Publication 999 3032.3 All specifications are nominal and may change as design improve- ments occur. Greenlee Textron Inc. shall not be liable for damages resulting from misapplication or misuse of its products. Loctite and 242 are registered trademarks of Loctite Corporation.
Long-term exposure to high noise levels could result in hearing loss. Wear foot protection when using this tool. Failure to observe this warning could result in serious injury. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 4
Do not disconnect tool, hoses, or fittings while the power source is running or if the hydraulic fluid is hot. Hot hydraulic fluid could cause serious burns. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 5
Nearby personnel may be injured by flying or falling debris or by flying parts in the event of a tool malfunction. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
2. Lifting Bracket 7. Trigger Bar (HPD-T) 3. Side Handles 8. Remote Control Valve (HPD-HV) 4. Supply (pressure) Port 9. Adapter Release Ring 5. Serial Number Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Pressure ......9/16–18 SAE O-ring boss Return ........ 3/4–16 SAE O-ring boss RELIEF COOLER VALVE 160 bar RESERVOIR (2300 psi) CONTROL VALVE TOOL FLOW METER PUMP POWER SOURCE Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 8
SHELL Tellus oil T46 45.7 cSt ESSO Univis N46 51.0 cSt TEXACO Rando oil HDZ46 44.9 cSt MOBIL DTE 15 Permitted oil temperature Recommended oil temperature Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
4. Disconnect the return hose from the tool, then from the power source. 5. Install dust caps over the ports to prevent contamination. Typical Setup Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
(port P/CC) to the power source’s pressure port 3. Disconnect hoses in the reverse order of the (port P). connection sequence. 4. Install dust caps over the ports to prevent contamination. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Round 2.00" 1.75" 2.75 lb/ft 2.25" Square Post Square Post Flanged Channel Square Post 2.50 lb/ft 2.50" Flanged Channel Square Post 2.0 lb/ft Flanged Channel Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Wear eye protection when operating or servicing this tool. Failure to wear eye protection could result in serious eye injury from flying debris or hydraulic oil. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 13
8. When the tool is not in use, stop the power source to reduce heat and wear on tool components. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
As the quick- release couplings are blocked when disassembled, the striking piston must be pressed upward with the hoses mounted but the power source turned off. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 15
16. If the gauge (4) shows too high a nitrogen pres- (not shown) (8) Reducing nipple sure, loosen the bleeder valve (5) until the re- (24.32-14WFG) quired pressure is achieved. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Low accumulator gas pressure. Return tool to an authorized Fairmont blow energy is weak. service center. Broken accumulator diaphragm. Return tool to an authorized Fairmont service center. Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
9* 70 Nm (52 ft-lb) 80 Nm (59 ft-lb) 10* 100 Nm (74 ft-lb) 16* 15* 100 Nm (74 ft-lb) 52 53 HPD-HV HPD-T ® *Loctite Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 18
Trigger cartridge (HPD-HV) ......1 5028782 Seal kit (includes items marked with an asterisk) 50022431 Trigger rod ............1 50022458 Packing gland ..........1 50022474 Spring .............. 1 Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
Page 19
Screw, cap, #10–24 x .500, flat head ....2 50032097 Screw, M5x8 ........... 4 50022199 Screw, M10x30 ..........2 50023535 Roll pin, Ø6x24 ..........2 Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...
4455 Boeing Drive • Rockford, IL 61109-2988 • USA • 815-397-7070 52022622 Anvil spring ............. 1 An ISO 9001 Company Greenlee Textron Inc. is a subsidiary of Textron Inc. • www.greenlee.com Greenlee / A Textron Company 4455 Boeing Dr. • Rockford, IL 61109-2988 USA • 815-397-7070...