Table of Contents

Advertisement

Quick Links

W
A
!
E L C O M E
B O A R D
T
C
A B L E O F
O N T E N T S
C
1 : C
H A P T E R
Owner's Packet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1
Warranty Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1
Dealer's Responsibilities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1
Consumer Responsibilities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2
Hazard Warning Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3
C
2 : S
H A P T E R
Required Safety Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
Additional Recommended Equipment . . . . . . . . . . . . . . . . . . . . . . . 2-1
Registration Numbers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1
Emergency Stop Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
Emergency Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-2
Boating Safety Tips . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3
Certification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4
Loading Capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-4
Carbon Monoxide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-5
Suggested Boating Classes And Reading Material . . . . . . . . . . . . . . 2-6
C
3 : G
H A P T E R
Fueling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-1
Fuel System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-2
Fuel Select Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3
Pollution Regulations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3
Discharge of Oil or Hazardous Substances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4
Disposal of Plastics or Garbage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4
Trailering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4
Predeparture . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-5
Casting Off & Approaching The Dock . . . . . . . . . . . . . . . . . . . . . . . 3-5
Anchoring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-5
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-6
Shallow Water . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-6
Windlass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-7
General Information On Boat Handling . . . . . . . . . . . . . . . . . . . . . . 3-7
Twin Engine Boats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-7
Commonly Used Nautical Terms . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-8
C
4 : P
H A P T E R
Performance Factors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
Engine Efficiency . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
Weather Conditions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
Load Distribution . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
Marine Growth . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
Trim . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
Propeller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
T
A B L E O F
C
O N T E N T S
O N S U M E R
E N E R A L
T
A B L E O F
C
O N T E N T S

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Marlin 300 and is the answer not in the manual?

Questions and answers

Summary of Contents for Grady-White Marlin 300

  • Page 1: Table Of Contents

    A B L E O F O N T E N T S A B L E O F O N T E N T S E L C O M E B O A R D A B L E O F O N T E N T S 1 : C H A P T E R...
  • Page 2 A B L E O F O N T E N T S Propulsion System – Outboard ......4–3 Engine Warranty .
  • Page 3 A B L E O F O N T E N T S 8 : 3 0 0 M H A P T E R A R L I N S p e c i f i c a t i o n s ......8 – 1 O p t i o n a l F e a t u r e s .
  • Page 4 A B L E O F O N T E N T S Access Plate And Rigging Tube Location ....8–19 Fuel System .
  • Page 5: Information

    Grady-White Boat, the dealer will fill out a warranty card. This card will be kept on file at the dealership and at the Grady-White factory. A copy will be provided for your records and should be kept with other valuable documents for future reference. For questions regarding your warranty please contact your dealership.
  • Page 6: Consumer Responsibilities

    • Return the boat to the selling dealer for an engine inspection. Refer to the engine’s owner’s manual for the proper maintenance schedule. Grady-White Boats has a permanent record of your boat which is retained under its “Hull Identification Number” (HIN). Data regarding equipment and accessories, as well as dealer/ shipping information is documented.
  • Page 7: Hazard Warning Labels

    E L C O M E AZARD ARNING ABELS The hazard warning labels shown below are applied throughout this manual to alert the customer of potentially dangerous situations that can lead to death, personal injury, and/or product damage. We urge you to observe these warnings and comply with all safety recommendations. D A N G E R This symbol alerts you to imminently hazardous situations which will cause severe personal injury or death if the warning is ignored.
  • Page 8 E L C O M E 1–4...
  • Page 9: A F E T Y

    Children and non-swimmers are advised to wear a PFD at all times. • Sound Signaling Device (Horn, Bell Or Whistle) Your Grady-White is equipped with a horn that meets USCG requirements. • Visual Distress Signals USCG approved visual distress signals are required on U. S. waters. See page 33 of the pamphlet Sportfish, Cruisers, Yachts Owner’s Manual enclosed with this manual for more...
  • Page 10: Emergency Stop Switch

    A F E T Y MERGENCY WITCH All Grady-Whites are equipped with an emergency stop switch. This is a safety feature that if used properly will shut the engine(s) down if the operator leaves or falls from the helm position. The ignition shutdown system includes a shut-off switch, switch clip, lanyard and lanyard clip.
  • Page 11: Boating Safety Tips

