Page 2: Table Of Contents
The 2003 Chevrolet Corvette Owner Manual Seats and Restraint Systems Front Seats Safety Belts Child Restraints Air Bag System Restraint System Check Features and Controls ... 2-1 Keys ... 2-9 Doors and Locks Windows Theft-Deterrent Systems Starting and Operating Your...
Page 3 GENERAL MOTORS, GM, the GM Emblem, CHEVROLET, the CHEVROLET Emblem and the name CORVETTE and the CORVETTE Emblem are registered trademarks of General Motors Corporation. This manual includes the latest information at the time it was printed. We reserve the right to make changes after that time without further notice.
Page 4 Safety Warnings and Symbols You will find a number of safety cautions in this book. We use a box and the word CAUTION to tell you about things that could hurt you if you were to ignore the warning. These mean there is something that could hurt you or other people.
Page 5 Vehicle Damage Warnings Also, in this book you will find these notices: Notice: These mean there is something that could damage your vehicle. A notice will tell you about something that can damage your vehicle. Many times, this damage would not be covered by your warranty, and it could be costly.
Page 6 These are some examples of vehicle symbols you may find LATCH BOTH LAP AND CAUTION SHOULDER BELTS TO POSSIBLE OCCUPANT PROTECT INJURY DO NOT TWIST SAFETY BELT WHEN AnACHING FAEXST SHIELDING BELTS CAUSTIC MOVE SEAT \ $ % BATTERY FULLY ACIDcoULD REARWARD* CAUSE...
Page 7 Model Reference This manual covers these models: Convertible Coupe...
Page 8: Seats And Restraint Systems
Section Front Seats Manual Seats Power Seats Reclining Seatbacks Seatback Latches Sport Seat ... 1-6 Safety Belts Safety Belts: They Are for Everyone Questions and Answers About Safety Belts ... 1-11 How to Wear Safety Belts Properly Driver Position Safety Belt Use During Pregnancy ... 1-20 Passenger Position ...
Page 9: Front Seats
Front Seats Manual Seats To move a manual seat, pull up on the lever located in front of the seat to unlock it. Slide the seat to where you want it and release the lever. Then try to move the seat with your body to make sure the seat is locked into place.
Page 10: Reclining Seatbacks
Different parts of the power seat control move different parts of the seat. To move the seat forward or rearward, move the control in that direction. Move the control up to raise the seat and down to lower it. By tilting the back of the control, it will raise or lower the back of the seat.
Page 11 But don’t have a seatback reclined if your vehicle is moving. 1 -4 Sitting a reclined position when your vehicle is in motion can be dangerous. Even if you buckle up, your safety belts can’t do their job when you’re reclined like this. The shoulder belt can’t do its job because it won’t be against your body.
Page 12: Seatback Latches
Seatback Latches Both seatbacks fold forward to give you access to the rear area. To fold a seatback forward, lift this latch, which is located on top of the backside of the seat, and ~ c ! ! !he seathack forward Tho seatback down in this position.
Page 13: Sport Seat
Sport Seat 1 -6 If your vehicle has this feature, there are three other controls that help you change the shape of the seat in addition to the power seat control. There are two lumbar supports for the middle (A) and lower (6) back. There’s also a side bolster control (C) that adjusts the sides of the seat around you to give you more lateral support.
Page 14: Safety Belts
Safety Belts Safety Belts: They Are for Everyone This part of the manual tells you how to use safety some belts properly. It also tells you not do with safety belts. Don’t let anyone ride where he or she can’t safety beat properly, If you are in a wear a...
Page 15 In most states and all Canadian provinces, the law says to wear safety belts. Here’s why: They work. You never know if you’ll be in a crash. If you do have a crash, you don’t know if it will be a bad one. A few crashes are mild, and some crashes can be so serious that even buckled up a person wouldn’t survive.
Page 17 The person keeps going until stopped by something. In or the instrument panel ... a real vehicle, it could be the windshield 1-10...
Page 18: Questions And Answers About Safety Belts
or the safety belts! With safety belts, you slow down as the vehicle does. siup get more rime io siup. ‘iou and your strongest bones take the forces. That’s why safety belts make such good sense. Questions and Answers About Safety Belts Won’t I be trapped in the vehicle after an accident if I’m wearing a safety belt?
Page 20: Driver Position
Driver Position This part describes the driver’s restraint system. Lap-Shoulder Belt The driver has a lap-shoulder belt. Here’s how to wear it properly. 1. Close and lock the door. 2. Adjust the seat so you can sit up straight. To see how, see Reclining Seatbacks on page 1-3.
Page 21 1-14 the belt should be worn low and snug on The lap part the hips, just touching the thighs. In a crash, this applies force to the strong pelvic bones. And you’d be less likely to slide under the lap belt. If you slid under it, the belt would apply force at your abdomen.
Page 22 What’s wrong with this? You can be seriously hurt if your shoulder , , I t is too loose. In a crash, you would move forward too much, which could increase injury. The shoulder belt should fit against your body. The shoulder belt is too loose.
Page 23 What’s wrong with this? The belt buckled in the wrong place. 1-16 You can be seriol y Ired if your belt is buckled the wrong place like this. In a crash, the belt would go up over your abdomen. The belt forces would be there, not at the pelvic bones.
Page 24 What’s wrong with this? under the arm. It should The shoulder belt is worn be worn over the shoulder at all times. You can be serious injured if yo shoulder belt under your arm. In a crash, your body would move too far forward, which would increase the chance of head and neck injury.
Page 25 What’s wrong with this? across The belt twisted the body. 1-18 You ea seriously injured In a crash, you wouldn’t have the full width of the belt to spread impact forces. If a belt twisted, make it straight so it can work properly, or ask your dealer to fix it.
Page 26 1-19...
Page 27: Safety Belt Use During Pregnancy
Safety Belt Use During Pregnancy Safety belts work for everyone, including pregnant women. Like all occupants, they are more likely to be seriously injured if they don’t wear safety belts. A pregnant woman should wear a lap-shoulder belt, and the lap portion should be worn as low as possible, below the rounding, throughout the pregnancy.
Page 28: Child Restraints
Child Restraints Older Children Older children who have outgrown booster seats should wear the vehicle’s safety belts. What is the proper way to wear safety belts? If possible, an older child should wear a lap-shoulder belt and get the additional restraint a shoulder belt can provide.
Page 29 Never do this. Here two children are wearing the same belt. The belt can’t properly spread the impact forces. In a crash, the two children can be crushed together and seriously injured. A belt must be used by only one person at a time. 1-22 What if a child is wearing a lap-shoulder belt, but the child is so small that the shoulder belt...
Page 30: Infants And Young Children
Never do this. Here a child is sitting in a seat that has a lap-shoulder belt, but the shoulder part is behind the child. If the child wears the belt in CAUTION: (Continued) this way, in a crash the child might slide under the belt.
Page 31 People should never hold a baby in their arms while riding in a vehicle. A baby doesn’t weigh much until a crash. During a crash a baby will become so heavy it is not possible to hold CAUTION: (Continued) 1-24 In a example, km/h), a 12-lb.
Page 32 What are the different types of add-on child restraints? Add-on child restraints, which are purchased by the vehicle’s owner, are available in four basic types. Selection of a particular restraint should take into consideration not only the child’s weight, height and age but also whether or not the restraint will be compatible with the motor vehicle in which it will be used.
Page 33: Child Restr3.Int Systems
The body s t r u c L e of a young child is ,Ate unlike that of an adult or older child, for whom the safety belts are designed. A young child’s hip bones are still so small that the vehicle’s regular safety belt may not remain low on the hip bones, as it should.
Page 34 A rear-facing infant seat (6) provides restraint with the seating surface against the back of the infant. The system holds the infant in place and, in a crash, h2.rnqss acts to keep the infant positioned in the restraint. A forward-facing child seat (C-E) provides restraint for the child’s body with the harness and also sometimes with surfaces such as T-shaped or shelf-like shields.
Page 35 A booster seat (F-G) is a child restraint designed to improve the fit of the vehicle’s safety belt system. Some booster seats have a shoulder belt positioner, and some high-back booster seats have a five-point harness. A booster seat can also help a child to see out the window.
Page 36 When choosing a child restraint, be sure the child restraint is designed to be used in a vehicle. If it is, it will have a label saying that it meets federal motor vehicle safety standards. Then follow the instructions for the restraint. You may find these instructions on the restraint itself or in a booklet, or both.
Page 37: Top Strap
Top Strap Some child restraints have a top strap, or “top tether”. It can help restrain the child restraint during a collision. For it to work, a top strap must be properly anchored to the vehicle. Some top strap-equipped child restraints are designed for use with or without the top strap being anchored.
Page 38: Location
Once you have the top strap anchored, you’ll be ready to secure the child restraint itself. Tighten the top strap when and as the child restraint manufacturer’s instructions say. Top Strap Anchor Location If your vehicle is a Z06, an anchor bracket for a top strap is located behind the passengers’s seat in the cargo area.
Page 39 In order to use the system, you need either a forward-facing child restraint that has attaching points (B) at its base and a top tether anchor (C), or a rear-facing child restraint that has attaching points (B), as shown here. 1-32 With this system, use the LATCH system instead of the vehicle’s safety belts to secure a child restraint.
Page 40: Securing A Child Restraint Designed For The Latch System
If a LATCH-type child restraint isn’t attached to its anchorage points, the restraint won’t be able to protect a child sitting there. In a crash, the child could be seriously injured or killed. Make sure that a LATCH-type child restraint is properly installed using the anchorage points, or use the vehicle’s safety belts to secure the restraint.
Page 41: Securing A Child Restraint In The Passenger Seat Position
Securing a Child Restraint in the Passenger Seat Position Your vehicle has a passenger air bag. There’s an air bag off switch in the glove box you can use to turn off the passenger’s air bag when you want to secure a rear-facing child restraint at the passenger’s position.
Page 42 Unless the passenger’s air bag has been turned off, never put a rear-facing child restraint in this vehicle. Here’s why: A child in a rear-facing child restraint can be seriously injured or killed if the passenger’s air bag inflates. This is because the back of the rear-facing child restraint would be very close to the inflating air bag.
Page 43 You’ll be using the lap-shoulder belt. See Top Strap on page 1-30 if the child restraint has one. Be sure to follow the instructions that came with the child restraint. Secure the child in the child restraint when and as the instructions say.
Page 44 5. Pull the rest of the lap belt all the way out retractor to set the lock. To tighten the belt, feed the lap belt back into the retractor while you push down on the child restraint. You may find it helpful to use your knee to push l-!l-l dowr lllU...
Page 45 To remove the child restraint, just unbuckle the vehicle’s safety belt and let it go back all the way. The safety belt will move freely again and be ready to work for an adult or larger child passenger. If you were using a rear-facing child restraint, turn on the passenger’s air bag when you remove the rear-facing child restraint from the vehicle unless the person who will be sitting there is a member of a...
Page 46: Air Bag System
Air Bag System This part explains the air bag system. Your vehicle has air bags one air bag for the driver and another air bag for the passenger. Frontal air bags are designed to help reduce the risk of injury from the force of an inflating air bag. But these air bags must inflate very quickly to do their job and comply with federal regulations.
Page 47: Where Are The Air Bags
yone who i ~p -ainst, or vc any air bag when it inflates can be seriously injured or killed. Air bags plus lap-shoulder belts offer the best protection for adults, but not for young children and infants. Neither the vehicle’s safety belt system nor its air bag system is designed for them.
Page 48 The passenger’s air bag is in the instrument panel passenger’s side. If something is between an occupant and an air bag, the bag might not inflate properly or it might force the object into that person causing severe injury or even death. The path of an inflating air bag must be kept clear.
Page 49: When Should An Air Bag Inflate
When Should an Air Bag Inflate? An air bag is designed to inflate in a moderate to severe frontal, or near-frontal crash. The air bag will inflate only if the impact speed is above the system’s designed “threshold level”. If your vehicle goes straight into a wall that doesn’t move or deform, the threshold level is about 9 to 15 mph (14 to 24 km/h).
Page 50: Air Bag Inflates
What Will You See After an Air Bag Inflates? After the air bag inflates, it quickly deflates, so quickly that some people may not even realize the air bag inflated. Some components of the air bag module steering wheel hub for the driver’s air bag, the instrument panel for the passenger’s bag for a short time.
Page 51: Air Bag Off Switch
Additional windshield breakage may also occur from the passenger air bag. Air bags are designed to inflate only once. After an air bag inflates, you’ll need some new parts for your air bag system. If you don’t get them, the air bag system won’t be there to help protect you in another crash.
