Table of Contents
Advertisement
Quick Links
Owner's Instruction and Operation Manual
Model Number:
BH32VF
Control #:4002719
Certified for installations in the USA
Approved for installation in mobile homes
* All Pictures In This Manual Are For Illustrative Purposes Only. Actual Product May Vary.
Failure to follow safety warnings exactly could result in serious injury, death, or property damage.
Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from a neighbor's phone. Follow the gas supplier's instructions.
• If you cannot reach your gas supplier, call the fire department.
Installation and service must be performed by a qualified installer, service agency or the gas supplier.
Please read this manual BEFORE installing and
operating this unit.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
© 2021 Breckwell Hearth, South Pittsburg, TN 37380
Save These Instructions In A Safe Place For Future Reference.
FIRE OR EXPLOSION HAZARD
THIS MANUAL IS SUBJECT TO CHANGE WITHOUT NOTICE.
WARNING:
CALIFORNIA PROPOSITION 65 WARNING:
This product can expose you to chemicals including carbon
monoxide, which is known to the State of California to cause
cancer, birth defects, and/or other reproductive harm. For
more information, go to
www.breckwell.com
853753-1803K
www.P65warnings.ca.gov
PH. 423-403-4031
Advertisement
Table of Contents
Related Manuals for Breckwell BH32VF
Summary of Contents for Breckwell BH32VF
- Page 1 INSTALLER: Leave this manual with the appliance. cancer, birth defects, and/or other reproductive harm. For more information, go to www.P65warnings.ca.gov CONSUMER: Retain this manual for future reference. THIS MANUAL IS SUBJECT TO CHANGE WITHOUT NOTICE. © 2021 Breckwell Hearth, South Pittsburg, TN 37380 www.breckwell.com PH. 423-403-4031...
- Page 2 • DO NOT USE A BLOWER INSERT, HEAT EXCHANGER INSERT OR OTHER ACCESSORY, NOT APPROVED FOR USE WITH THIS HEATER WHERE APPLICABLE. RETAIN YOUR ORIGINAL RECEIPT FOR ANY WARRANTY CLAIMS. CONTACT YOUR DEALER OR INSTALLER IF YOU NEED TO FILE A CLAIM. © 2021 Breckwell Hearth...
-
Page 3: Installation Checklist
Your gas stove should be installed by a qualified installer only. An NFI qualified Installer can be found at www.nficertified. org/public/find-an-nfi-pro/ For customer service, please contact your Breckwell dealer or visit www.Breckwell.com COMMISSIONING CHECKLIST This Checklist is to be completed in full by the qualified person who installs this unit. Keep this page for future reference. -
Page 4: Massachusetts Residents Only
© 2021 Breckwell Hearth... -
Page 5: Safety Information
If you have these vent-free appliance is in operation. signs, obtain fresh air immediately. Have the heater serviced as it may not be operating properly. © 2021 Breckwell Hearth... - Page 6 28. The stove door/screen must be closed when the or lung irritation. This is a normal and temporary appliance is operating. The screen shall have openings occurrence. The initial break-in operation should last for induction of combustion air. © 2021 Breckwell Hearth...
-
Page 7: Product Features
NOTE: An external regulator is required to reduce supply pressure to a maximum of 10.5” w.c. on Natural Gas systems operating at higher pressure. NOTE: An external regulator is required to reduce supply pressure to a maximum of 13.0” w.c. for LP systems. © 2021 Breckwell Hearth... -
Page 8: Getting Started
• External regulator (for Propane/LPG) or high pressure DESCRIBED IN THE NATIONAL FUEL GAS CODE, ANSI natural gas (1 to 2 psi system) Z223.1/NFPA 54, THE INTERNATIONAL FUEL GAS CODE OR APPLICABLE LOCAL CODES. • Piping which complies with local codes © 2021 Breckwell Hearth... -
Page 9: Clearances And Height Requirements
Max. Protrusion 12” Mantel Clearance From Top Of Unit Min. Height 18” Side View Right 2” Side Measured From Left 2” Rear Measured From Back 1” G Corner Measured From Top Corners 1/2” 36" in Front Minimum © 2021 Breckwell Hearth... -
Page 10: Installation
1. Remove the two (2) straps, and open the wrapping. Slide the bag to the bottom of the unit. Wrapping Straps Leg is removed for pictorial purposes only Leg is removed for pictorial purposes only Pallet © 2021 Breckwell Hearth... - Page 11 A SECOND PERSON IS STRONGLY SUGGESTED. PLEASE USE PROPER LIFTING TECHNIQUE WHEN POSITIONING Side of unit is removed THE APPLIANCE FOR ASSEMBLY AND INSTALLATION. for pictorial purposes only Screen BACK Side of unit is removed for pictorial purposes only © 2021 Breckwell Hearth...
