Advertisement
Quick Links
Advertisement
Subscribe to Our Youtube Channel
Related Manuals for Vintage Air 11301-VUY-A
Summary of Contents for Vintage Air 11301-VUY-A
- Page 1 ISO 9001:2015 Registered Company SLIMLINE COOL 11301-VUY-A 11401-VUY-A 18865 Goll St. San Antonio, TX 78266 Phone: 800-862-6658 Sales: sales@vintageair.com Tech Support: tech@vintageair.com www.vintageair.com 901302 REV E 07/16/19, SLIMLINE COOL PG 1 OF 11...
-
Page 2: Table Of Contents
Table of Contents PAGES COVER TABLE OF CONTENTS PACKING LIST INFORMATION PAGE INSTALLATION INSTALLATION CONTINUED HOSE ROUTING O-RING/FITTING INSTRUCTIONS WIRING DIAGRAM THERMOSTAT ADJUSTMENT EVAPORATOR KIT PACKING LIST 901302 REV E 07/16/19, SLIMLINE COOL PG 2 OF 11... - Page 3 INSTALLATION KIT (COOL ONLY) ** BEFORE BEGINNING INSTALLATION OPEN ALL PACKAGES AND CHECK CONTENTS OF SHIPMENT. PLEASE REPORT ANY SHORTAGES DIRECTLY TO VINTAGE AIR WITHIN 15 DAYS. AFTER 15 DAYS, VINTAGE AIR WILL NOT BE RESPONSIBLE FOR MISSING OR DAMAGED ITEMS.
- Page 4 WITH A HEAT GUN OR BY RUNNING THE ENGINE WITH THE HEATER ON BEFORE EVACUATING. LEAK CHECK AND CHARGE TO SPECIFICATIONS. VINTAGE AIR SYSTEMS ARE DESIGNED TO OPERATE WITH R134a REFRIGERANT ONLY! USE OF ANY OTHER REFRIGERANTS IS A FIRE HAZARD AND COULD DAMAGE EITHER YOUR AIR CONDITIONING SYSTEM OR YOUR VEHICLE.
-
Page 5: Installation
INSTALLATION ATTACH EVAPORATOR BRACKETS TO EVAPORATOR (SEE FIGURE 1). POSITION EVAPORATOR WITH BRACKETS UNDER DASH. MARK AND DRILL TWO (2) 9/32" DIAMETER HOLES UNDER THE LIP OF THE DASH. ATTACH THE FRONT BRACKETS TO THE DASH WITH 1/4" x 1" BOLTS, WASHERS AND NUTS PROVIDED (SEE FIGURE 2). - Page 6 THIS POSITION AFTER CRIMPING. THE RUBBER HOSE IS ONLY CAPABLE OF A MINIMAL AMOUNT OF TWIST TO AID ALIGNMENT. REMOVE HOSES AND CRIMP ENDS. IF YOU DO NOT HAVE ACCESS TO THE PROPER EQUIPMENT, VINTAGE AIR RECOMMENDS TAKING THEM TO A QUALIFIED A/C SERVICE CENTER FOR CRIMPING. (SEE CRIMPING INSTRUCTIONS SUPPLIED WITH THE HOSE KIT).
- Page 7 901302 REV E 07/16/19, SLIMLINE COOL PG 7 OF 11...
-
Page 8: O-Ring/Fitting Instructions
O-RING/FITTING INSTRUCTIONS TIGHTEN #6 HOSE HOLD TO PRESS TAPE RESIST TWISTING #10 HOSE #10 SUCTION HOSE #6 LIQUID HOSE FIGURE 3 LUBRICATE O-RINGS FOR A PROPER SEAL SUPPLIED OIL OF FITTINGS FOR O-RINGS O-RING, SLIDE OVER INSTALL SUPPLIED MALE INSERT TO O-RINGS AS SHOWN SWAGEED LIP AND LUBRICATE... -
Page 9: Wiring Diagram
WIRING DIAGRAM COOL (REQUIRED) YELLOW COMPRESSOR SAFETY SWITCH BLUE (BINARY TYPE) CLUTCH ORANGE BLUE BLACK SPEED SWITCH ORANGE THERMOSTAT BLACK YELLOW BLUE HIGH BLOWER RELAY ORANGE WHITE WHITE BLOWER BLACK GROUND GROUND MOTOR BLUE POWER CONNECT TO RELAY PURPLE GROUND KEY ON IGNITION SOURCE (5AMP FUSE) -
Page 10: Thermostat Adjustment
THERMOSTAT ADJUSTMENT COLDER CLOCKWISE ADJUSTABLE KNOB CAPILLARY TUBE COUNTERCLOCKWISE WARMER EVAPORATOR COIL AIR CONDITIONING ADJUSTMENTS: THE AIR CONDITIONER THERMOSTAT CONTROLS COIL TEMPERATURE. THERMOSTATS ARE SHIPPED ADJUSTED FULLY • COLD (CLOCKWISE), AND IN THE MAJORITY OF CASES, THE A/C WILL OPERATE CORRECTLY AS SHIPPED. TURNING THE KNOB TO THE RIGHT (CLOCKWISE) MAKES THE SYSTEM OPERATE COLDER. -
Page 12: Evaporator Kit Packing List
EVAPORATOR KIT 11301-VUY-A EVAPORATOR KIT PACKING LIST 11401-VUY-A No. QTY. PART No. DESCRIPTION 55327-VUE-A EVAPORATOR SUBCASE COOL ONLY w/ STD LOUVERS 55427-VUE-A EVAPORATOR SUBCASE COOL ONLY w/ BLK LOUVERS 64143-VUE EVAPORATOR MOUNTING BRKT. KIT 63301-VUE IK KIT (COOL ONLY) CHECKED BY:...
Need help?
Do you have a question about the 11301-VUY-A and is the answer not in the manual?
Questions and answers