Page 52 Infant. An infant (less than 1 year old) must ride in the front seat because: my vehicle has no rear seat; my vehicle has a rear seat too small to accommodate a rear-facing infant seat; or the infant has a medical condition which, according to the infant’s physician, makes it necessary for the infant to ride in the front seat so that the driver can constantly monitor the child’s condition.
Page 53 off the passenger’s air bag, insert your ignition To turn key into the switch, push in, and move the switch to the off position. The AIR BAG OFF light on the center console switch panel will come on to let you know that the passenger’s air bag is off.
Page 54: Servicing Your Air Bag-Equipped Vehicle
To turn the passenger’s air bag on again, insert your ignition key into the switch, push in, and move the switch position. tn !he Servicing Your Air Bag-Equipped Vehicle Air bags affect how your vehicle should be serviced. There are parts of the air bag system in several places around your vehicle.
Page 55: Restraint System Check
Restraint System Check Checking Your Restraint Systems Now and then, make sure the safety belt reminder light and all your belts, buckles, latch plates, retractors and anchorages are working properly. Look for any other loose or damaged safety belt system parts. If you see anything that might keep a safety belt system from doing its job, have it repaired.
Page 56 If you ever see a label on the driver’s safety belt that says to replace the belt, be sure to do so. Then the new belt will be there to help protect you in a collision. You would see this label on the belt near the latch plate. If belts are cut or damaged, replace them.
Page 58: Features And Controls
Section 2 Keys ... Remote Keyless Entry System Remote Keyless Entry System Operation Doors and Locks ... Door Locks Power Door Locks ... Lockout Protection ... Leaving Your Vehicle ... Hatchnrun k ... Windows ... Power Windows ... Sun Visors ... Theft-Deterrent Systems ...
Page 59 Storage Areas Glove Box Cupholder(s) Center Console Storage Area Floor Mats Rear Storage Area Convenience Net Cargo Cover ... eatures an 2.39 Roof Panel . -2-39 Removing the Roof Panel 2.39 Storing the Roof Panel ... 2.39 Installing the Roof Panel 2.40 Convertible Top ...
Page 60 Leaving children in a vehicle with the igni, key is dangerous for many reasons. A child or others could be badly injured or even killed. They could operate the power windows other controls or even make the vehicle move. Don't leave the keys in a vehicle with children.
Page 61: Remote Keyless Entry System
So be sure you have spare keys. If you ever do get locked out of your vehicle, call Chevrolet Roadside Assistance. See Roadside Assisfance Remote Keyless Entry System Your vehicle has a Remote Keyless Entry (RKE) system...
Page 62: Remote Keyless Entry System Operation
Changes or modifications to this system by other than an authorized service facility could void authorization to use this equipment. If you ever notice a decrease in the remote keyless entry transmitter range, try doing one of the following: Check the distance. You may be too far from your vehicle.
Page 63 The driver’s door will unlock when the unlock button on the remote keyless entry transmitter is pressed, or press the unlock button again within five seconds to unlock both doors. Also, by pressing the unlock button, it may automatically disarm your theft-deterrent system, depending on how the theft-deterrent system is programmed.
Page 64 Matching Transmitter(s) to Your Vehicle Each remote kevless entw transmitter is coded to prevent anothertransmitter from unlocking your vehicle. If a transmitter is lost or stolen, a replacement can be purchased through your dealer. Remember to bring any remaining transmitters with you when you go to your dealer.
Page 65 Battery Replacement Under normal use, the battery in your remote keyless entry transmitter should last about three years. You can tell the battery is weak if the transmitter won’t work at the normal range in any location. If you have to get close to your vehicle before the transmitter works, it’s probably time to change the battery.
Page 66: Doors And Locks
Doors and Locks Door Locks ’ Unlocked )ors can be dangerous. Passengers especially children easily open the doors and fall out moving vehicle. When a door is locked, the handle won’t open it. You increase the chance of being thrown 0i;a in a crash if the doors aren’t locked.
Page 67: Power Door Locks
Power Door Locks Press the power door switch on either door to unlock or lock both doors at once. 2-1 0 Lockout Protection If you press the power door lock switch when a door is open and a key in the ignition, a chime will sound. door If the power lock switch is pressed again within five...
Page 68: Hatchnrunk
Hatchnrunk It can be dangerous to drive with the hatch/ trunk lid open because carbon monoxide (CO) gas can come into your vehicle. You can’t see or smell CO. can cause unconsciousness and even death. If you must drive with the trunk lid open or if electrical wiring or other cable connections must pass through the seal between the body and the hatchhrunk lid:...
Page 69 Hatchnrun k Lid Release To use the hatchhunk lid release on vehicles with an automatic transmission, your vehicle must be in PARK (P) or NEUTRAL (N). For manual transmissions, set the parking brake. See Parking Brake on page 2-30. Press the button with the trunk symbol on at the left side of the steering column on the instrument panel, to release the hatch/trunk lid from inside your vehicle.
Page 70 If your vehicle is equipped with a convertible top/hardtop and you have lost battery power, use the manual release cable to open the trunk lid. To access the cable, remove the center storage compartment lid located in the rear of the trunk area. See Rear Storage Area on page 2-37 for more information.
Page 71: Windows
Windows Leaving children in a ve,,,Ae with the windows closed is dangerous. A child can be overcome by the extreme heat and can suffer permanent injuries or even death from heat stroke. Never leave a child alone in a vehicle, especially with the windows closed in warm or hot weather.
Page 72: Power Windows
Power Windows With power windows, switches on the door control each window when the ignition is on or when RAP present. See “Retained Accessory Power Ignition Positions on page 2-20. Express-Down Window Both driver’s and passenger’s window switches have the express-down feature. Tap AUTO and immediately release.
Page 73: Theft-Deterrent Systems
Theft-Deterrent Systems Vehicle theft is big business, expecially in some cities. Although your vehicle has a number of theft-deterrent features, we know that nothing we put on it can make it impossible to steal. However, there are ways you can help. Theft-Deterrent System Your vehicle is equipped with a theft-deterrent alarm system.
Page 74: Pass-Key
Testing the Alarm Use the following to test the system: 1. Make sure the hatchhrunk lid is latched. 2. Lower the window on the driver’s door. 3. Manually arm the system. 4. Close the doors and wait 15 seconds. 5. Reach through the open window and manually unlock the driver’s door.
Page 75 If you lose or damage a PASS-Key@ ignition key, see your dealer or a locksmith who can service PASS-Key@ In an emergency, call Chevrolet Roadside Assistance. See Roadside Assistance Program on page 7-5 for more information.
Page 76: Starting And Operating Your Vehicle
Starting and Operating Your Vehicle New Vehicle Break-In Notice: Your vehicle doesn’t need an elaborate ”break-in.” But it will perform better in the long run if you follow these guidelines: Keep your speed at 55 mph (88 km/h) or less for the first 500 miles (805 km).
Page 77: Ignition Positions
Ignition Positions With the key in the ignition switch, you can turn it to four different positions. OFF: This is the only position from which you can remove the key. If you have an automatic transmission, the ignition switch can’t be turned to OFF unless the shift lever PARK (P).
Page 78: Starting Your Engine
When the engine is not running, ACC and ON allow you to operate your electrical accessories, such as the radio. A warning tone will sound if you open the driver’s door while the ignition is in OFF or ACC and the key is in the ignition.
Page 79 When starting your engine in very cold weather (below 0°F or -18”C), do this: 1. With your foot off the accelerator pedal, turn the ignition key to START and hold it there up to 15 seconds. When the engine starts, let go of the key.
Page 80: Engine Coolant Heater (Canada Only)
Engine Coolant Heater (Canada Only) The engine coolant heater is located on the driver’s side of the engine under the manifold. In very cold weather, 0°F (-18°C) or colder, the engine coolant heater can help. You’ll get easier starting and better fuel economy during engine warm-up. Usually, the coolant heater should be plugged in a minimum of four hours prior to starting your vehicle.
Page 81: Automatic Transmission Operation
4. Before starting the engine, be sure to unplug and store the cord as it was before to keep it away from moving engine parts. If you don’t it could be damaged. How long should you keep the coolant heater plugged in? The answer depends on the outside temperature, the kind of oil you have, and some other things.
Page 82 : is lngerous to get out of yc shift lever is not fully in PARK parking brake firmly set. Your vehicle can roll. Don’t leave your vehicle when the engine is running unless you have to. If you have left the engine running, the vehicle can move suddenly.
Page 83 NEUTRAL (N): In this position, your engine doesn’t connect with the wheels. To restart when you’re already moving, use NEUTRAL (N) only. Also, use NE1 JTRAL (N) when your vehicle is being towed. Sh ng into a driv Jear “racing” (running at high speed) is dangerous. Unless your foot is firmly on the brake pedal, your vehicle could move very rapidly.
Page 84: Manual Transmission Operation
Nofice: If your rear wheels won’t turn, don’t try to drive. This might happen if you were stuck in very deep sand or mud or were up against a solid object. You could damage your transmission. Also, if you stop when going uphill, don’t hold your vehicle there with only the accelerator pedal.
Page 85 NEUTRAL: Use this position when you start or idle your engine. Your shift lever is in NEUTRAL when it is centered in the shift pattern, not in any gear. REVERSE (R): To back up, press down the clutch pedal and shift into REVERSE (R). Just apply pressure to get the lever past FIFTH (5) and SIXTH (6) into REVERSE (R).
Page 86 If your engine speed drops below 900 rpm, or if the engine is not running smoothly, you should downshift to the next lower gear. You may have to downshift two or more gears to keep the engine running smoothly or for good engine performance.
Page 87: Parking Brake
If your vehicle is a Z06, do not downshift into a gear shown below at a speed greater than shown in the table: Notice: If you skip more than one gear when you you race the engine when you downshift, or release the clutch pedal while downshifting, you could damage the engine, clutch, driveshaft or the transmission.
Page 88: Shifting Into Park (P)
To release the parking brake, hold the brake pedal down. Then push the release button in as you move the parking brake lever all the way down. Notice: Driving with the parking brake on can cause your rear brakes to overheat. You may have to replace them, and you couia aiso damage other parts of your vehicle.
Page 89 Move the shift lever into PARK (P) by holding in the button on the lever and pushing the lever all the way toward the front of the vehicle. Turn the ignition key to OFF. Remove the key and take it with you. If you can remove the key from the ignition, the vehicle is in PARK (P).
Page 90: (Automatic Transmission)
Torque Lock (Automatic Transmission) If you are parking on a hill and you don’t shift your transmission into PARK (P) properly, the weight of the vehicle may put too much force on the parking pawl in the transmission. You may find it difficult to pull the shift lever out of PARK (P).
Page 91: Parking Your Vehicle (Manual Transmission)
If you ever hold the brake pedal down but still can’t shift out of PARK (P), try this: ACC. 1. Turn the key to 2. Apply and hold the brake until the end of Step 4. 3. Shift to NEUTRAL (N).
Page 92: Engine Exhaust
Engine Exhaust Engine exhaust can kill. It contains the gas carbon monoxide (CO), which you can’t see or smell. It can cause unconsciousness and death. You might have exhaust coming in if: Your exhaust system sounds strange or different. rusty Your vehicle gets underneath.
Page 93: Running Your Engine While You Are Parked (Automatic Transmission)
Running Your Engine While You Are Parked (Automatic Transmission) It’s better not to park with the engine running. But if you ever have to, here are some things to know. Idling the engine with the climate control system off could allow dangerous exhaust into your vehicle.
Page 94: Mirrors
Mirrors Manual Rearview Mirror An inside rearview mirror is attached above the windshield. The mirror pivots so that you can adjust it. You can adjust the mirror for day or night driving. Pull the tab for night driving to reduce glare. Push the tab forward for daytime driving.
Page 95: Outside Automatic Dimming Mirror
Outside Power Heated Mirrors The power mirror control is the driver’s door. It controls the driver’s and passenger’s mirrors. To adjust either mirror, press the LT (left) or RT (right) button to select the mirror, then press the arrows to adjust the direction of the mirror.
Page 96: Storage Areas
Storage Areas Glove Box To open the glove box, lift up on the lever. Use your door key to lock or unlock it. The glove box has a light inside. Cupholder(s) The cupholder is located on the center console in front of the ashtray.
