Carbest 81238 User Instruction page 33

UK
81239
SAFETY DATA SHEET
Safety Data Sheet according to Directive 1907/2006/EC, Article 31, Annex II, and TRGS 220 (Germany)
Product name: LiFePO4 Battery 12V/200Ah
Date of issue: 30 March, 2020
Date of last revision:
- Short term limit values:
- Remarks::
8.3 Personal Protection:
The following protection measures apply, if ingredients of the battery are set free:
Respiratory protection:
Hand protection:
Eye protection:
Skin protection:
General protective measures:
Industrial hygiene:
SECTION 9: Physical and Chemical Properties
9.1 Appearance
Physical state: Solid.
Colour: Silver.
Odour: None.
Carbest LiFe PO4 Batterie | Battery 81238/81239
Exceeding factor X: Exposure may exceed the exposure
limit value by the factor X for not longer than 15 minutes. 4
measurements at intervals of 1 hour.
Exceeding factor =X=: Exposure must never exceed the
exposure limit value by more than the factor X (instantaneous
value).
(I): Category I: substances for which the exposure limit value
is based on local effects or sensitizing substances.
(II): Category II: substances effective by resorption.
H : Substances effective by resorption through skin
S = Sensitizing substance
Y, C (DFG): There is no teratogenic risk if the exposure limit value
and the BLV are maintained.
Use respiratory protection apparatus or ventilated breathing hood.
If contact with hands cannot be avoided use protection gloves tested
according to DIN EN 374. Seek advice from manufacturers of
protection gloves. If gloves cannot be used for safety reasons (e. g.
while working at rotating machines) use skin-protective barrier
cream. Consult the company medical officer for the type of barrier
cream to be used.
Comment: In contrary to the European ordinance 1907/2006/EC
(REACH), it is not sufficient to specify only the protective glove
material. The break-through-times are dependent not only on the
material but also on the manufacturing technique. It is therefore
essential to consult the manufacturers of protective gloves. For the
ingredients of the battery the following materials should be
appropriate: for short-time contact (few minutes) rubber or plastic is
sufficient, for long-time contact use gloves of nitrile/latex rubber -
NBR (0.35 mm).
Safety glasses with side shield.
Use chemical resistant protective clothing if contamination of
clothing cannot be avoided. Change contaminated clothing
immediately.
Avoid contact with eyes and skin. Do not inhale aerosols or vapours.
Wash hands or skin after contact immediately. Do not eat, drink,
smoke or take snuff at work.
33
Page 6/ 14