Page 1
Operator’s Manual Manual del Operario Questions? Help is just a moment away! 030242 Preguntas? La ayuda es justa un momento lejos! Call: Generator Helpline (6200W) Llame: Línea Directa del Generador 1-800-743-4115 M-F 8-5 CT web: BRIGGSandSTRATTON.COM ADVERTENCIA WARNING Before using this product, read this manual and follow Antes de utilizar el producto, lea este manual y siga all Safety Rules and Operating Instructions.
Briggs & Stratton Power Products Group, LLC. 6200W Portable Generator SAFETY RULES This is the safety alert symbol. It is used to alert you to potential personal injury hazards.
Page 3
6200W Portable Generator Using a generator indoors WILL KILL YOU IN MINUTES. Exhaust contains carbon monoxide, a poison gas you cannot see or smell. NEVER use in the home ONLY use outdoors and or in partly enclosed far from open windows, areas such as garages.
Page 4
• DO NOT allow unqualified persons or children to operate or service generator. 6200W Portable Generator WARNING Running engines produce heat. Temperature of muffler and nearby areas can reach or exceed 150°F (65°C).
Page 5
6200W Portable Generator WARNING Unintentional sparking can result in fire or electric shock. WHEN ADJUSTING OR MAKING REPAIRS TO YOUR GENERATOR • Disconnect the spark plug wire from the spark plug and place the wire where it cannot contact spark plug.
Battery Float Charger — Use battery float charger jack to keep the starting battery charged and ready for use. Choke Lever — Used when starting a cold engine. 6200W Portable Generator Start Button Battery Float Charger Circuit Breakers (AC) — Push-to-reset circuit breakers are provided to protect generator against electrical overload.
6200W Portable Generator ASSEMBLY Your generator requires some assembly and is ready for use after it has been properly serviced with the recommended oil and fuel. If you have any problems with the assembly of your generator, please call the generator helpline at 1-800-743-4115.
Hex Nut Support Leg Vibration Mount Capscrew 6200W Portable Generator 5. Install e-ring with pliers, squeezing from top of e- ring to bottom of axle. CAUTION E-rings can cause eye injury. E-rings can spring back and become airborne when installing or removing.
6200W Portable Generator BEFORE STARTING THE ENGINE Add Engine Oil • Place generator on a level surface. • Refer to engine operator’s manual and follow oil recommendations and instructions. CAUTION Any attempt to crank or start the engine before it has been properly filled with the recommended oil will result in equipment failure.
• DO NOT handle generator or electrical cords while standing in water, while barefoot, or while hands or feet are wet. • DO NOT allow unqualified persons or children to operate or service generator. 6200W Portable Generator Generator Location Generator Clearance WARNING Exhaust heat/gases can ignite combustibles, structures or damage fuel tank causing a fire.
6200W Portable Generator OPERATING THE GENERATOR Starting the Engine IMPORTANT: Always unplug the battery float charger before starting the generator. Disconnect all electrical loads from the generator. Use the following start instructions: Make sure unit is on a level surface.
6,200 watts of power (6.2 kW) at 25.8 Amps for 120 Volts or 240 Volts. The outlet is protected by a push–to–reset circuit breaker. 6200W Portable Generator 120 Volt AC, 20 Amp, Duplex Receptacle Each duplex receptacle (Figure 7) is protected against overload by a push–to–reset circuit breaker.
6200W Portable Generator DON'T OVERLOAD GENERATOR Capacity You must make sure your generator can supply enough rated (running) and surge (starting) watts for the items you will power at the same time. Follow these simple steps: Select the items you will power at the same time.
Cooling air slots in the generator must not become clogged with snow, leaves or any other foreign material. 6200W Portable Generator NOTE: DO NOT use a garden hose to clean generator. Water can enter engine fuel system and cause problems.
6200W Portable Generator STORAGE The generator should be started at least once every seven days and allowed to run at least 30 minutes. If this cannot be done and you must store the unit for more than 30 days, use the following guidelines to prepare it for storage.
Generator will not start; or starts and runs rough. Generator shuts down during operation. Generator lacks power. 6200W Portable Generator Cause One of the circuit breakers is open. 2. Fault in generator. 3. Poor connection or defective cord set.
Effective February 1, 2006 replaces all undated Warranties and all Warranties dated before February 1, 2006 Briggs & Stratton Power Products Group, LLC will repair or replace, free of charge, any part(s) of the portable generator that is defective in material or workmanship or both. Transportation charges on product submitted for repair or replacement under this warranty must be borne by purchaser.