Page 97: Floor Mats
Floor Mats If your vehicle has floor mats, they are specially designed to remain in position under your feet and out of reach of the accelerator pedal. The driver’s side floor mat is held in place by two locator hooks and the passenger’s side is held in place by one.
Page 98: Rear Storage Area
Rear Storage Area There are three rear storage compartments in the floor of the rear hatchhrunk area. Coupe shown, Convertible and 206 similar If you have a coupe or convertible model, your vehicle will be equipped with three storage compartment lids.
Page 99: Convenience Net
Notice: If your vehicle is equipped with the optional trunk-mounted CD changer, it center rear storage compartment. To help avoid damage to the compact disc player, do not store items such as liquids or sharp objects that could damage, puncture or cut the trunk-mounted CD changer or wiring.
Page 100: Roof Panel
Roof Panel Your vehicle may have a removable roof panel. Remov9g Roof Parnl Don’t try to remove a roof panel while the vehicle is moving. Trying to remove the roof panel while the vehicle is moving could cause an accident. The panel could fall into the vehicle and cause you to lose control, or it could fly off and strike another vehicle.
Page 101 5. Lower the windows and open the doors. There are two latches on the front of the roof panel near each door (A), and one rear latch (B). 2-44 6. To unlock the front of the roof panel, pull down each of the front handles.
Page 102 7. To unlock the rear of the roof panel, press the latch release button with your thumb and pull down the latch lever with your fingers. 8. After releasing the latches, return the sun visors to the forward position. 9. Stand on one side of the vehicle and, if necessary, have your helper stand on the other side.
Page 103: Storing The Roof Panel
Storing the Roof Panel If a roof panel is not stored properly, it could be thrown about the vehicle in a crash or sudden maneuver. People in the vehicle could be injured. Whenever you store a roof panel in the vehicle, always be sure that it is stored securely in the proper location.
Page 104 4. Gently lower the roof panel onto the carpeted ledge. Then, pull each release rearward and upward to place the storage pins into the holes of the roof panel. 5. Gently lift and lower the roof panel to be sure locked into place.
Page 105 If the roof panel is stored in the rear area, grasp it with your right hand at the middle edge near the seatbacks, and with your left hand at the middle of the edge closest to you. Reverse the steps described previously under Storing the Roof Panel on page 2-46.
Page 106: Convertible Top
Convertible Top If your vehicle has this feature, the following procedures explain the proper operation the convertible top. Notice: Certain automatic car washes may cause damage to the vehicle. The top fabric can be damaged by top cleaning brushes. For care and cleaning the convertible top, see "Cleaning Your Convertible Top"...
Page 107: Lowering The Convertible Top
Lowering the Convertible Top Notice: Don’t leave the convertible out with the top down for any long periods of time. The sun and rain can damage the seat material and other things inside the vehicle. 1. Set the parking brake firmly. Shift an automatic transmission into PARK (P).
Page 108 4. Lift upward on the front edge (A) of the convertible top off of the windshield frame. Then lift upward on the rear edge (B) of the convertible top to be vertical off the storage compartment lid (C). The front edge (A) and rear edge (B) should be straight down 3 .
Page 109 If the vehicle has lost battery power, you can still open the storage compartment lid (C) using the manual release cable. The cable is located underneath the carpeting behind the driver’s and passenger’s seats, in the center of the vehicle. When using the manual release, you must first open the doors to prevent damage to the seals.
Page 110: Raising The Convertible Top
7. Then move the top rearward to its fully-stored position. 8. After the top is stored, apply one even push on the center of the front edge (A) of the convertible top to assure that the top is fully retracted. 9.
Page 111 3. Pull the top up by firmly gripping the front edge (A) of the convertible top with your hand and applying a brisk, firm upward and forward motion to get the top in the full-up position. 2-54 4. Lift the rear edge of the convertible full-up position by first raising the front edge (A).
Page 112: Vehicle Personalization
Vehicle Personalization Memory p n r MEMORY can store and has this featlJre, ?IP~~CI!P recall the settings for the driver’s seat position, the outside rearview mirror positions, telescopic steering column (if equipped), radio presets, tone, volume, playback mode (AMIFM, tape or CD), last displayed station, compact disc position and tape direction and the last ciimate controi setting.
Page 113 Your memory settings are now programmed. Any changes that are made to the audio system and climate controls while driving will be automatically stored when the ignition key is turned off. When first entering your vehicle, after pressing the unlock button on your remote keyless entry transmitter or a MEMORY button, a recall of your settings will occur when the door is closed and the ignition key is in the ignition switch.
Page 114: Instrument Panel
Section 3 Instrument Panel Overview ... Hazard Warning Flashers Other Warning Devices Horn Tilt Wheel Turn Signal/Multifunction Lever Exterior Lamps ... Interior Lamps ... Head-Up Display (HUD) ... Accessory Power Outlets Ashtrays and Cigarette Lighter Climate Contrsis ... 3.22 Dual Automatic Climate Control System Outlet Adjustment ...
Page 116 The main components of your instrument panel are the following: A. Instrument Panel Brightness Control B. Head-Up Display Controls C. Turn SignaVMultifunction Lever D. Driver Information Center (DIC) (Located in the Instrument Cluster) E. Instrument Panel Cluster F. Windshield Wiperwasher Lever G.
Page 117: Hazard Warning Flashers
Hazard Warning Flashers Your hazard warning flashers let you warn others. They also let police know you have a problem. Your front and rear turn signal lamps will flash on and off. The hazard warning flasher button is located on the instrument panel above the audio system.
Page 118: Horn
Horn To sound the horn, press either horn symbol on the steering wheel. Ti It Wheel A tilt wheel allows you to adjust the steering wheel before you drive. You can raise it to the highest level to give your legs more room when you exit and enter the vehicle.
Page 119 Turn SignaVMultifunction Lever The lever on the left side of the steering column includes the following: Turn and Lane-Change Signals Headlamp High/Low-Beam Changer Flash-to-Pass Feature Cruise Control For information on exterior lamps, see Exterior Lamps page Turn and Lane-Change Signals The turn signal has two upward (for right) and two downward (for left) positions.
Page 120 Turn Signal on Chime A chime will remind you if you leave the turn signal on for more than 3/4 mile (1.2 km) of driving. If you need to leave the turn signal on for more than 3/4 mile (1.2 km), turn off the signal and then turn it back on.
Page 121 INT (Intermittent): Move the lever to INT to choose a delayed wiping cycle. Turn the INT ADJ band down for a longer delay or up for a shorter delay. The further the INT ADJ band is turned upward, the shorter the delay will be and the further the INT ADJ band is turned downward, the longer the delay will be.
Page 122 Cruise Control With cruise control, you can maintain a speed of about 25 mph (40 km/h) or more without keeping your foot on the accelerator. This can really help on long ..,- L . - - A , . . . : - - x..-I J - - - .--L...
Page 123 Setting Cruise Cc-trol If you leave your cruise control on when y not using cruise, you might hit a button ana go into cruise when you don’t want to. You could be startled and even lose control. Keep the cruise control switch off until you want to use cruise control.
Page 124 Reducing Speed While Using Cruise Control There are two ways to reduce speed while using cruise control: Press in the SET button at the end of the lever until you reach the lower speed you want, then release it. To slow down in very small amounts, press the SET button briefly.
Page 125: Exterior Lamps
Exterior Lamps The exterior lamp switch on the turn signal/multifunction lever operates the headlamps. The exterior lamp switch has three positions: OFF: Turning the switch to this position turns off all lamps, except the Daytime Running Lamps (DRL). (Parking Lamps): Turning the switch to this position turns on the parking lamps, together with the following: Taillamps...
Page 126 You can open the doors manually using the knob next to the headlamp assembly. Turn the knob counterclockwise until the doors are open. Turn the knob clockwise to close the doors manually. The headlamp doors should be open when driving in icy or snowy conditions to prevent the doors from freezing closed and when washing the vehicle to help clean the headlamps.
Page 127 Fog Lamps Your vehicle may have this feature. Use the fog lamps for better vision in foggy or misty conditions. Your parking lamps or low-beam headlamps must be on or the fog lamps won’t work. To turn the fog lamps on, press the button located on the instrument panel, to the left of the steering column.
Page 128: Interior Lamps
Make sure your instrument panel brightness control is in the full bright position. See “Instrument Panel Brightness” later in this section. With Twilight §entinel@ turned on, you can idle the vehicle with the lamps off, even when it’s dark outside. First set the parking brake while the ignition is in OFF.
Page 129 Parade Mode The instrument panel brightness knob has an added feature called parade mode to assist you in seeing certain instrument panel controls if your headlamps are on in the daylight. Turn the knob counterclockwise to dim the instrument panel lights or clockwise to brighten the lights.
Page 130: Head-Up Display (Hud)
Battery Run-Down Protection Your vehicle has a feature to help prevent you from draining the battery in case the underhood lamp, vanity mirror lamps, cargo lamps, reading lamps, console or glove box lamps are accidentally left on. If you leave any of these lamps on, they will automatically timeout after about 15 minutes.
Page 131 There are five HUD selections that you can choose to view in the HUD display. By pressing and holding the PAGE button, you can scroll through these pages in the following order: Speed Only Speed and Gage Speed, Tachometer and Gage Speed and Tachometer Tachometer Only When you have chosen the desired HUD display,...
Page 132 The HUD controls are located to the left of the steering wheel. To adjust the HUD so you can see it properly, do the following: 1. Start your engine and slide the HUD dimmer control all the way up. The brightness of the HUD image is determined by the light conditions in the direction your vehicle is facing and where you have the HUD dimmer control set.
Page 133: Accessory Power Outlets
If the sun comes out or it becomes cloudy, you may need to adjust the HUD brightness again using the dimmer control. Polarized sunglasses could make the HUD image harder to see. To change from English to metric units, press the E/M button located to the right of the steering wheel.
Page 134: Ashtrays And Cigarette Lighter
When adding electrical equipment, be sure to follow the installation instructions included with the equipment. We recommend that you see a qualified technician or your dealer for the proper installation of your equipment. Notice: Power outlets are designed for accessory plugs only.
Page 135: Climate Controls
Climate Controls Dual Automatic Climate Control System With this system you can control the heating, cooling and ventilation for your vehicle. 3-22 When your vehicle is first started, the display will show the driver’s temperature setting, the fan speed and the air delivery for approximately five seconds;...
Page 136 After a five-second display of the current settings, only the word AUTO and the outside temperature will be shown on the digital display unless the system is set to full cold 60°F (16°C) or full hot 90°F (32”C), then the word AUTO will not display.
Page 137 To change the current mode, select one of the following: f;’ (Vent): This mode directs most of the air to the instrument panel outlets, with a very small amount of air directed to the floor outlets. (Bi-Level): This mode directs approximately half of the air to the instrument panel outlets, and then directs most of the remaining air to the floor outlets.
Page 138 & I (Recirculation): This mode keeps outside air from coming in the vehicle. It can be used to prevent outside air and odors from entering your vehicle or to help cool the air inside your vehicle more quickly. Press this button to turn the recirculation mode on or off. When the button is pressed, an indicator light will come on.
Page 139 You may notice a slight change in engine performance when the air-conditioning compressor shuts off and turns on again. This is normal. The system is designed to make adjustments to help with fuel economy while still maintaining the selected temperature. On hot days, open the windows to let hot inside air escape;...
Page 140 There is also an inside temperature sensor located to the left of the ignition switch. The automatic climate control system uses this sensor to receive information, so if you block or cover it, the system will not function properly. Defogging and Defrosting There are two modes to clear fog or frost from your windshield.
Page 141: Outlet Adjustment
The rear window defogger will automatically turn off approximately 15 minutes after the button is pressed. If turned on again, the defogger will only run for approximately seven minutes before turning off. The defogger can also be turned off by pressing the button again or by turning off the engine.
Page 142: Warning Lights, Gages
Warning Lights, Ga Indicators This part describes the warning lights and gages that may be on your vehicle. The pictures will help you locate them. Warning lights and gages can signal that something is wrong before it becomes serious enough to cause an expensive repair or replacement.
Page 143: Instrument Panel Cluster
Instrument Panel Cluster Your instrument panel cluster and Driver Information Center (DIC) are designed to let you know at a glance how the vehicle is running. You’ll know how fast you’re going, about how much fuel you have left and many other things you’ll need to know to drive safely and economically.
Page 144: Speedometer And Odometer
Speedometer and Odometer Your speedometer lets you see your speed in either miles per hour (mph) or kilometers per hour (km/h). There is only one scale for mph and km/h. When you press the E/M (English/metric) button on the Driver Information Center (DIC), the cluster will calculate the proper speed and move the needle to the correct position.