    • Before operating your Grady-White READ AND STUDY ALL OPERATION AND MAINTENANCE MANUALS. It is important that you fully understand how to use your boat. Contact your Grady-White dealer for questions. Proper use and service will insure quality performance and longevity of your boat.
  • Page 12: Certification

    With this tag, you can have confidence in the safety of your boat. This label means that Grady-White has designed and built your boat to the ABYC standard H-8, buoyancy in the event of swamping. Basic flotation is defined as having enough foam in the boat to create buoyancy and prevent sinking under swamped conditions.
  • Page 13: Carbon Monoxide

    A F E T Y ARBON ONOXIDE W A R N I N G (CO) is produced by all combustion engine(s) and generator sets. Avoid brain damage or death from carbon monoxide. Keep cockpit and cabin areas well ventilated. Avoid blockage of exhaust outlets. Signs of exposure include headache, nausea, dizziness and drowsiness.
  • Page 14: Suggested Boating Classes And Reading Material

    A F E T Y UGGESTED OATING LASSES EADING ATERIAL Like a car, boats must be operated according to safety rules and traffic regulations. Although we include some basic boating tips in this manual, a thorough review of the safety rules and regulations for boating is beyond the scope of this text.
  • Page 15: I N F O R M A T I O N

    E N E R A L N F O R M A T I O N C h a p t e r 3 : G e n e r a l I n f o r m a t i o n UELING W A R N I N G Safety during fueling requires CAUTION and COMMON SENSE.
  • Page 16: Fuel System

    E N E R A L N F O R M A T I O N •If your boat is equipped with two fuel tanks use the fuel select valve (see “Fuel Select Valve” on page 3–3) to select the main or aux tank. Select the tank to be used first taking into consideration the distribution of your load as fuel is consumed.
  • Page 17: Fuel Select Valve

    E N E R A L N F O R M A T I O N ELECT ALVE If your boat is equipped with dual fuel tanks, you will have a manual fuel select valve installed. This valve allows you to choose from which tank fuel will be consumed. Remember, as the fuel is consumed and the fuel load redistributes the performance will be influenced.
  • Page 18: Discharge Of Oil Or Hazardous Substances

    E N E R A L N F O R M A T I O N Discharge of Oil or Hazardous Substances The Federal Water Pollution Control Act prohibits the discharge of oil or hazardous substances, which may be harmful, into or upon U.S. navigable waters. Vessels 26 feet in length or over must display a placard at least 5”...
  • Page 19: Predeparture

    E N E R A L N F O R M A T I O N Practice maneuvering the trailer; the trailer always backs in the opposite direction of the vehicle. To maneuver the trailer, turn the steering wheel in the direction you want the trailer to go. Familiarize yourself with this manual and all aspects of your boat prior to initial launch.
  • Page 20: Towing

    E N E R A L N F O R M A T I O N OWING In the event of a mishap or power loss you may need to tow a boat or be towed. You should not tow a boat larger than your own. Always use safety and good judgement when towing. Never tow a boat if you are not equipped with the proper lines.
  • Page 21: Windlass

    E N E R A L N F O R M A T I O N INDLASS Anchoring can be less laborious if your boat has a windlass accessory. If your boat is equipped with a windlass, reference your windlass Operation Manual for instructions. ENERAL NFORMATION ANDLING...
  • Page 22: Commonly Used Nautical Terms

    E N E R A L N F O R M A T I O N OMMONLY AUTICAL ERMS Access Plate Port Side Stern Beam Gunwale Starboard Side Bow Eye Chine Keel Abeam - a line perpendicular to a Deck - upper structure which covers Lee - the side that is sheltered from boat’s keel the hull...
  • Page 23: E R F O R M A N C E

    E R F O R M A N C E C h a p t e r 4 : P e r f o r m a n c e ERFORMANCE ACTORS Maximum performance is dependent on many factors and cannot be guaranteed. These factors will vary with changing conditions.
  • Page 24: Propeller

    E R F O R M A N C E Propeller The condition of your prop has a major influence on the performance of your boat. Your engine(s) should be equipped with the best size prop for normal conditions. Unusual uses or weight conditions may require special props.
  • Page 25: Propulsion System - Outboard

    E R F O R M A N C E – O ROPULSION YSTEM UTBOARD The engine manufacturer supplies all vital information concerning your engine(s) in the Operation and Maintenance Manual(s). Details of important engine functions such as the lubrication system, cooling system, and alarm/monitoring system are outlined in these manuals. Your familiarization with this engine reference material will result in the proper usage and service essential for safe and enduring engine performance.
  • Page 26: Steering

