Related Manuals for Forest-Master FM6DD-MUL
Summary of Contents for Forest-Master FM6DD-MUL
- Page 1 Forest Master Direct Drive Garden Mulcher Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL FM6DD-MUL FM4DDE-MUL IMPORTANT: Read this manual fully before assembly and use and observe all safety rules and operating instruc- tions...
- Page 2 FM6DDES-MUL - 6hp Petrol Engine with Electric Start FM4DDE-MUL - 4hp Electric Motor The FM6DD-MUL, FM6DDES-MUL and FM4DDE-MUL are garden mulchers designed to mulch weeds, greens, leaves, animal fodder, beet, potatoes, carrots, apples, etc. They will also mulch cardboard & paper. NOTE: Do not insert garden waste that contains stones, plastic, metal or any other objects may damage the blades Cardboard and paper must be free of staples.
-
Page 3: Table Of Contents
Contents Title Page No. Specifications Safety Instructions Assembly Operation Maintenance Troubleshooting Warranty Exploded Diagram (FM6DD-MUL/FM6DDES-MUL) Parts List (FM6DD-MUL/FM6DDES-MUL) Exploded Diagram (FM4DDE-MUL) Parts List (FM4DDE-MUL) Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL... -
Page 4: Specifications
Twin Reversible Blades Overall Height 780mm 780mm Overall Length 910mm 910mm Overall Width 480mm 390mm Weight 38kg 35kg Max Drum RPM 3600rpm 2800rpm Max Feed Diameter 50mm / 2” 50mm / 2” Starting Mechanism Pullstart / Electric Start Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL... -
Page 5: Safety Instructions
The mulcher should be operated by one person only. Any other bystanders must always be at least 50 feet from the work area. • Do not operate the FM6DD-MUL inside or in a confined space; the exhaust from the engine contains carbon monoxide which is poisonous. •... - Page 6 Safety with Maintenance • Inspection and maintenance must be done with the motor and driving unit switched off and the spark plug cap removed (FM6DD-MUL) or power cable (FM4DDE-MUL) disconnected. Wait 5 minutes for the engine or motor to cool down.
- Page 7 Safety with Petrol (FM6DD-MUL) Petrol is a highly flammable liquid. Petrol also gives off flammable vapour that can be easily ignited and cause a fire or explosion. Never overlook the hazards of petrol. Always follow these precautions: • Never run the engine in an enclosed area or without proper ventilation as the exhaust from the engine contains carbon monoxide, which is an odourless, tasteless and a deadly poisonous gas.
-
Page 8: Assembly
(45) through the small holes on the outer of the axle (46). Finally, place each dome cap (48) on the ends of the axle (46) and secure the cap by tapping it with a mallet or hammer. Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL... - Page 9 Fasten the motor (60) with the M8 bolts (56), M8 washers (33) and M8 Lock Nuts (57). The order of assembly is: [Bolt] – [Washer] – [Base] – [Motor] – [Washer] – [Lock Nut]. FM6DD-MUL FM4DDE-MUL Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL...
- Page 10 (56) and 4 M8 washers (33) that also secure the engine to the base. Connect the battery wires to the terminals on the battery (red to positive(+)). Place the battery on the tray and secure using the two M5 x 125 bolts (71) and nuts (72). Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL...
- Page 11 M6 bolts (51) the M6 washer (41) and the M6 spring washer (59). There is a thread in the drum housing to fasten the bolt into. The order of assembly is: [Bolt] – [Spring Washer] – [Washer] – [Feed Hopper] – [Drum Housing]. Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL...
- Page 12 It must be filled with 600ml of oil before use. It must be filled with the mulcher on level ground, do not tilt it. It is recommended to use 5W-30 in winter and 10W-30 in summer. M3x60 BOLTS Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL...
-
Page 13: Operation
Grasp the recoil starter handle and slowly pull until you feel resistance. If the pull start is tight on the FM6DD-MUL, the mulcher has a blockage and should be cleared before starting. Let the cord retract a little bit then pull the cord rapidly to start the engine. - Page 14 If the electric start does not turn the engine over then the battery may have insufficient charge. Start the engine using the pull start. The engine will trickle charge the battery, 30 minutes of running should provide sufficient charge to start the next time. Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL...