Page 145: Air Bag Readiness Light
Air Bag Readiness Light There is an air bag readiness light on the instrument panel, which shows a deployed air bag symbol. The system checks the air bag’s electrical system for malfunctions. The light tells you if there is an electrical problem.
Page 146 If the passenger’s air bag is turned off for a person who isn’t in a risk group identified by the national government, that person won’t have the extra protection of an air b a g h a crash, the air bag wouldn’t be able to inflate and help protect the person sitting there.
Page 147: Voltmeter Gage
If the air bag readiness light ever comes on when you have turned off the air bag, it means that something may be wrong with the air bag system. The passenger’s air bag could inflate even though the switch is off. If this ever happens, don’t let anyone whom the national government has identified as a member of a passenger air bag risk group sit in the...
Page 148: Brake System Warning Light
Brake System Warning Light Your vehicle’s hydraulic brake system is divided into two parts. If one part isn’t working, the other part can still work and stop you. For good braking, though, you need both parts working well. This light should come on when you turn the ignition key to START.
Page 149: Anti-Lock Brake System Warning Light
Anti-Lock Brake System Warning Light With the anti-lock brake system, the light will come on when your engine is started and may stay on for several seconds. That’s normal. If the light stays on, turn the ignition to OFF. Or, if the light comes on when you’re driving, stop as soon as possible and turn the ignition off.
Page 150: Active Handling System Light
Active Handling System Light The Active Handling System light will come on briefly as you start the engine. If the light does not come on then, have it fixed so it will be ready to warn you if there is a problem. The light will also come on while the system warms up and the ACT HNDLING WARMING UP message will be displayed in the Driver Information Center (DIC).
Page 151: Engine Coolant Temperature Gage
Engine Coolant Temperature Gage United States This gage shows the engine coolant temperature. If the gage pointer moves into the shaded area, your engine is too hot. This means that your engine coolant has overheated. If You have been operating your vehicle under normal driving conditions, you should pull off the road, stop your vehicle and turn off the engine as soon as possible.
Page 152 Nofice: Modifications made to the engine, transmission, exhaust, intake or fuel system of your vehicle or the replacement of the original tires with other than those of the same Tire Performance Criteria (TPC) can affect your vehicle’s emission controls and may cause this light to come on. Modifications to these systems repairs not covered by your warranty.
Page 153 Did you just drive through a deep puddle of water? If so, your electrical system may be wet. The condition will usually be corrected when the electrical system dries out. A few driving trips should turn the light off. Have you recently changed brands of fuel? If so, be sure to fuel your vehicle with quality fuel.
Page 154: Engine Oil Pressure Gage
Engine Oil Pressure Gage United States The engine oil pressure gage shows the engine oil pressure in psi (pounds per square inch) or kPa (kilopascals) when the engine is running. Oil pressure should be 20 to 80 psi (140 to 550 kPa). in certain situations such as long, extended idles on hot .--: 1 - 1...
Page 155: Security Light
Security Light This light comes on to remind you to arm your theft-deterrent system. If it SECURITY comes on and stays on when your ignition is on, there may be a problem with your theft-deterrent system. See Theft-Deterrent System on page 2- 16 and PASS-Key on page 2- 17.
Page 156 Press RESET to acknowledge a DIC message(s). Pressing RESET will also turn off a DIC message but the LOW FUEL message will come on again in 10 minutes if you have not added fuel to the vehicle. Here are five things that some owners ask about. All these things are normal and do not indicate that anything is wrong with the fuel gage.
Page 157: Driver Information Center (Dic)
Driver Information Center (DIC) The Driver Information Center (DIC) will display information about how your vehicle is functioning, as well as warning messages if a system problem is detected. The DIC display area is located in the instrument panel cluster below the speedometer and tachometer, directly above the steering column.
Page 158 Dl6 Controls an Displays Turn on the system by turning the ignition to ON. When you turn on the ignition, the DIG will be in the mode last displayed when the engine was turned off. Each Dl@ button allows you to scroll through a menu. A blank page ends each menu.
Page 159 Press FUEL again to display instantaneous fuel economy, such as: INST. 20.1 MPG or INST. 5.3 UlOO km Press FUEL again to display the range, such as: RANGE 20 MI or RANGE 32 km The range calculates the remaining distance you can drive without refueling.
Page 160 Press the GAGE button again to display the oil temperature, such as: OIL TEMP 234°F or OIL TEMP 112°C Press the GAGE button again to display the coolant temperature, such as: COOLANT TEMP 123°F or COOLANT TEMP 51°C Press the GAGE button again to display the automatic transmission fluid temperature, such as: TRANS FLUID 123°F or TRANS FLUID 51°C...
Page 161 Odometer The odometer shows how far your vehicle has been driven in either miles or kilometers. Press the TRIP button to display odometer readings such as: ODOMETER 12345 MI or ODOMETER 20008 km Without the keys in the ignition, you can also display the odometer by turning on the parking lamps.
Page 162 Average Speed Press the TRIP button until the average speed displayed, such as: AVERAGE SPEED 62 MPH or AVERAGE SPEED 100 km/h Press reset in this mode to start calculating the average speed. Press and hold RESET to clear. Engine Oil Life Press the TRIP button until the engine oil life is displayed, such as OIL LIFE REMAIN 89%.
Page 163 OPTIONS This button allows you to choose personal options that may be available your vehicle, depending on the options your vehicle is equipped with. Some of these functions work along with the remote keyless entry transmitter. When returning to the options menu, the first item of the options list will always be displayed, not the one you were last in when you changed buttons.
Page 164 If you choose LOCK & ARM OFF, you will receive no security feedback when locking or unlocking your vehicle. If you choose LOCK & ARM HORN ONLY, only the horn will chirp to let you know when your alarm system has armed when locking your vehicle.
Page 165 Auto Unlock The AUTO UNLOCK will be available only if AUTO LOCK set to ON as described previously. Press the OPTIONS button until AUTO UNLOCK appears on the display, then use the RESET button to page through the following choices: AUTO UNLOCK DRIVER AUTO UNLOCK BOTH AUTO UNLOCK OFF...
Page 166 Blank Page There is a blank page at the end of the OPTIONS menu. When the blank page is displayed, you can access the following items: FOB TRAINING: This option allows you to match the RKE transmitter(s) to your vehicle. You can access this option by pressing and holding RESET for three seconds while you are on the blank page at the end of the OPTIONS menu.
Page 167 ACT HNDLG WARMING UP: When you first start your vehicle (especially during cold winter weather), and begin to drive away (up to 6 mph (10 km/h)), the message ACT HNDLG WARMING UP may be displayed in the DIC, the instrument panel cluster light will be on, and a chime will sound.
Page 168 If the SERVICE ABS message is being displayed, your Traction Control System and the Active Handling System will also be disabled. The Driver Information Center will scroll three messages: SERVICE ABS, SERVICE TRACTION SYS and SERVICE ACTIVE HNDLG, and the instrument cluster car icon will be illuminated.
Page 169 REDUCED ENGINE POWER: You will hear chimes continuously when this message is displayed. To acknowledge that you have read the message and to remove it from the display, press RESET. The message will reappear every 15 seconds until this condition changes.
Page 170 TRACTION SYSTEM OFF: You will hear a single quick tone when this message is displayed. This message comes on and stays on when the Traction Control System button on the console is pressed to turn the system off. To acknowledge this message, press RESET.
Page 171 COOLANT OVER TEMP: You will hear four chimes and the CHECK GAGES telltale will come on when this message is displayed. To acknowledge the warning, press the RESET button. After you press the RESET button, a message will be displayed and you will hear a chime every minute until this condition changes.
Page 172 SERVICE ACTIVE HANDLING: If the SERVICE ACTIVE HNDLG message is displayed, there is a problem with your Active Handling System and your vehicle needs service. The instrument cluster light will also be on and a chime will sound. When this message is displayed, the system is not working.
Page 173 This message indicates that the pressure in one of your tires is lower than 5 psi (34 kPa). Next to the FLAT TIRE message, you can see either LF (left front), LR (left rear), RF (right front) or RR (right rear) to indicate to you which tire is flat.
Page 174 Other Messages Here are more messages that you can receive on your Driver Information Center (DIC). To acknowledge a message and read another message that may have come on at the same time, press the RESET button. BRAKE BEFORE SHiFT (See “Automatic Transmissions Only”...
Page 175: Audio System(S)
Audio System(s) Notice; Before you add any sound equipment to your vehicle like a tape player, CB radio, mobile telephone or two-way radio be sure you can add what you want. If you can, it’s very important to do it properly. Added sound equipment may interfere with the operation of your vehicle’s engine, Delphi Electronics radio or other systems, and even damage them.
Page 176 Radio with Cassette Your vehicie is equipped with six Base@ amplified speakers. See your dealer for details. Playing the Radio PWR (Power): Press this knob to turn the system on and off. VOL (Volume): Turn the knob to increase or to decrease volume.
Page 177 The radio will seek or scan only to stations that are in the selected band and only to those with a strong signal. Scan): PSCAN (Preset Press this button to listen to each of your favorite stations stored on the pushbuttons for a few seconds.
Page 178 Adjusting the Speakers (BallanceIFade) BAL (Balance): To adjust the balance between the right and the left speakers, press this knob lightly so it extends. Turn the knob to move the sound toward the right or the left speakers. FADE: To adjust the fade between the front and the rear speakers, press this knob lightly so it extends.
Page 179 4 REV (Reverse): Press this pushbutton to reverse the tape rapidly. Press it again to return to playing speed. The radio will play while the tape reverses. 5 (Dolby): Press this pushbutton to reduce background noise. The double-D symbol will appear on the display.
Page 180 Radio with CD Your vehicle is equipped with six 5ose@ amplified speakers. See your dealer for details. Playing the Radio PWR (Power): Press this knob to turn the system on and off. .._- I,--h I . , . 5 I A D 1 \ 1 - 1 _ _ - _ &I^- V U L...
Page 181 P.SCAN (Preset Scan): Press this button to listen to each of your favorite stations stored on the pushbuttons for a few seconds. The AUTO TONE setting stored for that pushbutton will be automatically chosen. PSCAN will appear on the display. Press P.SCAN again or one of the pushbuttons to stop scanning presets.
Page 182 Adjusting the Speakers (Balance/Fade) BAL (Balance): To adjust the balance between the right and the left speakers, press this knob lightly so it extends. Turn the knob to move the sound toward the right or the left speakers. FADE: To adjust the fade between the front and the rear speakers, press this knob lightly so it extends.
Page 183 AM FM: Press this button listen to the radio when a CD is playing. CD AUX (Auxiliary): Press this button to play a CD when listening to the radio. CD will appear on the display when a disc is in the player, whether it is active or not.
Page 184 You must first load the magazine with discs before you can play a compact disc. Each of the 12 trays holds one disc. Press the button on the back of the magazine and pull gently on one of the trays. Load the trays from bottom to top, placing a disc on the tray label side disc si&...
Page 185 Close the door by sliding it all the way to the left. If the door is left partially open, the changer will not operate and an error will occur. When the door is closed, the changer will begin checking for discs in the magazine.
Page 186 3 NEXT: Press this pushbutton to advance to the next track. If you press and hold this pushbutton or press it more than once, the player will continue moving forward through the disc. (Reverse): Press and hold this pushbutton to quickly reverse within a track.
Page 187 NEXT: Press this pushbutton to advance to the next track. If you press and hold this pushbutton or press it more than once, the player will continue moving forward through the disc. REV 4 (Reverse): Press and hold this pushbutton to quickly reverse within a track.
Page 188 Theft-Deterrent Feature THEFTLOCK@ is designed to discourage theft of your radio. It works by using a secret code to disable all radio functions whenever battery power is interrupted. The THEFTLOCK feature for the radio may be used or ignored. If ignored, the system plays normally and the radio is not protected by the feature.
Page 189 Unlocking the Theft-Deterrent Feature After a Power Loss Enter your secret code as follows; pause no more than 15 seconds between steps: 1. Turn the ignition on. LOC will appear on the display. 2. Press MN and 000 will appear on the display. 3.
Page 190 The range for most AM stations is greater than for FM, especially at night. The longer range, however, can cause stations to interfere with each other. AM can pick up noise from things like storms and power lines. Try reducing the treble to reduce this noise if you ever get it. FM stereo will give you the best sound, but FM signals will reach only about 10 to 40 miles (16 to 65 km).