-
Page 12: Connect Gas Line
CHECK SYSTEM OPERATION The millivolt system and individual components may be checked with a millivolt meter having a 0-1000 mV range. Conduct each check shown in chart below by connection meter test leads to terminals as indicated. © 2021 Breckwell Hearth... - Page 13 2 = TP 3 = TH Connect Switch or Meter Check To Test Meter Leads Thermostat Reading Test to Terminals Contacts Should Be Complete System 2 & 3 Closed Closed Thermopile 1 & 2 Open Open © 2021 Breckwell Hearth...
-
Page 14: Log Placement
Log #2 PI LO Back Log #1 PI LO Right Bottom Rear Log Log #3 Support Bracket PI LO Right Bottom Log Support Bracket Studs Log #3 Burner Ports Right Log Support Bracket © 2021 Breckwell Hearth Right Top Log #5... -
Page 15: Flame Appearance
NOTE: Thermocouple for LP Wash your hands immediately after coming in contact with Thermocouple wool material. In some cases the wool can cause slight for LP itching or burning, avoid any contact with eyes. © 2021 Breckwell Hearth... -
Page 16: Operation
Hi/Lo Knob WHAT TO DO IF YOU SMELL GAS: Off/Pilot/On Knb • Turn off all gas to the appliance. Burner Controls - Piezo Ignitor, Control Knobs © 2021 Breckwell Hearth... -
Page 17: Millivolt Control Lighting Instructions
Periodic Cleaning - See parts diagram for location of Control on off swit Stove) items discussed below. • Do not use cleaning fluid to clean logs or any part of the Pilot Control Cover Plate for Millivolt heater. © 2021 Breckwell Hearth... -
Page 18: How To Order Repair Parts
Other information that may be needed would be the part number and part description of the item(s) in question. Part numbers and descriptions can be found in the “Repair Parts” section of this manual. Once this information has been gathered you can contact your Breckwell dealer or visit www.Breckwell.com Model Information Model Number Dealer’s Name... -
Page 19: Troubleshooting
Check for bottom riser on glass door, sunken fireplace, Restrictions in incoming air flow. excessive lava rock/cinders densely packed against grate. Gas odor even Gas leak. Locate and correct all leaks. when control knob Control valve defective. Replace control valve. is in OFF position. © 2021 Breckwell Hearth... - Page 20 Clean burner or replace burner orifi LP-regulator shut down due to inlet pressure too Verify LP tank regulator is installed and set at No gas to pilot. high. 11” to 13” w.c. Replace regulator on heater. © 2021 Breckwell Hearth...
-
Page 21: Replacement Parts
ODS Pilot Assembly (LP) IN ORDER TO MAINTAIN WARRANTY, COMPONENTS MUST BE REPLACED USING ORIGINAL MANUFACTURERS PARTS PURCHASED THROUGH YOUR DEALER OR DIRECTLY FROM THE APPLIANCE MANUFACTURER. USE OF THIRD PARTY COMPONENTS WILL VOID THE WARRANTY. © 2021 Breckwell Hearth... -
Page 22: Service Record
Engineer Name: _________________________________ Engineer Name: _________________________________ License No.: _____________________________________ License No.: _____________________________________ Company: ______________________________________ Company: ______________________________________ Telephone No.: __________________________________ Telephone No.: __________________________________ Stove Inspected: Chimney Swept: Stove Inspected: Chimney Swept: Items Replaced: __________________________________ Items Replaced: __________________________________ © 2021 Breckwell Hearth... - Page 23 NOTES © 2021 Breckwell Hearth...
- Page 24 NOTES © 2021 Breckwell Hearth...
Need help?
Do you have a question about the BH32VF and is the answer not in the manual?
Questions and answers