATE VENTILATION. INDOOR USE PERMITTED ONLY FOR
THE TEMPORARY HEATING OF BUILDINGS OR STRUCTURES UNDER CONSTRUCTION,
ALTERATION OR REPAIR. This is an unvented portable heater that uses air (Oxygen) from within
the area in which it is used. Failure to provide adequate combustion and ventilation air will result in
asphyxiation, carbon monoxide poisoning, bodily injury or death. Refer to "Ventilation" on Page 6.
668 Stony Hill Road #302 Yardley, PA 19067 USA
Fax: (215)-891-8461
Model Numbers
PT-150T-DFV / PT-220T-DFV
HEATER SHOWN WITHOUT SAFETY GUARD. PLEASE
ATTACH SAFETY GUARD BEFORE USING HEATER.
© 2015 Pinnacle Products International, Inc.
• Web: www.masterindustrialproducts.com • Email: info@pinnacleint.com
User's Manual &
Operating Instructions
®
•
Toll Free (800)-641-6996
70-400-0200-14
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Pinnacle Protemp PT-150T-DFV
Summary of Contents for Pinnacle Protemp PT-150T-DFV
- Page 1 Only persons who can follow and understand these instructions should operate or service this heater. If you need heater info; such as an operating manual, labels, etcetera, contact Pinnacle Products International at 800-641-6996. NOT FOR USE IN RESIDENTIAL LIVING AREAS OR IN ENCLOSED SPACES DANGER WITHOUT ADEQUATE VENTILATION.
-
Page 2: Table Of Contents
THE INSTALLATION OF THIS HEATER SHALL COMPLY WITH THE REGULATIONS OF THE AUTHORITIES HAVING JURISDICTION. Look for this icon throughout the manual for helpful tips on how to assemble, use and clean your DFV Heater. © 2015, Pinnacle Products International, Inc. SilentDrive® Forced Air Heater User’s Manual... -
Page 3: Safety Information
Btu / Hr heater rating. Refer to “Ventilation” on once it is plugged in, it can start at anytime in page 6 for further instructions. accordance with the thermostat setting. © 2015, Pinnacle Products International, Inc. SilentDrive® Forced Air Heater User’s Manual... -
Page 4: Features And Specifications
Models: PT-150T-DFV / PT-220T-DFV Shell Control Panel Front Safety Guard Rear Guard Rear Handle Power Cord Support Frame Front Handle Wheel Fuel Gauge Fuel Cap Fuel Tank Drain Plug Figure 1 © 2015, Pinnacle Products International, Inc. SilentDrive® Forced Air Heater User’s Manual... -
Page 5: Assembly
Wheels (2) Safety Guard (1) Axle Nuts (2) Spacers (2) Spare Drain Plug (1) Front Handle Rear Handle Wheel Support Frame Axle Missing Parts? Please Call 800-641-6996 For Assistance © 2015, Pinnacle Products International, Inc. SilentDrive® Forced Air Heater User’s Manual... - Page 6 (4) nuts through the first and second hole from the rear on both sides of the tank lip and wheel support frame and tighten firmly. 8. Attach front guard with the included hardware. © 2015, Pinnacle Products International, Inc. SilentDrive® Forced Air Heater User’s Manual...
-
Page 7: Operation
- NEVER use kerosene that has been stored from one season to the next. Kerosene deteriorates over time. OLD KEROSENE WILL NOT BURN PROPERLY IN THIS HEATER. © 2015, Pinnacle Products International, Inc. SilentDrive® Forced Air Heater User’s Manual... - Page 8 To stop the heater, move the power switch to the “Off” position and unplug the power cord. To restart the heater; wait 10 seconds and follow ignition steps. © 2015, Pinnacle Products International, Inc. SilentDrive® Forced Air Heater User’s Manual...
-
Page 9: Storage
(See Figure 6) Drain Plug Fuel Tank Seal Head Head Flange Seal Cap Figure 6 IMPORTANT: Never store leftover kerosene between seasons, using old fuel can damage heater. © 2015, Pinnacle Products International, Inc. SilentDrive® Forced Air Heater User’s Manual... - Page 10 NOTE: To remove the filter from models turn filter 90º counter-clockwise. See Figure 8. Photocell Wire Fuel Line Fuel Filter Fuel Tank Figure 8 Figure 10 © 2015, Pinnacle Products International, Inc. SilentDrive® Forced Air Heater User’s Manual...
-
Page 11: Wiring Diagram
It may be necessary to soak the nozzle in 1-K kerosene to loosen any dirt particles. Nozzle Face Burner Head Nozzle Dispenser Figure 11 Wiring Diagram Earth Green Earth Green Yellow 250V / 3.15A Figure 12 © 2015, Pinnacle Products International, Inc. SilentDrive® Forced Air Heater User’s Manual... -
Page 12: Troubleshooting Guide
4. Improper electrical connection supply. 3. Check / replace the fuse. between temperature limit sensor and circuit board. 4. Inspect all electrical connections. © 2015, Pinnacle Products International, Inc. SilentDrive® Forced Air Heater User’s Manual... -
Page 13: Exploded View
NEVER LEAVE HEATER UNATTENDED WHILE BURNING OR WHILE CONNECTED TO A POWER SOURCE ® Exploded View © 2015, Pinnacle Products International, Inc. SilentDrive® Forced Air Heater User’s Manual... -
Page 14: Parts List
70-016-2000 70-037-1000 70-037-1000 Ignitor Side Cover 70-008-1100 70-008-1100 70-034-1010 70-034-1010 Power Cord w/ Plug 70-036-2100 70-036-2100 Return Fuel Line 70-036-2000 70-036-2000 Intake Fuel Line Fuel Pump 70-400-0100 70-400-0100 © 2015, Pinnacle Products International, Inc. SilentDrive® Forced Air Heater User’s Manual... - Page 15 70-043-1001 70-043-1001 Handle Bolts Wheel 70-041-1400 70-041-1400 Wheel Axle 70-041-1500 70-041-1510 Wheel Bushing 70-041-1510 70-041-1510 Wheel Nut 70-041-0550 70-041-0550 Safety Guard 70-065-1000 70-065-1000 Control Panel PCB 70-027-1000 70-027-1000 © 2015, Pinnacle Products International, Inc. SilentDrive® Forced Air Heater User’s Manual...
-
Page 16: Warranty
WHILE CONNECTED TO A POWER SOURCE ® LIMITED WARRANTY If Pinnacle Products International, Inc. finds the item to Pinnacle Products International, Inc. warrants this heater to the original retail purchaser only, to be free from defects be in normal operating condition, or not defective the item in material and workmanship for a period of one (1) year will be returned freight collect.
Need help?
Do you have a question about the Protemp PT-150T-DFV and is the answer not in the manual?
Questions and answers