    E R F O R M A N C E TEERING Most outboard engines are equipped with an adjustable rudder trim tab. This trim tab should be adjusted to balance the steering at the speed which you travel most frequently. Variations in speed, boat load or engine trim will cause the steering to pull in one direction.
  • Page 27: Throttle/Shift Control

    E R F O R M A N C E HROTTLE HIFT ONTROL The throttle/shift controls located at the helm station control the flow of fuel to the engine. They also act as gear shift levers to control the forward and aft thrust of the propellers. The middle position of the throttle control is the neutral position.
  • Page 28 E R F O R M A N C E 4–6...
  • Page 29: Yamaha Instrumentation Panel

    C h a p t e r 5 : I n s t r u m e n t a t i o n a n d S w i t c h e s AMAHA NSTRUMENTATION ANEL Grady-White installs full Yamaha Command Link instrumentation on pre-rig boats. The instruments are powered by the ignition key(s) and will operate when the ignition switch(es) is in the “on” position. IGITAL...
  • Page 30: Digital Tachometer

    N S T R U M E N T A T I O N A N D W I T C H E S • Speedometer This feature indicates boat speed in miles per hour, knots per hour, or nautical miles per hour. On boats with V8 engines, this gauge must be interfaced with a GPS.
  • Page 31: Switch Panel

    N S T R U M E N T A T I O N A N D W I T C H E S WITCH ANEL At the helm station you will find an accessory switch panel. Not all boats are equipped with the same accessories.
  • Page 32 N S T R U M E N T A T I O N A N D W I T C H E S 5–4...
  • Page 33: Chapter 6 : M A I N T E N A N C E A N D S E R V I C E

    IBERGLASS INISH The exterior finish of your Grady-White is a thin layer of resin with a finished color pigment called gel-coat. It is used for cosmetic purposes and makes routine maintenance relatively simple. Although gel-coat has a hard smooth surface, it does contain microscopic pores that will allow surface discoloration if not kept clean.
  • Page 34: Finish/Waxing

    A I N T E N A N C E A N D E R V I C E Finish/Waxing Gel-coat will age or dull naturally due to constant exposure to the natural environment and pollutants. Discolorations are shallow in depth. Factors that will affect the rate of discoloration are: the sun, pollution, old wax accumulation, and the salt content of water.
  • Page 35: Repairing

    The canvas will not be completely leak proof. The seam holes in your canvas may stretch and tend to leak. However, you can correct this problem by applying *Apseal® or Uniseal™ to the seams. Please understand that Grady-White does not warrant the fit and design of the canvas to be entirely watertight.
  • Page 36: Snaps And Zippers

    A I N T E N A N C E A N D E R V I C E Snaps And Zippers To protect the snaps and zippers on your boat’s canvas and cushions from corrosion and binding, Grady White includes a snap/zipper assist tool and a tube of lubricant (E-Z Snap™) in your owner’s packet.
  • Page 37: Upholstery

    TEEL AILS The hardware on your Grady-White is made of laboratory grade 316 stainless steel and needs regular cleaning to maintain its “less staining” properties. The key to maintaining your stainless steel is to keep it clean with a mild solution of soap and FRESH water. Remove salt or dirt from your stainless steel on a regular basis.
  • Page 38: Hardware Mounting

    A I N T E N A N C E A N D E R V I C E ARDWARE OUNTING Ensure all holes are sealed properly when mounting hardware in the boat surface. Sealing will prevent water leakage. This is crucial in fiberglass areas that have been reinforced with plywood. A hole sealed improperly allows water inside the fiberglass leading to saturation of the plywood reinforcement.
  • Page 39: Fuel Tank Compartment

    ATTERIES Proper battery power is essential to the operation of your vessel. For this reason, Grady-White has carefully chosen a battery with cranking ability and reserve capacity sufficient to meet your needs.
  • Page 40 A I N T E N A N C E A N D E R V I C E This is not a complete set of guidelines. It is your responsibility to safely maintain your batteries and avoid injury. Use good judgement and remain alert to prevent an accident. In the event of an accident or exposure to electrolyte, immediately seek prompt medical advice or attention.
  • Page 41: Light Bulb Replacement Guide