Page 191 The cut tape detection feature of your cassette tape player may identify the cleaning cassette as a damaged tape, in error. To prevent the cleaning cassette from being ejected, use the following steps: 1. Turn the ignition on. 2. Turn the radio off. 3.
Page 192 Power Antenna Mast Care (Convertible) Your power antenna will look its best and work well if it’s cleaned from time to time. To clean the antenna mast do the following: 1. Turn on the ignition and radio to raise the antenna. 2.
Page 193 NOTES 3-80...
Page 194: Driving Your Vehicle
Section 4 Your Driving. the Road. and Your Defensive Driving ... Drunken Driving ... Control of a Vehicle ... Braking ... Traction Control System (TCS) ... Active Handling System ... Limited-Slip Rear Axle Selective Ride Control Steering Off-Road Recovery Passing Loss Control Driving at Night...
Page 195: Your Driving, The Road, And Your Vehicle
Your Driving, the Road, and Your Vehicle Defensive Driving The best advice anyone can give about driving is: Drive defensively. Please start with a very important safety device in your vehicle: Buckle up. See Safety Belts: They Are for Everyone on page 1-7. Defensive driving really means “be ready for anything.”...
Page 196 Many adults by some estimates, nearly half the adult population choose never to drink alcohol, so they never drive after drinking. For persons under 21, it’s against the law in every U.S. state to drink alcohol. There are good medical, psychological and developmental reasons for these laws.
Page 197 There is a gender difference, too. Women generally have a lower relative percentage of body water than men. Since alcohol is carried in body water, this means that a woman generally will reach a higher BAC level than a man of her same body weight when each has the same number of drinks.
Page 198: Control Of A Vehicle
Drinking and then driving is very dangerous. Your reflexes, perceptions, attentiveness and judgement can be affected by even a small amount of alcohol. You can have a serious-or even fatal-collision if you drive after drinking. Please don’t drink and drive or ride with a driver who has been drinking.
Page 199: Braking
Braking Braking action involves perception time and reaction time. First, you have to decide to push on the brake pedal. That’s perception time. Then you have to bring up your foot and do it. That’s reaction time. Average reaction time is about 3/4 of a second. But that’s only an average.
Page 200 Anti-lock Brake System (ABS) Your vehicle has anti-lock brakes. ABS is an advanced electronic braking system that will help prevent a braking skid. When you start your engine and begin to drive away, your anti-lock brake system will check itself. You may hear a momentary motor or clicking noise while this test is going on, and you may even notice that your brake pedal moves a little.
Page 201 The anti-lock system can change the brake pressure faster than any driver could. The computer is programmed to make the most of available tire and road conditions. This can help you steer around the obstacle while braking hard. As you brake, your computer keeps receiving updates on wheel speed and controls braking pressure accordingly.
Page 202: Traction Control System (Tcs)
Traction Control System (TCS) Your vehicle has a traction control system called TCS that limits wheel spin. This is especially useful in slippery road conditions. The system operates only if it senses that the rear wheels are spinning too much or are beginning to lose traction.
Page 203: Active Handling System
To turn the system off, press the button located on the console. You can turn the system on or off at any time by pressing the ACTIVE HANDLING button. The DIC will display the appropriate message when you push the button. Active Handling System The Active Handling System is a computer controlled system that helps the driver maintain directional control...
Page 204: Limited-Slip Rear Axle
The Active Handling System comes on automatically whenever you start your vehicle. To help maintain directional control of the vehicle, you should always leave the system on. You can turn the system off if you ever need to. If you turn the Active Handling System off, the Traction Control System will also be turned off.
Page 205: Selective Ride Control
Selective Ride Control You may have a ride control system on your vehicle called Selective Ride Control. The system provides the following performance benefits: Reduced Impact Harshness Improved Road Isolation Improved High-speed Stability Improved Handling Response Better Control of Body Ride Motions 4-1 2 This knob is located on the center console.
Page 206: Steering
Steering Power Steering If you lose power steering assist because the engine stops or the system is not functioning, you can steer but it will take much more effort. Magnetic Speed Variable Assist Steering Your vehicle is equipped with a steering system that continuously adjusts the effort you feel when steering at all vehicle speeds.
Page 207 Steering in Emergencies There are times when steering can be more effective than braking. For example, you come over a hill and find a truck stopped in your lane, or a car suddenly pulls out from nowhere, or a child darts out from between parked cars and stops right in front of you.
Page 208: Off-Road Recovery
Off-Road Recovery You may find that your right wheels have dropped off the edge of a road onto the shoulder while you’re driving. If the level of the shoulder is only slightly below the pavement, recovery should be fairly easy. Ease off the accelerator and then, if there is nothing in the way, steer so that your vehicle straddles the edge of the pavement.
Page 209 Watch for traffic signs, pavement markings and lines. If you can see a sign up ahead that might indicate a turn or an intersection, delay your pass. A broken center line usually indicates it’s all right to pass (providing the road ahead is clear). Never cross a solid line on your side of the lane or a double solid line, even if the road seems empty of approaching traffic.
Page 210: Loss Of Control
Loss of Control Let’s review what driving experts say about what happens when the three control systems (brakes, steering and acceleration) don’t have enough friction where the tires meet the road to do what the driver has asked. In any emergency, don’t give up. Keep trying to steer and constantly seek an escape route or area of less danger.
Page 211: Driving At Night
Driving at Night I : . Night driving is more dangerous than day driving. One reason is that some drivers are likely to be impaired by alcohol or drugs, with night vision problems, or by fatigue. Here are some tips on night driving. Drive defensively.
Page 212: Driving In Rain And On Wet Roads
You can be temporarily blinded by approaching headlamps. It can take a second or two, or even several seconds, for your eyes to readjust to the dark. When you are faced with severe glare (as from a driver who doesn’t lower the high beams, or a vehicle with misaimed headlamps), slow down a little.
Page 213 The heavier the rain, the harder it is to see. Even if your windshield wiper blades are in good shape, a heavy rain can make it harder to see road signs and traffic signals, pavement markings, the edge of the road and even people walking.
Page 214 Hydroplaning Hydroplaning is dangerous. So much water can build up under your tires that they can actually ride on the water. This can happen if the road is wet enough and you’re going fast enough. When your vehicle is hydroplaning, it has little or no contact with the road. Hydroplaning doesn’t happen often.
Page 215: City Driving
City Driving One of the biggest problems with city streets is the amount of traffic on them. You’ll want to watch out for what the other drivers are doing and pay attention to traffic signals. 4-22 Here are ways to increase your safety in city driving: Know the best way to get to where you are going.
Page 216: Freeway Driving
Freeway Driving Mile for mile, freeways (also called thruways, parkways, expressways, turnplKes or supernignwaysj are ine safest of all roads. But they have their own special rules. The most important advice on freeway driving is: Keep up with traffic and keep to the right. Drive at the same speed most of the other drivers are driving.
Page 217: Before Leaving On A Long Trip
Once you are moving on the freeway, make certain you allow a reasonable following distance. Expect to move slightly slower at night. When you want to leave the freeway, move to the proper lane well in advance. If you miss your exit, do not, under any circumstances, stop and back up.
Page 218: Highway Hypnosis
Highway Hypnosis Is there actually such a condition as “highway hypnosis”? Or is it just plain falling asleep at the wheel? Call it highway hypnosis, lack of awareness, or whatever. There is something about an easy stretch of road with the same scenery, along with the hum of the tires on the road, the drone of the engine, and the rush of the wind against the vehicle that can make you sleepy.
Page 219 If you drive regularly in steep country, or if you’re planning to visit there, here are some tips that can make your trips safer and more enjoyable. Keep your vehicle in good shape. Check all fluid levels and also the brakes, tires, cooling system and transmission.
Page 220: Winter Driving
Stay in your own lane when driving on two-lane roads in hills or mountains. Don't swing wide or cut across the center of the road. Drive at speeds that let you stay in your own lane. As vou ao over the top of a hill, be alert. There could be something in your lane, like a stalled car or an accident.
Page 221 Include an ice scraper, a small brush or broom, a supply of windshield washer fluid, a rag, some winter outer clothing, a small shovel, a flashlight, a red cloth and a couple of reflective warning triangles. And, if you will be driving under severe conditions, include a small bag of sand, a piece of old carpet or a couple of burlap bags to help provide traction.
Page 222 What’s the worst time for this? “Wet ice.” Very cold snow or ice can be slick and hard to drive on. But wet ice can be even more trouble because it may offer the least traction of all. You can get wet ice when it’s about freezing (32°F;...
Page 223 If You're Caught in a Blizzard If you are stopped by heavy snow, you could be in a serious situation. You should probably stay with your vehicle unless you know for sure that you are near help and you can hike through the snow. Here are some things to do to summon help and keep yourself and your passengers safe: Turn on your hazard flashers.
Page 224 Snow can trap exhaust gases under your vehicle. This can cause deadly CO (carbon monoxide) gas to get inside. CO could overcome you and kill you. You can’t see it or smell it, so you might not know it is in your vehicle.
Page 225: If You Are Stuck: In Sand, Mud, Ice Or Snow
If You Are Stuck: In Sand, Mud, Ice or Snow In order to free your vehicle when it is stuck, you will need to spin the wheels, but you don’t want to spin your wheels too fast. The method known as “rocking” can help you get out when you’re stuck, but you must use caution.
Page 226: Towing
Towing Towing Your Vehicle Consult your dealer or a professional towing service if you need to have your disabled vehicle towed. See Roadside Assistance Program on page 7-5. Recreational Vehicle Towing Recreational vehicle towing means towing your vehicle behind another vehicle such as behind a motorhome.
Page 227 MFD BY GENERAL MOTORS CORP The other label is the Certification label, found on the rear edge of the driver’s door. It tells you the gross weight capacity of your vehicle, called the Gross Vehicle Weight Rating (GVWR). The GVWR includes the weight of the vehicle, all occupants, fuel and cargo.
Page 228: Towing A Trailer
If you put things inside your vehicle tools, packages or anything else the vehicle goes. If you have to stop or turn quickly, there is a crash, they’ll keeF --ling. *‘ Things you put inside ur vehicle can strike and injure people in a sudden stop or turn, or in a crash.
Page 230: Service And Appearance Care
Section 5 Service Doing Your Own Service Work Adding Equipment to the Outside of Your Vehicle Fuel ... 5. 5 Gasoline Octane Gasoline Specifications ... 5.5 California Fuel Additives Fuels in Foreign Countries ... 5. 6 Filling Your Tank Filling a Portable Fuel Container Checking Things Under the Hood Hood Release ...
Page 231 Section 5 Wheel Alignment and Tire Balance ... 5-61 Wheel Replacement ... Tire Chains Lifting Your Corvette ... If a Tire Goes Flat ... Tire Inflator Kit (Z06 Only) Appearance Care Cleaning the Inside of Your Vehicle ... 5-75 Care Safety Belts ...
Page 232: Service
Service We hope you'll want to keep your GM vehicle all GM. Genuine GM parts have one of these marks: Your dealer knows your vehicle best and wants you to be happy with it. We hope you'll go to your dealer for all your service needs.
Page 233: Doing Your Own Service Work
Doing Your Own Service Work If you want to do some of your own service work, you’ll want to use the proper service manual. It tells you much more about how to service your vehicle than this manual can. To order the proper service manual, see Service Publications Ordering Information on page 7-10.
Page 234: Fuel
Fuel Use of the recommended fuel is an important part of the proper maintenance of your vehicle. Gasoline Octane Use premium unleaded gasoline with a posted octane of 91 or higher for best performance. You may also use middle grade or regular unleaded gasoline rated at 87 octane or higher, but your vehicle’s acceleration may be slightly reduced.
Page 235: California Fuel
California Fuel If your vehicle is certified to meet California Emission Standards (see the underhood emission control label), it is designed to operate on fuels that meet California specifications. If this fuel is not available in states adopting California emissions standards, your vehicle will operate satisfactorily on fuels meeting federal specifications, but emission control system performance may be affected.
Page 236: Filling Your Tank
Filling Your Tank Fuel vapor is higllly flammable. violently, and that can cause very bad injuries. Don't smoke if you're near fuel or refueling your vehicle. Keep sparks, flames and smoking materials away from fuel. burns The fuel filler door is located on the driver's side of the vehicle.
Page 237 The fuel filler door release button is located inside of the center console storage Compartment. If your fuel filler door release won’t operate, there is a manual release tab. The tab is located against the upper trim on the driver’s side in the rear compartment. Pull the tab to manually release the fuel filler door.
