Page 1
DELTA HEAT POWER BURNER INSTALLATION, USE, & CARE MANUAL MODELS: DHPW22 P/N: 17628A 08/20...
Page 3
IMPORTANT SAFETY INSTRUCTIONS WARNING! Read this manual carefully and completely before using your Power Burner to ensure proper operation, proper installation, proper servicing and to reduce the risk of fire, burn hazard and/ or other injury. AVERTISSEMENT! Lire ce manuel avec soin et en entier avant l’utilisation de votre barbecue afin d’en assurer un fonctionnement, une installation et un entretien adéquats et réduire le risque d’in- cendie, de brûlures et d’autres blessures.
Page 4
A Special Message to our Customers... Congratulations on your purchase of Delta Heat Power Burner. Delta Heat is committed to making outdoor cooking products you’ll be proud to own for years. This manual gives you easy to follow instructions for installing, operating and maintaining your Delta Heat Power Burner.
Page 5
Burner. Without the drip pan, hot liquid and debris could leak downward and produce a fire hazard. • The pressure regulator supplied with the Delta Heat Gas Power Burner must be used. Replacement pres- sure regulators must be those specified by Delta Heat.
TABLE OF CONTENTS GETTING STARTED LOCATING THE POWER BURNER GAS SAFETY REQUIREMENTS LP GAS HOOK-UP NATURAL GAS INSTALLATION LEAK TEST ELECTRICAL REQUIREMENT WIRING DIAGRAM BURNER FLAME / AIR SHUTTER ADJUSTMENT POWER BURNER CUT-OUT DIMENSIONS INSULATION JACKET OPERATING INSTRUCTIONS CLEANING & MAINTENANCE 14-15 EXPLODED VIEW REPLACEMENT PARTS LIST...
2. Check to endure that all Power Burner accessories listed below are included. 3. Fill out the Warranty Registration Card and mail it to the indicated address. POWER BURNER ACCESSORIES DHPW22-N DHPW22-L GRATE, ROUND, STAINLESS STEEL GRATE, ROUND, MIDDLE, STAINLESS STEEL...
LOCATING THE POWER BURNER This gas appliance is designed and certified for outdoor use only. Do not locate this Power Burner under overhead combustible surfaces. Do not operate the Power Burner inside a building, garage, recreation vehicle or any enclosed area. CAUTION should be taken when grills are used near glass, vinyl siding or other temperature sensitive construction materials.
If the grill is to be stored indoors, disconnect the gas supply cylinder and leave the cylinder outdoors out of reach of children and must not be stored in a building, garage or any other enclosed area. Delta Heat Service (562) 263-3600 | 3...
(Reference page 6 for leak test procedure). INSTALLER SUPPLIED REGULATOR SET AT 10” WC (LP) BRASS COUPLING 1/2 NPT X 1/2 FLARE (MUST BE PURCHASED FROM DELTA HEAT) FACTORY SUPPLIED HI-PRESSURE LP TYPICAL BOTTOM HOSE ASSEMBLY GAS CONNECTION...
Do not use any replacement regulator other than that specified by DELTA HEAT. Use only pipe sealants that are approved for use with Natural and LP gases. An installer-supplied gas shutoff valve must be installed in an accessible location.
Check to ensure that flexible hoses do not have any cuts and wear that may affect the safety before each use. Only the factory supplied hose and regulator must be used. Use only replace- ment regulator and hose assemblies specified by DELTA HEAT. LEAK TEST 1.
Do not cut or remove the third à la terre. Il ne faut pas couper ou enlever la prong from this plug. broche de mise à la terre de cette fiche. Delta Heat Service (562) 263-3600 | 7...
Page 14
ELECTRICAL REQUIREMENT - cont. The appliance should only be taken apart by a qualified technician, or electrical shock may occur. It is rated at 120VAC, 50/60Hz, and 2.2A. REMINDER: Keep any electrical supply cord and the fuel supply hose away from any heated fea- tures.
BURNER FLAME / AIR SHUTTER ADJUSTMENT Each burner is tested and adjusted at the factory prior to shipment; however, variations in the local gas supply may make it necessary to adjust the burners. The flames of the burner ring should be visually checked.
THESE DIMENSIONS ARE FOR NON-COMBUSTIBLE CONSTRUCTION ONLY. FOR COMBUSTIBLE CONSTRUCTION SEE NEXT PAGE. 22.31 20.75 WIDTH OF UNIT 20.75 11.50 NOTE: 19.50 It is recommended to build the enclosure for the Power Burner 6”-12” LOWER than the countertop. Delta Heat Service (562) 263-3600 | 11...
Do not build the Power Burner under overhead combustible construction. If the Power Burner is to be placed into combustible enclosure, an approved insulating jacket is necessary to prevent fire, proper- ty damage and bodily injury. Use only Delta Heat (DHIJ22) insulating jacket. IMPORTANT If using LP gas cylinder and insulation jacket (DHIJ22), use stainless flexible hose to connect LP gas cylinder to grill regulator.
IMPORTANT: If burner fails to light within 5 seconds, turn off gas and wait 5 minutes before repeat- ing the process. WARNING: If you smell gas, shutoff the gas supply and immediately check for leaks using the soapy water technique outlined in the Leak Test section (Pg 6). Delta Heat Service (562) 263-3600 | 13...
WARNING: It is recommended that your Delta Heat products be kept dry and covered when not in use. This is even more important when long-term storage is intended.
Page 21
1. The smell of gas in conjunction with the burner flames appearing yellow. 2. The burner does not reach temperature. 3. The burner heats unevenly. 4. The burner makes popping noise. Delta Heat Service (562) 263-3600 | 15...
TROUBLESHOOTING GUIDE BEFORE CALLING FOR SERVICE: If your Delta Heat Power Burner does not function properly, use the following troubleshooting guide before contacting your dealer for service. The troubleshooting guide may save the cost of a service call and the inconvenience of being without your Power Burner.
Delta Heat will repair or replace parts found to be defective at no cost to the original purchaser. Warranty service must be performed by a Delta Heat authorized representative during normal busi- ness hours.
HOW TO OBTAIN SERVICE For service, please contact your DELTA HEAT dealer or call DELTA HEAT direct at (562) 263-3600 or (800) 422-0091 or fax (562) 802-3391 Mailing address: DELTA HEAT, Inc. 13259 166th Street Cerritos, CA 90703 Visit us at www.deltaheat.com Please provide: •...
Page 28
CUT HERE PLACE POSTAGE HERE Customer Service ATTN: Warranty Department 13259 166th Street Cerritos, CA 90703 Service Direct Line: (562) 263-3600 Fax: (562) 801-3391...