    All of the lights shown may not be used on every model boat. If you have difficulty finding replacement bulbs under the part numbers listed, contact your Grady-White dealer for further assistance. Always use the specified replacement bulb. Improper substitution my result in electrical malfunction, insufficient lighting, boat damage or personal injury.
  • Page 42: Accessory Wiring Color - Fuse/Breaker Sizes

    A I N T E N A N C E A N D E R V I C E – F CCESSORY IRING OLOR REAKER IZES 290, 300, 305, 330, & 336 DC Wiring Chart Together Delivering the Ultimate Boating Experience! Accessory Wire Size &...
  • Page 43: Chapter 7 : W I N T E R I Z A T I O N A N D S T O R A G E

    Manual for a checklist on winterizing and storage. TORAGE Grady-White boats are equipped with stern eyes and a bow eye. These eyes are for anchoring and trailering purposes, and should be inspected regularly to insure structural integrity. W A R N I N G The boat should not be lifted for storage using the bow and stern eyes.
  • Page 44: Cleaning And Lubricating The Boat

    I N T E R I Z A T I O N A N D T O R A G E For outdoor storage, a canvas cover should be used to prevent “sweating”. One method is to build a frame over the boat to support the canvas. It should be a few inches wider than the boat so the canvas will clear the rails and allow passage of air.
  • Page 45: Head System

    I N T E R I Z A T I O N A N D T O R A G E YSTEM Empty toilet and holding tank making sure all water is cleared. Reference Owner’s Packet for manufacturer’s information on winterization. Water should be removed from deck pump-out hoses.
  • Page 46: Getting Boat Out After Storage

    I N T E R I Z A T I O N A N D T O R A G E • Remove any detachable and valuable equipment such as electronics. Store all electronics inside. Your compass should be covered for the winter. Ultraviolet rays from the sun will cloud the compass and make it difficult to read.
  • Page 47 I N T E R I Z A T I O N A N D T O R A G E • Thoroughly check the fuel system including lines, fittings, connections, valves, and filters for leaks. • Connect to shore power. Check out all electrical equipment, lights, hot water heater, air conditioning system, etc.
  • Page 48 I N T E R I Z A T I O N A N D T O R A G E 7–6...
  • Page 49: S P E C I F I C A T I O N S

    3 0 0 M A R L I N C h a p t e r 8 : 3 0 0 M a r l i n S p e c i f i c a t i o n s Beam-amidship.....................
  • Page 50: O P E R A T I O N O F S T A N D A R D F E A T U R E S

    3 0 0 M A R L I N O p e r a t i o n O f S t a n d a r d F e a t u r e s WITCH ANEL At the helm you will find an accessory switch panel. Not all boats are equipped with the same accessories.
  • Page 51: Auxiliary Fuse Panel

    3 0 0 M A R L I N recommended breaker amperages. Switch labels are available from your dealer for non- factory installed options. N O T I C E Use anti-corrosion spray on the back of panels and on exposed wires to prevent the rust of corrosion that could lead to an electrical system failure.
  • Page 52: Accessory Outlet - 12 Volt

    3 0 0 M A R L I N - 12 V CCESSORY UTLET Three 12-volt outlets are installed on your 300. They are located in the port and starboard deck wing inserts on the vertical surfaces in front of the cupholders and in the dinette area near the stove.
  • Page 53: Windshield Washer Switch

    3 0 0 M A R L I N Should the high bilge water alarm activate, immediately investigate to determine the source of water entry. Also, confirm your bilge pumps are working properly. If the situation cannot be quickly resolved, contact your dealer and remove the boat from the water. See “12 Volt DC High Bilge Water Alarm Diagram”...
  • Page 54: Seacocks

    3 0 0 M A R L I N EACOCKS Ball valve seacocks are installed on the thru hulls for the livewell, washdown, and head discharge features. For proper drainage, it is necessary for the seacock to be in the open position. The open position for the livewell and washdown can be obtained by pulling up on the remote arm attached to the seacock handles.
  • Page 55: Dockside Power

    3 0 0 M A R L I N OCKSIDE OWER The dockside power feature allows the use of AC equipment on board the boat. This equipment includes any permanently installed appliances such as a battery charger or water heater, or it may be a household item plugged into a receptacle. The dockside power is utilized by connecting the heavy-duty cable supplied with the boat to an appropriate external power source.
  • Page 56: Ac Powered Accessories