Page 238: Filling A Portable Fuel Container
If you get fuel on yourself and then something ignites it, you could be badly burned. Fuel can spray out on you if you open the duel cap too quickly. This spray can happen if your tank is nearly full, and is more likely in hot weather. Open the fuel cap slowly and wait for any “hiss”...
Page 239: Checking Things Under The Hood
Checking Things Under the Hood An electric fan under the hood can start up and injure you even when the engine is not running. Keep hands, clothing and tools away from any underhood electric fan. 5-1 0 Things that burn can get on hot engine parts and start a fire.
Page 240: Hood Release
Hood Release Notice: In order to avoid possible contact hood to the headlamp doors, either take care in raising the hood with the headlamps up, or turn off the headlamps prior to opening the hood. To open the hood, do the following: 1.
Page 242: Engine Oil
A. Coolant Surge Tank and Pressure Cap B. Battery C. Engine Oil Dipstick D. Engine Oil Fill Cap E. Engine Air Cleaner/Filter F. Power Steering Fluid Reservoir G. Brake Fluid Reservoir H. Clutch Master Cylinder Reservoir I. Windshield Washer Fluid Reservoir Engine Oil If the LOW OIL LEVEL message on the Driver Information Center comes on, it means you need to...
Page 243 When to Add Engine Oil If the oil is at or below the cross-hatched area at the tip of the dipstick, you’ll need to add at least one quart of oil. But you must use the right kind. This part explains what kind of oil to use.
Page 244 LOOK T H I S WEATHER SYMBOL SAE IOW-30 ACCEPTABLE IF 5W-30 I S NOT AVAILABLE SAE 5W. I W J RECOMMENDED COLD WEATHER DO NOT USE SAE 1OW-40, SA€ V!SCOS!rv GRADE O!L NOT RECOMMENDED SAE 5W-30 As shown in the viscosity chart, SAE 5W-30 is best for your vehicle.
Page 245 Substitute Engine Oil: When adding oil to maintain engine oil level, oil meeting GM Standard GM4718M may not be available. You can add substitute oil designated SAE 5W-30 with the starburst symbol at all temperatures. If temperatures are above 0°F (-1 8"C), you may substitute SAE 1OW-30 with the starburst symbol.
Page 246 How to Reset the Change Oil Soon Message The GM Oil Life SystemTM calculates when to change your engine oil and filter based on vehicle use. Anytime your oil is changed, reset the system so it can calculate when the next oil change is required. If a situation occurs where you change your oil prior to a CHANGE OIL SOON message being turned on, reset the system.
Page 247: Engine Air Cleaner/Filter
Engine Air Cleaner/Filter The engine air cleaner/filter is located at the center front of the engine compartment. See Engine Compartment Overview on page 5-12 for more information on location. Refer to Scheduled Maintenance on page 6-4 to determine when to replace the air filter. Operating the engine with the air cleaner/filter off can cause you or others to be burned.
Page 248 Engine Air Cleaner/Filter Replacement To remove the engine air cleaner/filter: 1. Pull up on the clips on each side to release the assembly. 2. Pull the assembly out. 3. Replace the filter. See Normal Maintenance Replacement Parts on page 5-94. 4.
Page 249: Automatic Transmission Fluid
Automatic Transmission Fluid How to Check It is not necessary to check the transmission fluid level. A transmission fluid leak is the only reason for fluid loss. If a leak occurs, take the vehicle to your dealer service department and have it repaired as soon as possible.
Page 250 How to Check Because this operation can be difficult, you may choose to have this done at your dealership service department. If you do it yourself, be sure to follow all the instructions here, or you could get a false reading. Notice: Too much or too little fluid can damage your transmission.
Page 251: Hydraulic Clutch
How to Add Fluid Here’s how to add fluid. Refer to the Maintenance Schedule to determine what kind of fluid to use. See Part D: Recommended Fluids and Lubricants on page 6- 13. 1. Remove the filler plug. 2. Add fluid at the filler plug hole. Add only enough fluid to bring the fluid level up to the bottom of the filler plug hole.
Page 252: Engine Coolant
How to Check and Add Fluid Fluid should be added if the fluid level is below the step on the inside of the reservoir. There are additional instructions on the reservoir cap. Put the rubber seal ana cap back on. See Engine Zomparimeni Zlverview on page 5-12 for more information on location.
Page 253 Notice: When adding coolant, it is important that you use only DEX-COOL@ (silicate-free) coolant. If coolant other than DEX-COOL@ is added to the system, premature engine, heater core or radiator corrosion may result. In addition, the engine coolant will require change sooner (50,000 km) or 24 months, whichever occurs first.
Page 254 Checking Coolant The coolant surge tank is located in the engine compartment behind the passenger's side headlamp. See Engine Compartment Overview on page 5-12 for more intormation on locatlon. Turning the surge tank pressure cap when the engine and radiator are hot can allow steam and scalding liquids to blow out and burn you badly.
Page 255: Coolant Surge Tank Pressure Cap
Adding Coolant If you need more coolant, add the proper DEX-COOL@ coolant mixture at the surge tank, but only when the engine is cool. You can bc urned you engine parts. Coolant contains ethylene glycol, and it will burn if the engine parts are hot enough.
Page 256 If Steam Is Coming From Your Engine Steam from an ove eated engine can b . . . you badly, even if you just open the hood. Stay away from the engine if you see or hear steam coming from it. dust turn it off and get everyone away from the vehicle until it cools down.
Page 257 If No Steam Is Coming From Your Engine If you get an engine overheat warning but see or hear no steam, the problem may not be too serious. Sometimes the engine can get a little too hot when you: Climb a long hill on a hot day. Stop after high-speed driving.
Page 258: Cooling System
Cooling System When you decide it’s safe to lift the hood, here’s what you’ll see: A. Electric Engine Cooling Fans B. Coolant Surge Tank An elec :tric engine cooling fan unde N r tne nood can start up even when the engine is not running and can injure you.
Page 259 The coolant level should be at or above the FULL COLD mark. If it isn’t, you may have a leak at the pressure cap or in the radiator hoses, heater hoses, radiator, water pump or somewhere else in the cooling system.
Page 260 Notice: When adding coolant, you use only DEX-COOL~ (silicate-free) coolant. If coolant other than DEX-COOL is added to the system, premature engine, heater core or radiator corrosion may result. In addition, the engine coolant will require change sooner (50 000 km) or 24 months, whichever occurs first. Damage caused by the use of coolant other than DEX-COOL@ is not covered by your new vehicle warranty.
Page 261 Adding only plai Mater to system can be dangerous. Plain water, or some other liquid such as alcohol, can boil before the proper coolant mixture will. CAUTION: (Continued) 5-32 Your vehicle's coolant warning system is set for the proper coolant mixture. With plain water or the wrong mixture, your engine could get too hot but you wouldn't get the overheat warning.
Page 262 1. Park the vehicle on a level surface. You can remove the coolant surge tank pressure cap when the cooling system, including the coolant surge tank pressure cap and upper radiator hose, is no longer hot. Turn the pressure cap slowly counterclockwise about one-quarter turn and then stop.
Page 263 4. With the coolant surge tank pressure cap off, start the engine and let it run until you can feel the upper radiator hose getting hot. Watch out for the engine cooling fan(s). By this time, the coolant level inside the coolant surge tank may be lower.
Page 264: Power Steering Fluid
Power Steering Fluid When to Check Power Steering Fluid It is not necessary to regularly check power steering fluid unless you suspect there is a leak in the system or you hear an unusual noise. A fluid could indicate a problem. Have the system inspected and repaired.
Page 265: Windshield Washer Fluid
Windshield Washer Fluid What to Use When you need windshield washer fluid, be sure to read the manufacturer’s instructions before use. If you will be operating your vehicle in an area where the temperature may fall below freezing, use a fluid that has sufficient protection against freezing.
Page 266: Brakes
Brakes Brake Fluid Your brake master cylinder reservoir is on the driver’s side of the engine compartment. It is filled with UWT-3 brake iiuia. See Engine Gompanmenr zlverview on page 5- 12. There are only two reasons why the brake fluid level in the reservoir might go down.
Page 267 Checking Brake Fluid You can check the brake fluid without taking off the cap. Just look at the brake fluid reservoir. The fluid level should be above the MIN mark on the reservoir. If it isn’t, have your brake system checked to see if there is a leak.
Page 268 Brake Wear Your vehicle has four-wheel disc brakes. Disc brake pads have built-in wear indicators that make a high-pitched warning sound when the brake pads are worn and new pads are needed. The sound may come and go or be heard all the time your vehicle is moving (except when you are pushing on the brake pedal firmly).
Page 269: Battery
Replacing Brake System Parts The braking system on a vehicle is complex. Its many parts have to be of top quality and work well together if the vehicle is to have really good braking. Your vehicle was designed and tested with top-quality GM brake parts.
Page 270: Jump Starting
Jump Starting If your battery has run down, you may want to use another vehicle and some jumper cables to start your vehicle. Be sure to fo” the steps below to do it safely. I L t e r i e s ca.. you.
Page 271 4. Open the hoods and locate the batteries. Find the positive (+) and negative (-) terminal locations on each vehicle. See Engine Compartment Overview on page 5-12 for more information on location. elect. fan can s t , . up even when the engine is not running and can injure you.
Page 272 5. Check that the jumper cables don’t have loose or missing insulation. If they do, you could get a shock. The vehicles could be damaged, too. Before you connect the cables, here are some basic things you should know. Positive (+) will go to positive (+) or to a remote positive (+) terminal if the vehicle has one.
Page 273 7. Don’t let the other end touch metal. Connect it to the positive (+) terminal of the good battery. Use a remote positive (+) terminal if the vehicle has one. Now connect the black negative (-) cable to the negative (-) terminal of the good battery.
Page 274 Try to start the vehicle that had the dead battery. If it won’t start after a few tries, it probably needs service. Nofice: Damage to your vehicle may result from electrical shorting if jumper cables are removed incorrectly. To prevent electrical shorting, take care that the cables don’t touch each other or any other metal.
Page 275: Rear Axle
Rear Axle When to Check Lubricant Refer to the Maintenance Schedule to determine how often to check the lubricant. See Part C: Periodic Maintenance Inspections on page 6- 1 1. How to Check Lubricant 5-46 To get an accurate reading, the vehicle should be on a level surface.
Page 276: Bulb Replacement
Bulb Replacement For the proper type of replacement bulb, see Bulb Replacement on page 5-47. For any bulb changing procedure not listed in this section, contact your dealer’s service department. Halogen Bulbs Halogen bulbs have pressurized gas inside and can burst if you drop or scratch the bulb. You or others could be injured.
Page 277 2. Remove the screws on each side of the headlamp bezel. 3. Open the hood. 4. To remove the bezel, pull the sides slightly outward and tilt the bezel forward. Pull the clip centered above the lens outward. Be careful not to scratch the paint on the vehicle.
Page 278: Taillamps And Turn Signal Lamps
Taillamps and Turn Signal Lamps A. Back-up Lamp B. Inboard Taillamp C. Outboard Taillamp 1. Remove the screws. Pull the taillamp housing assembly out. 5-49...
Page 279 3. To remove the socket with the bulb, squeeze the 4. Remove the bulb from the socket. tab while you turn the socket counterclockwise. 5. Reverse the steps listed previously with a new bulb. 5-50...
Page 280: Back-Up Lamps
Back-up Lamps You can access the back-up lamps through the inboard taillamp opening. See Taillamps and Turn Signal Lamps on page 5-49. 1. Squeeze the tab on the socket while turning it counterclockwise to remove it from the assembly. 2. Remove the bulb from the socket. 3.
Page 281: Windshield Wiper Blade Replacement
Windshield Wiper Blade Replacement Windshield wiper blades should be inspected at least twice a year for wear or cracking. See “Wiper Blade Check under Part Owner Checks and Services on page 6-7 for more information. Replacement blades come in different types and are removed in different ways.
Page 282 To install the new wiper insert: 1. Slide the insert (D), notched end last, into the end with the two blade claws (A). Slide the insert all the way through the blade claws at the opposite end (B). Plastic caps (C) will be forced off as the :.---.A 1.
Page 283: Tires
Tires Your new vehicle comes with high-quality tires made by a leading tire manufacturer. If you ever have questions about your tire warranty and where to obtain service, see your Ct- rolet V ’ rranty booklet for details. Poorly maintained and improperly used tires are dangerous.