- Page 15 Do not push the material into the blades as this could damage the machine. • Do not over load the mulcher. Let previous material go through the blades before adding more. Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL...
- Page 16 Never attempt to unblock the machine whilst the mulcher is running. • If the drum stops while mulching, stop the engine IMMEDIATELY and remove the spark plug (FM6DD-MUL/FM6DDES-MUL) or disconnect the power cable (FM4DDE- MUL). • Unhinge either the feed hopper or discharge chute by removing the bolt and washers on the bottom of chute and lifting it upward to allow access to the drum.
- Page 17 The square shoulder of the coach is free to rotate. DO NOT remove the bolts must remain located in the slots nuts. in the back plate. Maximum Hopper Angle Minimum Hopper Angle CE Position Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL...
-
Page 18: Maintenance
Please refer to this manual and the engine manufacturer’s user manual for maintenance procedures. Before performing any maintenance procedure or inspection, stop the engine, wait five minutes to allow all parts to cool. Disconnect the spark plug wire (FM6DD-MUL/ FM6DDES-MUL) or the power cable (FM4DDE-MUL). Regular Maintenance Checklist... - Page 19 Remove the 4 screws and washers holding the CE plate and lift it out. Then remove the 2 screws holding the rubber flap, do not remove the 3 screws joining the flap sections together. RUBBER FLAP CE PLATE Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL...
-
Page 20: Troubleshooting
0191 276 6553. For spare parts contact 01912655000. Before performing any maintenance procedure or inspection, stop the engine, wait 5 minutes to allow all parts to cool. Disconnect the spark plug (FM6DD-MUL) or the power cable (FM4DDE-MUL). Symptom Possible Cause The engine won’t... - Page 21 Check the air filter and clean or replace if needed. • You may be using the wrong oil – too light for the temperature. Refer to your engine owner’s manual for detailed information. • Clean the cooling fins if they are dirty. Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL...
- Page 22 Is there a blockage in the drum? Inspect the drum and remove any potential blockages. • Does the motor need to be reset? Press the reset button on the motor (next to the on off switches). Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL...
-
Page 23: Warranty
The unit, if it has not been operated and/or maintained in accordance with the owner’s manual. Normal wear. Routine maintenance items such as lubricants and blade sharpening. Normal deterioration of the exterior finish due to use or exposure. Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL... - Page 24 FM6DD-MUL/FM6DDES-MUL Exploded Diagram (Petrol) 6 6 6 7 7 7 7 7 7 8 8 8 Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL...
- Page 25 Flat Washer Φ8×1.6 Nut M6 M3 x 60 Discharge Chute Safety Bolt M3 Discharge Chute Safety Nut Flat Washer Φ6×1.0 Base Wheel Front Foot Rubber Cap Split Pin 1.6×20 Axle Φ16×2 Φ16 Flat Washer Φ16 Dome Cap Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL...
- Page 26 FM4DDE-MUL Exploded Diagram (Electric) 6 6 6 7 7 7 7 7 7 8 8 8 Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL...
- Page 27 Flat Washer Φ8×1.6 Nut M6 M3 x 60 Discharge Chute Safety Bolt M3 Discharge Chute Safety Nut Flat Washer Φ6×1.0 Base Wheel Front Foot Rubber Cap Split Pin 1.6×20 Axle Φ16×2 Φ16 Flat Washer Φ16 Dome Cap Forest Master Model: FM6DD-MUL/FM6DDES-MUL/FM4DDE-MUL...
- Page 28 The latest version of the handbook and FAQ can be found on our website at https://forest- master.com/resources/ Manufactured for Forest Master Limited. Registered Office: Forest Master Ltd, Industry Road, Heaton, Newcastle Upon Tyne, NE6 5XB, United Kingdom. Tel: +44 191 2966939 - email: info@forest-master.com - web: www.forest-master.com...