    3 0 0 M A R L I N AC P OWERED CCESSORIES AC/DC Panel The 300 Marlin AC/DC panel is located in the wire cover box on the aft wall of the cabin on the starboard side. AC and DC powered switches are noted below. See “120 Volt AC Wiring One Line Diagram”...
  • Page 57: Battery Charger

    3 0 0 M A R L I N • Stove Reference the manufacturer's Operation Manual for information on safe handling and proper procedures prior to using the stove. W A R N I N G Understand the instructions and warnings before operating your stove. •...
  • Page 58: Water Heater

    3 0 0 M A R L I N Water Heater The optional generator must be operating or the dockside power connected with the AC breaker switch on for the water heater to function. This accessory will provide hot water to the pressurized fresh water system.
  • Page 59: Livewell - Raw Water

    3 0 0 M A R L I N Livewell - Raw Water To operate the livewell, open the seacock located in the port aft bilge using the remote arm labeled livewell. The livewell pump is screwed directly into this seacock. The livewell switch at the helm should be in the on position.
  • Page 60: Battery Select Switch

    3 0 0 M A R L I N Battery Select Switch The 300 Marlin is equipped with four batteries and two battery select switches. The batteries are grouped into two banks, each bank consisting of two batteries wired in parallel. One battery select switch is designated for each engine, and the accessories operate from the same switch as the starboard engine.
  • Page 61: Trim Tabs

    3 0 0 M A R L I N Trim Tabs Trim tabs are electrically and hydraulically operated. The trim tab system consist of a hydraulic pump, a two-rocker switch panel, a trim tab position indicator panel, and an auto- retract device.
  • Page 62: Vacuflush Head System

    3 0 0 M A R L I N Vacuflush Head System The VacuFlush Head consists of a virtuous china bowl, vacuum pump with tank, and a holding tank. To operate the head, the head and water press. switches on the DC panel must be in the on position.
  • Page 63: O P E R A T I O N O F O P T I O N A L F E A T U R E

    3 0 0 M A R L I N O p e r a t i o n O f O p t i o n a l F e a t u r e s ENERATOR The generator option enables you to use AC accessories without being attached to shore power.
  • Page 64: Ac Transfer Switch

    3 0 0 M A R L I N AC Transfer Switch If your Marlin is equipped with a generator, there will be a transfer switch located in the cabin beneath the AC/DC panel. This switch permits you to operate your AC accessories by either shore power or generator.
  • Page 65: Tv/Dvd

    3 0 0 M A R L I N TV/DVD The television is a 15” flat screen LCD unit with speakers across the bottom. It is located in a separate TV cabinet near the forward vee berth. An A/B switch located on the bottom of TV cabinet is used to change between broadcast antenna and dockside cable reception.
  • Page 66: Outriggers

    3 0 0 M A R L I N UTRIGGERS The optional outriggers spread the fishing lines being trolled from your boat and decrease the chance of entanglement. • Advantages Advantages of outriggers include offering bait throughout a larger area behind the boat, placing bait out of the wake zone, automatic drop back following strikes (which allows for fish to completely accept bait), and a reduction in unnecessary twisting action characteristic of artificial bait.
  • Page 67: Access Plate And Rigging Tube Location

    3 0 0 M A R L I N I n f o r m a t i o n a l D r a w i n g s A c c e s s P l a t e A n d R i g g i n g T u b e L o c a t i o n 6"...
  • Page 68: Fuel System

    3 0 0 M A R L I N F u e l S y s t e m Fuel Fill 150 Gallon & Vent Fuel Tank 150 Gallon Fuel Tank Fuel Filters Fuel Select Valve Primer Bulbs Oil Fills 8–20...
  • Page 69: Labels And Location

    3 0 0 M A R L I N L a b e l s A n d L o c a t i o n CAUTION TO AVOID PERSONAL INJURY, KEEP HANDS FREE OF WINDLASS AND ROPE WHEN OPERATEING On AC/DC Panel WARNING Inside Rigging Compartment...
  • Page 70: Livewell System Layout

    3 0 0 M A R L I N L i v e w e l l S y s t e m L a y o u t Livewell Inlet Livewell Drain Washdown Seacock 1100 gph Livewell Pump & Seacock Washdown Fitting Washdown Strainer Washdown Pump...
  • Page 71: Livewell/Washdown System