Page 284 The tire can operate effectively with no air pressure for up to 200 miles (320 km) at speeds up to 55 mph (90 km/h), but the tire would then have to be replaced. When a tire is filled with air, it provides a cushion between the road and the wheel.
Page 285: Inflation
If you feel that winter tires are needed for your driving conditions, Goodyear Eagle M+S EMT tires are available in your original equipment sizes from an authorized Goodyear EMT retailer. These tires will improve snow traction while maintaining your vehicle’s extended mobility feature.
Page 286: Tire Pressure Monitor System (Except Z06)
If the display doesn’t show tire pressure, or if the SERVICE TIRE MON SYS message appears see your dealer for service. For more information, see Tire Pressure Monitor System (Except Z06) on page 5-57 and Driver Information Center (DIC) on page 3-44. Tire Pressure Monitor System (Except Z06)
Page 287: Tire Rotation
If a tire pressure message appears on the Driver Information Center, stop as soon as you can. Have the tire pressures checked and set to those shown on your Tire-Loading Information label. See inflation -- Tire Pressure on page 5-56. en th .OW TIRE PRESSURE or FLAT TIRE message is displayed on the Driver Information...
Page 288: Buying New Tires
Buying New Tires To find out what kind and size of tires you need, look at the Tire-Loading Information label. The tires installed on your vehicle when it was new had a Tire Performance Criteria Specification (TPC Spec) number on each tire’s sidewall. When you get new tires, get ones with that same TPC Spec number.
Page 289: Uniform Tire Quality Grading
Uniform Tire Quality Grading Quality grades can be found where applicable on the tire sidewall between tread shoulder and maximum section width. For example: Treadwear 200 Traction AA Temperature A The following information relates to the system developed by the United States National Highway Traffic Safety Administration, which grades tires by treadwear, traction and temperature performance.
Page 290: Wheel Alignment And Tire Balance
A, B, C Temperature The temperature grades are A (the highest), B, and C, representing the tire’s resistance to the generation of heat and its ability to dissipate heat when tested under controlled conditions on a specified indoor laboratory test wheel. Sustained high temperature can cause the material of the tire to degenerate and reduce tire life, and excessive temperature can lead to sudden tire failure.
Page 291 If you need to replace any of your wheels, wheel bolts or wheel nuts, replace them only with new GM original equipment parts. This way, you will be sure to have the right wheel, wheel bolts and wheel nuts for your vehicle. Using the wrong re1 cement wheels, wheel bolts or wheel nuts on your vehicle can be dangerous.
Page 292 Incorrect wheel nuts or improperly llyhtened wheel nuts can cause the wheel to become loose and even come off. This could lead to a crash. Be sure to use the correct wheel nuts. If you have to replace them, be sure to get new GM original equipment wheel nuts.
Page 293: Tire Chains
Tire Chains Don’t use tire Therc . , . . I S . clearance. Tire chains used on a vehicle without the proper amount of clearance can cause damage to the brakes, suspension or other vehicle parts. The area damaged by the tire chains could cause you to lose control of your vehicle and you or others may be injured in a crash.
Page 294 Make sure the jack you’re using spans at least two crossmem ber ribs. Lift only in the areas shown in the following pictures. For additional information, see your dealer and the Chevrolet Corvette service manual. 5-65...
Page 295 Lifting From the Front The front lifting point can be accessed for either the driver’s or passenger’s side of the vehicle, behind the front tires. 5-66 Locate the lifting point (B) on either side of your vehicle to jack the vehicle according to the illustration shown.
Page 296 Lifting From Rear The rear lifting point can be accessed from the rear of the vehicle, on either the driver’s or passenger’s side. 1. Locate the lifting point to jack your vehicle according to the illustration shown. 2. Be sure to place a block or pad between the jack and the vehicle.
Page 297: If A Tire Goes Flat
(80 km) or less and at speeds of 55 mph (90 km/h) or less, there is a good chance that the tire can be repaired. Contact the nearest authorized Chevrolet or Goodyear EMT servicing facility, as soon as possible, to have the flat tire inspected and repaired or replaced.
Page 298 Z06 models do not have Extended Mobility Tires. If a Z06 model tire goes flat, avoid further tire and wheel damage by driving slowly to a level place and stopping. Then do this: 1. Turn on the hazard warning flashers. 2.
Page 299: Tire Inflator Kit (Z06 Only)
Tire Inflator Kit (Z06 Only) Every Z06 model with P295/35ZR18 and P265/402Rl7 tires, when new, was equipped with a tire inflator kit. The repair kit contains a detailed instruction card that outlines step by step the temporary repair procedure. Be sure to read and follow all the tire inflator kit instructions.
Page 300 Tire Sealant The kit contains a liquid sealant that when injected into a flat tire, may temporarily repair nail holes or cuts in the tread area of the tire. The tire sealant cannot repair tire damage caused while driving on a flat tire or a tire that has had a “blow out”...
Page 301 It can be dangerous to get out of your vehicle with the engine running, if the shift lever is not in NEUTRAL (N) with the parking brake firmly set (manual transmission). Your vehicle can roll or move suddenly even when on fairly level ground.
Page 302 The maximum speed label reminds you to drive cautiously and not to exceed 55 mph (90 km/h) until you have the damaged tire inspected and repaired. Repairheplace tire. Reparer ou remplacer pneu. Repararlsustituir el neumatico. Place the air compressor pump and accessories into the inflator kit case and store in the hatchhrunk compartment area of your vehicle.
Page 303 To Stow the Tire Inflatnr Kit: Stc,,,lg the tire inflator kit or other equipment in the passenger compartment of the vehicle could cause injury. In a sudden stop or collision, loose equipment could strike someone. Store the tire inflator kit in the proper place. 5-74 1.
Page 304: Appearance Care
Appearance Care Remember, cleaning products can be hazardous. Some are toxic. Others can burst into flames if you strike a match or get them on a hot part of the vehicle. Some are dangerous if you breathe their fumes in a closed space.
Page 305 Here are some cleaning tips: Always read the instructions on the cleaner label. Clean up stains as soon as you can they set. Carefully scrape off any excess stain. Use a clean cloth or sponge, and change to a clean area often.
Page 306: Care Of Safety Belts
Interior Plastic Components Use only a mild Soap and water solution on a soft cloth or sponge. Commercial cleaners may affect the surface finish. Security Shade and Convenience Net Wash with warm water and mild detergent, rinse with cold water and tumble dry on low. Do not use chlorine bleach.
Page 307: Cleaning The Outside Of Your Vehicle
Cleaning the Outside of Your Vehicle The paint finish on your vehicle provides beauty, depth of color, gloss retention and durability. Washing Your Vehicle The best way to preserve your vehicle’s finish is to keep it clean by washing it often with lukewarm or cold water. Don’t wash your vehicle in the direct rays of the sun.
Page 308 Exterior painted surfaces are subject to aging, weather and chemical fallout that can take their toll over a period of years. You can help to keep the paint finish looking new by keeping your vehicle garaged or covered whenever possible. Windshield and Wiper Blades If the windshield is not clear after using the windshield washer, or if the wiper blade chatters when running,...
Page 309 Convertible Top Your convertible top should be cleaned often. If you use an automatic car wash, use one with water jets and hanging cloths. High pressure car washes may cause water to enter your vehicle. When you hand wash the top, do it in partial shade. Use a mild soap, lukewarm water and a soft sponge.
Page 310: Finish Damage
Finish Damage Any stone chips, fractures or deep scratches in the finish should be repaired right away. Minor chips and scratches can be repaired with touch-up materials avaliable from your dealer or other service outlets. Larger areas of finish damage can be corrected in your dealer’s body and paint shop.
Page 311: Gm Vehicle Care/Appearance Materials
GM Vehicle Care/Appearance Materials See your GM dealer for more information on purchasing the following products. Vinyl Cleaner Removes dirt, grime, Glass Cleaner smoke and Removes dirt and grime Chrome and Wire Wheel from chrome wheels and Cleaner wire wheel covers. Removes dust, fingerprints, and surface Finish Enhancer...
Page 312: Vehicle Identification
Vehicle Identification Vehicle Identification Number (VlN) EI II 1111 I II 11111111 1111 111 111111 111 111111 I I 111111111111 SAMPLE4UX1 M072675 This is the legal identifier for your vehicle. It appears on a plate in the front corner of the instrument panel, on the driver’s side.
Page 313: Electrical System
Electrical System Add-on Electrical Equipment Notice: Don’t add anything electrical to your vehicle unless you check with your dealer first. Some electrical equipment can damage your vehicle and the damage wouldn’t be covered by your warranty. Some add-on electrical equipment can keep other components from working as they should.
Page 314: Headlamp Wiring
Notice: When using the accessory power plug: Do NOT splice wires directly into the vehicle electrical wire harness. If done incorrectly, spicing may cause damage to your electrical system and would not be covered by the vehicle’s warranty. The maximum load of any electrical equipment should not exceed 15 amps.
Page 315 Fuses and Circuit 5reakers The wiring circuits in your vehicle are protected from short circuits by a combination of maxi-fuses, mini-fuses and circuit breakers. This greatly reduces the chance of fires caused by electrical problems. Look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Page 316 Fuse Usage Console Cigarette Lighter Monitored (Inadvertent) Load Control Lumbar Seat Seat Control Module Driver Radio, Compact Parking Lamps, Disc Player Taillamps I System and Inside Rearview Bodv Control Module HVAC Controls " Ignition 2 5-87...
Page 317 ignition 1 Rear Defogger Starter Blank 5-88 Left Daytime Running Lamp Tonneau Release Courtesy Lamps Automatic Lamp Control Parking Automatic Lamp Control Headlamps Speakers Bose Defoaaer Rear ~ _ _ _ _ _ _...
Page 319 Anti-Lock Brakes, Selective Ride Fog Lamp Blank Headlamp Low-Beam Headlamp High-Beam Right Headlamp Low-Beam Horn Headlamp High-Beam Left Fuel Pumr, Cooling Fan Oxygen Sensor Powertrain Control Module Throttle Control lniector 2 Engine Ignition Blank Blank Injector 1 5-90 Riaht " Left Spare Ignition 3...
Page 320 Air Pump Air Conditioner and Clutch Fog Lamp Coolinq Fan 1 5-91...
Page 321: Capacities And Specifications
Capacities and Specifications The following approximate capacities are given in English and metric conversions. Please refer to Part Recommended Fluids and Lubricants on page Application Air Conditioning Refrigerant R134a Automatic Transmission Drain and Refill Overhaul Cooling System 11.9 Engine Oil with Filter Fuel Tank Manual Transmission (Overhaul) Wheel Nut Torque...
Page 322 VIN Code Engine Engine Horsepower L S 1 Automatic 5200 rpm Transmission 350605200 rpm Transmission ~~~~~ 6000 rpm Engine Specifications Transmission Manual Engine Data Torque @ 4000 rpm 375@4400 rpm 4800 rpm Spark Plug Gap Firing Order 1-8-7-2-6-5-4-3 1-8-7-2-6-5-4-3 0.060 inch (1.524 mm) Compression Ratio...
Page 323: Normal Maintenance Replacement Parts
Normal Maintenance Replacement Parts Normal Maintenance Replacement Parts Enqine Air CleanedFilter Engine Oil Filter PCV Valve Spark Plug Windshield Wiper Blade Length ACDelco@ part number. 5-94 Part Number A91 7C* PF44* CV948C* 41 -974* 22 inches (55.9 9 mm x 3 mm Shepherd’s Hook...
Page 324 Engine Accessory Drive Belt Routing 5-95...
Page 326 Section 6 Maintenance Schedule ... introduction ... Your Vehicle and the Environment ... Maintenance Requirements How This Section is Organized ... Part A: Scheduled Maintenance Services Using Your Maintenance Schedule ... Scheduled Maintenance ... Part B: Owner Checks and Services At Each Fuel Fill ...
Page 327: Maintenance Schedule
Maintenance Schedule Introduction IMPORTANT: KEEP ENGINE AT THE PROF LEVEL AND CHAluut RECOMMENDED .., Have you purchased the GM Protection Plan? The Plan supplements your new vehicle warranties. See your Warranty and Owner Assistance booklet or your dealer for details.
Page 328: How This Section Is Organized
How This Section is Organized This maintenance schedule is divided into five parts: “Part A: Scheduled Maintenance Services” explains what to have done and how often. Some of these services can be complex, so unless you are technically qualified and have the necessary equipment, you should let your dealer’s service department or another qualified service center do these jobs.
