Page 1
OWNER’S MANUAL for LUX700 For CART Models: JLS700-LP (Liquid Propane) JLS700-NG (Natural Gas) Important Notice Please read ALL safety notices on Pg. 2-3 before assembling or operating this grill. FIRE IT UP WITH JACKSON GRILLS. www.jacksongrills.com Version: JUL15...
Page 2
!SAFETY WARNINGS! IMPORTANT: Please read and understand all warnings and precautions before using your gas grill. !DANGER! !WARNING! If you smell gas: 1. Do not store or use gasoline or 1. Shut off gas to the appliance. other Flammable liquids in the 2.
Page 3
Inspect fuel supply hose for damage before each use. If excessive wear, abrasion, or cracks are present, the hose MUST be replaced with a genuine Jackson Grills replacement part, prior to using this outdoor cooking gas appliance (Contact your nearest dealer for assistance).
Table of Contents: Certification & Testing: Unpacking Your Grill: Parts Checklist: Contact Us: Owner Registration: Tools Required for Assembly: Assembling & Preparing your Grill: Clearance to Combustibles: Propane Gas Connection: 9-10 Natural Gas Connection: Leak Testing: Installer Final Checklist: Gas Conversion: Lighting Instructions: 14-15 Grilling and Rotisserie Cooking:...
Certification and Testing: This appliance has been tested by Labtest Certification Inc. (LC), and has been tested to ANSI Z21.58b-2012, & CSA 1.6b-2012, and Certified for Canada and the USA. Unpacking Your Grill: Please open your packaging carefully and set aside all loose components. Once unpacked, please match the parts to the list shown below.
To obtain replacement parts for your Jackson Grill, contact your local dealer. If you have any questions please call us anytime at the number below: (Please have your model and serial number at hand) Grill Model: JLS700-LP or JLS700-NG Serial Number: ___________________ Write your serial number here for future reference.
Tools Required for Assembly: Please use the proper tools to simplify installation and avoid injury or damage to your grill. INSTALLER SUPPLIED TOOLS: Large Phillips Screwdriver Small Phillips Screwdriver Small Crescent Wrench Large Crescent Wrench Assembling & Preparing your Grill: Tip of brass orifice, on Figure 1 end of valve;...
INSTALL SIDE SHELVES (2): 1. Install both Side Shelves, using 4 screws per shelf (supplied). (Fig. 4 Next Page) 2. Drop Cutting Board into opening in RH Side Shelf (Fig. 5) Figure 5 Figure 4 Phillips Head Mounting Screws (Included) ...
Propane Gas Connection: FUEL TYPE: The following instructions are for a Propane configured grill. Operating Pressure: 11” WC. HOSE & REGULATOR: Use only the propane hose and regulator supplied with your Propane grill. For replacement Hose & Regulator assemblies, please contact your local dealer and ask for part #JF-70. Only use genuine Jackson replacement parts.
Page 10
STORING PROPANE CYLINDERS: 1. Place dust cap on cylinder valve outlet whenever the cylinder is not in use. Only install the type of dust cap on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may result in leakage of propane.
Natural Gas Connection: !WARNING! 1 Never insert any foreign objects in valve outlet, as this may cause leaks. 2 Do NOT connect this grill to unregulated Propane systems such as in a motor home or camper trailer. System pressure MUST be regulated before hook up. 3 Do NOT use this grill until leak tests have been completed.
4. If the smell of gas is detected, immediately shut off gas or disconnect from source, and repair leaks before further attempts are made to use the grill. !WARNING! Propane and Natural Gas are very flammable; exercise extreme caution while checking for, and repairing gas leaks. Jackson Grills Support: 1-888-287-3333 or info@jacksongrills.com...
Installer Final Check List: Ensure that clearances to combustible materials are maintained per specifications listed in this manual. Make sure that all internal packaging has been removed. Check that the burners are sitting properly on orifice end of the valves. (p.7) ...
Fuel Conversion: This grill is convertible to Natural Gas or Propane when needed, with the installation of the appropriate Gas Conversion Kit. (See parts list, p.22) The kit should be installed by a qualified gas fitter. Please contact your local dealer for information.
4. FLAME CHARACTERISTICS: (Fig. 13) Check for proper burner flame characteristics. Each burner is adjusted prior to shipment; however, variations in the local gas supply may mean subtle adjustments may be necessary. Burner flames should be blue and stable. There should be no excessive noise, or flame lifting. If any of these conditions exist please call your Dealer.
Page 16
!WARNING! Clean your grill often, especially the grease pan and grease cup. Failure to do so may cause a grease fire, resulting in injury or property damage! FOOD SAFETY: Always adhere to the following tips to enjoy a safe and healthy outdoor grilling. ...
TIPS FOR ROTISSERIE COOKING: When using the rotisserie, the meat should be centered on the spit rod, after which it must be balanced. To balance the meat, first rotate the cut so that heaviest side is facing downwards. Next, position the counter balance so that it faces upwards.
Page 18
2. GREASE MANAGEMENT SYSTEM: Your grill is equipped with a small grease cup in the back of the unit. This cup should be emptied & cleaned thoroughly after each use and before the grill is transported. Your grill is designed to allow grease to flow along the bottom of the firebox, thereby collecting in both the grease pan and the small grease cup.(Fig.
5. INTERIOR CLEANING: Remove the cooking grid, flame diffuser and the burner from the grill. TECH-TIP Remove excess residue using a brush, scraper and/or cleaning pad. Many cleaners can be caustic, Spray inside the firebox with oven degreaser and let stand for 5 minutes. so for final cleaning use soapy ...
Trouble Shooting: A) SPIDER AND INSECT WARNING: Spiders and insects can nest in burners during storage. This hazard has been known to cause grill fires. Clean the main burners periodically, as well as before storing the grill. Closed for Nat Gas B) BURNER INSPECION: Inspect burners each time you use your grill, or immediately if one of the following occurs: 1.
(NO EXCEPTIONS) Jackson Grills or its parties will not be responsible for This Limited Warranty does not cover any damage the installation, labor or any other costs or expenses caused by misuse, lack of maintenance, hostile...