    3 0 0 M A R L I N L i v e w e l l / Wa s h d o w n S y s t e m To Washdown Fitting To Livewell Washdown Pump Strainer Pump Seacock Hull Bottom Forward...
  • Page 72: Vaccuflush Head Layout

    3 0 0 M A R L I N Va c c u f l u s h H e a d L a y o u t Cabin Vacu-flush Deck Bulkhead Marine Head Pump- Discharge Vaccum Tank Seacock With Pump Vent Holding Tank...
  • Page 73: Pressurized Fresh Water System

    3 0 0 M A R L I N P r e s s u r i z e d F r e s h Wa t e r S y s t e m Galley Sink Drain Head Sink Drain Galley Sink &...
  • Page 74: Thru Hull Detail

    3 0 0 M A R L I N T h r u H u l l D e t a i l Description Galley Sink Drain Shower Sump Fwd Bilge Head Vent Livewell Drain/Overflow Gen Exhaust (Diesel) Aft Bilge Scupper Drains Aft Fishbox Drain Stbd Rigging Station Drain...
  • Page 75: Air Conditioning Layout & Assembly

    3 0 0 M A R L I N A i r C o n d i t i o n i n g L a y o u t & A s s e m b l y A/C Control Panel 4"...
  • Page 76: Diesel Generator Layout

    3 0 0 M A R L I N D i e s e l G e n e r a t o r L a y o u t Generator Fuel Gauge Generator Control Panel at AC/DC Panel CO Monitor Generator Harness 10 AWG 3 AC wiring to AC Panel...
  • Page 77: Bow Thruster Layout

    3 0 0 M A R L I N B o w T h r u s t e r L a y o u t Bow Thruster Motor 0000 ga Red Cable Joystick Control harness 0000 ga Bow Thruster Black Cable Joystick Control Emergency Shutoff Switch...
  • Page 78: Hardtop Wiring

    3 0 0 M A R L I N H a r d t o p W i r i n g All wiring illustrations shown in this drawing represent both the positive and ground wiring. Reference “Accessory Wiring Color – Fuse/Breaker Sizes” on page 6–10 for color codes and gauge sizes.
  • Page 79: Stereo System Layout

    3 0 0 M A R L I N S t e r e o S y s t e m L a y o u t Sirius Antenna 4" Speakers with Covers 6 Meter Remote 35' Sirius Extension Harness Antenna Cable 6 Meter Remote Extension Harness...
  • Page 80: Accessory Wiring

    3 0 0 M A R L I N A c c e s s o r y W i r i n g Bow Lights Anchor Windlass Wiper Motor Horn DVD Player Flat Screen TV Reading Light 300W 12V DC to AC Inverter Refrigerator Reading Light...
  • Page 81: Dockside Wiring

    3 0 0 M A R L I N D o c k s i d e W i r i n g Wire Sizes: Main Shore Inlet: 10 AWG/3 Microwave: 12 AWG/3 Battery Charger: 16 AWG/3 Water Heater: 10 AWG/3 Outlets: 14 AWG/3 Stove: 12 AWG/3 Air Conditioner: 10 AWG/3...
  • Page 82: Battery Wiring With Select Switches

    3 0 0 M A R L I N B a t t e r y W i r i n g W i t h S e l e c t S w i t c h e s Battery Battery Bank (#2)
  • Page 83: Volt Ac Wiring One Line Diagram

    3 0 0 M A R L I N 1 2 0 Vo l t A C W i r i n g O n e L i n e D i a g r a m GENERATOR SHORE # 1 (SELF LIMITING) MECHANICAL INTERLOCK TO...
  • Page 84: Volt Dc Distribution Diagram

    3 0 0 M A R L I N 1 2 Vo l t D C D i s t r i b u t i o n D i a g r a m LINE SEE DWG SEE DWG SEE DWG 300-DC-1-1 300-DC-1-1...
  • Page 85: Volt Dc Cockpit Switch Panel Diagram

    3 0 0 M A R L I N 1 2 Vo l t D C C o c k p i t S w i t c h P a n e l D i a g r a m SEE DWG SEE DWG LINE...
  • Page 86: Volt Dc Lighting Diagram

    3 0 0 M A R L I N 1 2 Vo l t D C L i g h t i n g D i a g r a m FROM DWG FROM DWG LINE 300-DC-2 300-DC-1-1 LINE 5 LINE 2 16 GA BLU/GN VALANCE...
  • Page 87: Volt Dc Fuse Block Diagram