CONSERVE ESTAS INSTRUCCIONES TABLA DE CONTENIDOS Reglas De Seguridad ......18-20 Conozca Su Generador ......21 Montaje .
Page 19
Generador Portátil de 6200W El usar un generador en espacios interiores le causará la muerte en unos minutos. Los gases de combustión contienen monóxido de carbono, un gas venenoso que usted no puede ver ni oler. NUNCA lo use dentro SOLO úselo al aire libre del hogar ni en lugares y lejos de ventanas...
Page 20
ADVERTENCIA El rápido repliegue del cable del arrancador (retroceso) impedirá que el usuario suelte el cable a tiempo y tirará de su mano y brazo hacia el motor. Como resultado, podrían producirse fracturas, contusiones o esguinces. • Cuando arranque el motor, tire lentamente del cable hasta sentir una resistencia y, a continuación, tire rápidamente de él para evitar su retroceso.
Generador Portátil de 6200W CONOZCA SU GENERADOR LEA ESTE MANUAL DEL OPERARIO Y LAS REGLAS DE SEGURIDAD ANTES DE OPERAR SU GENERADOR. Compare las ilustraciones con su Generador para familiarizarse con las ubicaciones de los diferentes controles y ajustes. Conserve este manual para referencias futuras. Tapa del Depósito del Aceite Tanque de Combustible...
MONTAJE Su generador requiere de ciertos procedimientos de montaje y solo estará listo para ser utilizado después de haberle suministrado servicio con el combustible y aceite recomendados. Si usted tiene problemas con el montaje de su generador, por favor llame a la línea de ayuda para generadores al 1-800-743-4115.
Generador Portátil de 6200W Instale el Juego de Ruedas El juego de ruedas está diseñado para mejorar el transporte del generador. NOTA: Este Juego de Ruedas no ha sido diseñado para ser usado en la carretera. Necesitará las siguientes herramientas para instalar estos componentes: •...
ANTES DE DARLE ARRANQUE AL MOTOR Agregar Aceite al Motor • Coloque la generador sobre una superficie nivelada. • Consulte el manual del operario del motor para añadir al motor el aceite recomendado. PRECAUCIÓN Cualquier intento para arancar el motor antes de haberle proporcionado el mantenimiento apropiado con el aceite recomendado, podría ocasionar la falla del motor.
Generador Portátil de 6200W USO DEL GENERADOR Tierra del Sistema El generador dispone de una conexión a tierra del sistema que conecta los componentes del bastidor a los terminales de tierra de los enchufes hembra de salida de CA. La tierra del sistema está...
OPERANDO EL GENERADOR Encienda el Motor IMPORTANTE: Desenchufe siempre el cargador de flotación de la batería antes de arrancar el generador. Desconecte todas las cargas eléctricas del generador. Use las siguientes instrucciones para encender: Asegúrese de que la unidad está en una superficie plana.
Generador Portátil de 6200W Parado Del Motor Gire legos y desconecte todas las cargas eléctricas de los tomaco-rrientes del panel del generador. NUNCA de arranque o detenga el motor con todos los dispositivos eléctricos conectados y encendidos. Deje que el motor funcione sin cargas por algunos minutos para estabilizar las temperaturas internas del motor y el generador.
Page 28
NO SOBRECARGUE GENERADOR Capacidad Usted debe asegurarse que su generador puede proveer el suficiente vataje calificado (cuando esté funcionando) y de carga (al encender) para los aparatos a los cuales va a proveer la energía, al mismo tiempo. Siga estos pasos: Seleccione los aparatos que recibirán la energía, al mismo tiempo.
ALMACENAMIENTO El generador deberá ser encendido al menos una vez cada siete días y deberá dejarlo funcionar al menos durante 30 minutos. Si no puede hacer esto y debe almacenar la unidad por más de 30 días, siga las siguientes instrucciones para preparar su unidad para almacenamiento.
Generador Portátil de 6200W DIAGNOSITICOS DE AVERÍAS Problemo El motor está funcionando pero no existe salida de AC disponsible. El motor funciona bien sin carga pero "funciona mal" cuando se le contectan cargas. El motor no se enciende; o se enciende y funciona mal.
POLÍTICA DE GARANTÍA PARA EL PROPIETARIO DE GENERADOR PORTÁTIL BRIGGS & STRATTON POWER PRODUCTS GROUP, LLC Fecha de entrada en vigor:1 de Febrero de 2006. Sustituye a todas las garantías sin fecha y a las de fecha anterior al 1 Febrero de 2006 Briggs &...