Page 329: Part A: Scheduled Maintenance Services
Part A: Scheduled Maintenance Services This part contains engine oil scheduled maintenance which explains the engine oil life system and how it indicates when to change the engine oil and filter. Also, listed are scheduled maintenance services which are to be performed at the mileage intervals specified. Using Your Maintenance Schedule We at General Motors want to keep your vehicle in good working condition.
Page 330 Footnotes The U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emissions warranty or limit recall liability prior to the completion of the vehicle's useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.
Page 331 50,000 Miles 000 km) Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions: In heavy city traffic where the outside temperature regularly reaches 90°F (32°C) or higher. In hilly or mountainous terrain. Uses such as high performance operation.
Page 332: Part B: Owner Checks And Services
Part B: Owner Checks and Services Listed in this part are owner checks and services which should be performed at the intervals specified to help ensure the safety, dependability and emission control performance of your vehicle. Be sure any necessary repairs are completed at once. Whenever any fluids or lubricants are added to your vehicle, make sure they are the proper ones, as shown in Part D.
Page 333: At Least Twice A Year
At Least Twice a Year Restraint System Check Make sure the safety belt reminder light and all your belts, buckles, latch plates, retractors and anchorages are working properly. Look for any other loose or damaged safety belt system parts. If you see anything that might keep a safety belt system from doing its job, have it repaired.
Page 334 Starter Switch Check en yo-. are dc ...g tl..- check, the vehicle could move suddenly. If it does, you or others could be injured. Follow the steps below. Before you start, be sure you have enough room around the vehicle. 2.
Page 335 Ignition Automatic Transmission Lock Check While parked, and with the parking brake set, try to turn the ignition key to OFF in each shift lever position. The key should turn to OFF only when the shift lever is in PARK (P). On all vehicles, the key should come out only in OFF.
Page 336: Part C: Periodic Maintenance Inspections
Part C: Periodic Maintenance Inspections Listed in this part are inspections and services which should be performed at least twice a year (for instance, each spring and fall). You should let your dealer’s service department or other qualified service center do these jobs.
Page 337: Fuel System Inspection
Fuel System Inspection Inspect the complete fuel system for damage or leaks. Engine Cooling System Inspection Inspect the hoses and have them replaced if they are cracked, swollen or deteriorated. Inspect all pipes, fittings and clamps; replace as needed. Clean the outside of the radiator and air conditioning condenser.
Page 338: Part D: Recommended Fluids And Lubricants
Part D: Recommended Fluids and Lubricants Fluids and lubricants identified below by name, part number or specification may be obtained from your dealer. Fluid/Lubricant Usaqe The engine requires a special engine oil meeting GM Standard GM4718M. Oils meeting this standard may be identified as synthetic, and should also be identified with the American Petroleum Institute Certified for...
Page 339 Fluid/Lubricant Mulit-Purpose Lubricant, Superlube Key Lock (GM Part No. U S . 12346241, in Cylinders Canada 10953474, or equivalent). SAE 75W-90 Synthetic Axle Lubricant (GM Part No. U.S. 12378261, in Canada 10953455, or equivalent) meeting GM Specification 99861 15. With a Rear Axle complete drain and refill add (Limited-Slip...
Page 340: Part E: Maintenance Record
Part E: Maintenance Record After the scheduled services are performed, record the date, odometer reading and who performed the service ana any additional information from “Owner Checks and Services” or “Periodic Maintenance” on the following record pages. Also, you should retain all maintenance receipts. Maintenance Record 6-1 5...
Page 341 Maintenance Record (cont’d) Odometer 6-1 6...
Page 342 Maintenance Record (cont’d) 6-1 7...
Page 343 Maintenance Record (cont’d)
Page 344 Customer Assistance Information Customer Satisfaction Procedure Customer Assistance for Text Telephone ( T Y ) Users Customer Assistance Off ices GM Mobility Program for Persons Disabilities Roadside Assistance Program Customer As Courtesy Transportation ... 7. 7 7 . 2 7. 2 Reporting Safety Defects to the United States Government Reporting Safety Defects to the Canadian...
Page 345: Customer Assistance Information
Information Customer Satisfaction Procedure Your satisfaction and goodwill are important to your dealer and to Chevrolet. Normally, any concerns with the sales transaction or the operation of your vehicle will be resolved by your dealer’s sales or service departments. Sometimes, however, despite the best intentions of all concerned, misunderstandings can occur.
Page 346 Customer Assistance for Text Telephone (TTY) Users To assist customers who are deaf, hard of hearing, or speech-impaired and who use Text Telephones (TTYs), Chevrolet has TTY equipment available at its Customer Assisiance Zenier. Arly u s e r with Chevrolet by dialing: 1 -800-833-CHEV (2438).
Page 347 Customer Assistance Chevrolet encourages customers to call the toll-free number for assistance. If a U.S. customer wishes to write to Chevrolet, the letter should be addressed to Chevrolet’s Customer Assistance Center. United States Chevrolet Motor Division Chevrolet Customer Assistance Center P.O.
Page 348: Gm Mobility Program For Persons With Disabilities
To enhance Chevrolet’s strong commitment to customer satisfaction, Chevrolet is excited to announce the establishment of the Chevrolet Roadside Assistance Center. As the owner of a 2003 Chevrolet, membership in Roadside Assistance is free. Roadside Assistance is available 24 hours a day, 365 days a year, by calling 1 -800-CHEV-USA (243-8872).
Page 349 Courtesy Transportation will be offered in conjunction with the coverage provided by the Bumper-to-Bumper New Vehicle Limited Warranty to eligible purchasers of 2003 Chevrolet passenger cars and light duty trucks. (See your selling dealer for details.) Courtesy Care is available to retail and retail lease...
Page 350: Courtesy Transportation
Transportation Options Warranty service can generally be completed while you wait. However, if you are unable to wait Chevrolet helps minimize your inconvenience by providing several transportation options. Depending on the circumstances,...
Page 351 Public Transportation or Fuel Reimbursement If your vehicle requires overnight warranty repairs, reimbursement up to $30 per day (five day maximum) may be available for the use of public transportation such as taxi or bus. In addition, should you arrange transportation through a friend or relative, reimbursement for reasonable fuel expenses up to $10 per day (five day maximum) may be available.
Page 352: Reporting Safety Defects To The United States Government
Please call us at 1-800-222-1020, or write: Chevrolet Motor Division Chevrolet Customer Assistance Center F.6. Eox 3 3 i u Detroit, MI 48232-51 70 In Canada, please call us at 1-800-263-3777 (English) or 1-800-263-7854 (French).
Page 353: Service Publications Ordering Information
Service Publications Ordering Information Service Manuals Service Manuals have the diagnosis and repair information on engines, transmission, axle, suspension, brakes, electrical, steering, body, etc. RETAIL SELL PRICE: $120.00 Service Bulletins Service Bulletins give technical service information needed to knowledgeably service General Motors cars and trucks.
Page 354 Accessory Power Outlets Accessory Power Plug ... Activating the Theft-Deterrent Feature ... 3-75 Active Handling System Active Handling System Light ... Adding Washer Fluid ... Additional Program Information ... Additives, Fuel ... Add-on Electrical Equipment ... Adjusting the Speakers (Balance/Fade) ... 3-65, 3-69 Air Bag Off Light Readiness Light ...
Page 355 Audio Systems (cont.) Setting the Time ... Theft-Deterrent Feature Trunk-Mounted CD Changer ... Understanding Radio Reception Automatic Transmission ... Fluid ... Operation Automatic Transmission Check Automatic Transmission Shift Lock Control System Check ... Battery Battery Replacement Battery Run-Down Protection Before Leaving on a Long Trip ...
Page 356 Check Engine Light Gages Warning Light Check Engine Light ... Checking Coolant Checking Engine Oil ... Checking Things Under the Hood ... Checking Your Restraint Systems ... Chemical Paint Spotting Child Restraints Child Restraint Systems ... Infants and Young Children Lower Anchorages and Top Tethers for Children (LATCH System) ...
Page 357 Customer Assistance Information (cont.) Reporting Safety Defects to General Motors ... 7-9 Reporting Safety Defects to the Canadian Government Reporting Safety Defects to the United States Government ... Roadside Assistance Program Service Publications Ordering Information Daytime Running Lamps Defensive Driving ... Defogging and Defrosting Disabling the Theft-Deterrent Feature Disarming the System ...
Page 358 Engine (cont.) Coolant Heater Coolant Temperature Gage Cooling System Inspection Engine Compartment Overview Exhaust ... 5-13 ... 3-41 Oil Pressure Gage Overheating ... 2-21 Starting Engine Accessory Drive Belt Routing ... Engine Air Cleaner/Filter Replacement Engine Compartment Fuse Block ... 6-7 Engine Coolant Level Check Engine Oil Additives ...
Page 359 Gage Check Gages Warning Light ... Engine Coolant Temperature Engine Oil Pressure Fuel ... Speedometer ... Tachometer ... Voltmeter Gage Gasoline Octane ... Specifications ... Glass Surfaces ... Glove Box ... GM Mobility Program for Persons with Disabilities ... Hatchnrunk Hatchnrunk Lid Release ...
Page 360 Ignition Automatic Transmission Check Lock Ignition Positions ... Infants and Young Children, Restraints ... Inflation -- Tire Pressure ... Inflator Kit, Tire ... Inspection Brake System ... Engine Cooling System Exhaust System Fuel System ... Part C Periodic Maintenance Steering and Suspension ... Tire and Wheel Installing the Roof Panel ...
Page 361 Light (cont.) Brake System Warning Check Gages Warning Malfunction Indicator ... Safety Belt Reminder ... Security TCS Warning Light ... Traction Control System (TCS) Warning Lighted Visor Vanity Mirrors Limited-Slip Rear Axle ... Loading Your Vehicle ... Lockout Protection ... Locks Door ...
Page 362 Mexico. Central America and Caribbean Countries (Except Puerto Rico and U S Islands) Mirrors Automatic Dimming Rearview Manual Rearview Mirror Outside Automatic Dimming Mirror ... 2-38 Outside Convex Mirror Outside Power Heated Mirrors ... Model Reference ... New Vehicle Break-In ... Normal Maintenance Replacement Parts ...
Page 363 PASS-Key@ ... Plan Ahead When Possible ... Playing a Cassette Tape Playing a Compact Disc ... Playing the Radio Power Accessory Outlets Antenna Mast Care ... Door Locks ... Electrical System ... Seat Steering Fluid Windows ... Power Antenna Service Power Steering ...
Page 364 Restraint System Check (cont.) Replacing Restraint System Parts After a Crash ... Restraint Systems Checking ... Replacing Parts ... Retained Accessory Power (RAP) Roadside Assistance Program ... Rocking Your Vehicle To Get It Out ... Panel Roof Installing the Roof Panel ... Removing the Roof Panel Storing the Roof Panel Running Your Engine While You Are Parked ...
Page 365 Skidding Some Other Rainy Weather Tips Specifications. Capacities Speedometer ... Sport Seat Starter Interlock Feature Starter Switch Check Starting Your Engine ... Steering ... Steering and Suspension Inspection ... 6-1 1 Steering in Emergencies ... Steering Tips Storage Areas Center Console Storage Area Convenience Net ...
Page 366 Towing (cont.) Your Vehicle ... Traction Active Handling System Control System (TCS) ... Control System Warning Light Limited-Slip Rear Axle Selective Ride Control Transmission Fluid. Automatic Fluid. Manual ... Transmission Operation, Automatic Transmission Operation, Manual Transportation Options TrunWHatch Turn and Lane-Change Signals Turn Signal/MuItifunction Lever Twilight Sentinel@ (Optional in United States, Standard...
Page 367 What to Do with Used Oil ... What to Use Wheels Alignment and Tire Balance Replacement ... When to Add Engine Oil ... When to Change Engine Oil (GM Oil Life SystemTM) ... When to Check When to Check and What to Use When to Check Lubricant When to Check Power Steering Fluid ...

Chevrolet 2003 Corvette Owner's Manual

Table of Contents

Section Seats and Restraint Systems

Section 2 Features and Controls

Section 3 Instrument Panel

Section 4 Driving Your Vehicle

Section 5 Service and Appearance Care

Section 6 Maintenance Schedul

Quick Links

Chapters

Related Manuals for Chevrolet 2003 Corvette

Summary of Contents for Chevrolet 2003 Corvette