    3 0 0 M A R L I N 1 2 Vo l t D C F u s e B l o c k D i a g r a m LINE SEE DWG SEE DWG 300-DC-1-1 300-DC-1-1 LINE 2 LINE 8 10 GA R/ORG ACCESSORY...
  • Page 88: Volt Dc Trim Tab Diagram

    3 0 0 M A R L I N 1 2 Vo l t D C T r i m Ta b D i a g r a m 8–40...
  • Page 89: Volt Dc Anchor Windlass Diagram

    3 0 0 M A R L I N 1 2 Vo l t D C A n c h o r W i n d l a s s D i a g r a m 8–41...
  • Page 90: Volt Dc Hard Top Elementary Diagram

    LINE 5 LINE 2 10 GA R/W 10 GA R/W SEE DWG 300-DC-1-1 LINE 10 FOR VHF (NOT INSTALLED BY GRADY-WHITE) 10 GA BLK/W 10 GA BLK/W SEE DWG 300-DC-1-1 LINE 1 14 GA GRY/R 14 GA GRY/R SEE DWG...
  • Page 91 3 0 0 M A R L I N 1 2 Vo l t D C I g n i t i o n C i r c u i t & T r i m D i a g r a m SEE DWG LINE 300-DC-1-1...
  • Page 92: Volt Dc High Bilge Water Alarm Diagram

    3 0 0 M A R L I N 1 2 Vo l t D C H i g h B i l g e Wa t e r A l a r m D i a g r a m LINE SEE DWG SEE DWG...
  • Page 93 3 0 0 M A R L I N 1 2 Vo l t D C S t e r e o w i t h o u t S a t e l l i t e R a d i o D i a g r a m SEE DWG SEE DWG LINE...
  • Page 94: Volt Dc With Satellite Radio Diagram

    3 0 0 M A R L I N 1 2 Vo l t D C w i t h S a t e l l i t e R a d i o D i a g r a m SEE DWG SEE DWG 13 PIN KENWOOD DIN CABLE TO 2C RCA ADAPTOR...
  • Page 95: Tv/Dvd & Phone Diagram

    3 0 0 M A R L I N T V / D V D & P h o n e D i a g r a m LINE SHORE CABLE TV INLET FLAT PANEL RG6 COAXIAL RG6 COAXIAL SELECTOR TELEVISION SWITCH 3C RCA CABLE...
  • Page 96: Electrical Plug Connection Detail

    3 0 0 M A R L I N E l e c t r i c a l P l u g C o n n e c t i o n D e t a i l P l u g # P l u g P l u g P l u g C o n n e c t i o n...
  • Page 97: Five Year Hull Transferable Warranty

    Any structural defects covered by the warranty will be repaired free of charge at either the Grady-White factory in Greenville, North Carolina, or at an authorized Grady-White dealer location as elected by Grady-White. Transportation to and from the point of repair will be the responsibility of the owner with all repairs subject to prior written authorization by Grady-White Boats, Incorporated.
  • Page 98: Warranty Claim Procedures

    LAIM ROCEDURES Upon the discovery of a defect, the owner is to promptly contact the Grady-White dealer from whom the original retail purchaser purchased the boat who will effect the corrective action under this warranty upon prior written authorization from Grady-White Boats, Incorporated.
  • Page 99 Why did you sell this boat? _____________________________ 5a. In which of the following ways do you use your Grady-White? (Please mark all applicable in column A.) 5b. In which one way do you use your Grady-White most often? (Please mark one only in column B.)
  • Page 100 Which of the following most influenced your selection of a Grady-White boat? (Please pick three or fewer reasons.) About Grady-White Grady-White's overall reputation Previous experience with a Grady-White About the boat itself Cockpit layout Hull design/ride Resale value Safety/seaworthiness Styling...
  • Page 101 3 0 0 M A R L I N 1 2 Vo l t D C E l e m e n t a r y D i a g r a m LINE LINE CONT. FROM 300-DC-1-2 LINE 11 SEE DWG 10 GA BLK/W (3) 16 GA GN...
  • Page 102 3 0 0 M A R L I N 1 2 0 Vo l t A C E l e c t r i c a l D i a g r a m BATTERY 3C 16 GA CHARGER BATTERY 10A (CB) CHARGER (SEE 300-DC-1-1...

Table of Contents