Champion Simplex Operation & Service Manual page 3

MCGUIRE AIR COMPRESSORS INC
Safety and Operation Precautions
Safety is everybody's business and is based on your use of good common sense. All situations or circumstances
cannot always be predicted and covered by established rules. Therefore, use your past experience, watch out for
safety hazards and be cautious. Some general safety precautions are given below:
REFER TO THE COMPRESSOR OPERATION & SERVICE MANUAL FOR ADDITIONAL IMPORTANT SAFETY
Failure to observe these notices will result in injury to or death of personnel.
 Keep fingers and clothing away from rotating fan, drive coupling/belting, etc.
 Disconnect the compressor unit from its power source, lockout and tagout before working on the unit –
this machine is automatically controlled and may start at any time.
 Do not loosen or remove the belt covers, or break any connections, etc., in the compressor air system
until the unit is shut down and the air pressure has been relieved.
 Electrical shock can and may be fatal.
 Perform all wiring in accordance with the National Electrical Code (NFPA-70) and any applicable local
electrical codes. Wiring and electrical service must be performed only by qualified electricians.
 Open main disconnect switch, lockout and tagout and check for voltage before working on the control.
Failure to observe these notices could result in damage to equipment.
 Stop the unit if any repairs or adjustments on or around the compressor are required.
 Do not use the air discharge from this unit for breathing unless used in accordance with NFPA99
compliant Level 1 Medical Air Supply and Filtration Systems.
 An Excess Flow Valve should be on all compressed air supply hoses exceeding 1/2 inch inside diameter
(OSHA Regulation, Section 1926.302).
 Do not exceed the rated maximum pressure values shown on the nameplate.
 Do not operate unit if safety devices are not operating properly. Check periodically. Never bypass safety
devices.
Simplex Control Panel
Operation & Service
MCGUIRE AIR COMPRESSORS INC
INFORMATION.
3
1-888-229-9999
CQF3475 v.02
August 06, 2019
1-888-229-9999