Ezzy DUO 2000 Quick Start Manual

Rigging:

1) Slide the mast through the luff sleeve. Note: slide

the mast above the cams (do not attach the cams to the

mast yet).

slide the mast above the cams.

2) Attach the mast extension and thread the line through

the cleat. Do not tension the downhaul yet, just cleat the

line off.

3) Attach the front of the boom to the mast and

outhaul the sail to the boom length that is printed on

the sail. The suggested boom length is measured from

the clew to the front of the mast at the center of the boom

cutout.

4) Attach the cams to the mast by pushing down on the

batten with the palm of your hand, approximately 12" (30

cm) from the luff sleeve, and snap the cam onto the mast

with your other hand.

Tuning Guide for the 2000 Ezzy Duo and Duo Plus

EZZY DUO 2000

SAIL TUNING

If the cam is difficult to put onto the mast,

check that the batten tension webbing is

loosened until the

Page 1

Velcro

™ touches the

Table of Contents

Do you have a question about the DUO 2000 and is the answer not in the manual?

Page 1 Tuning Guide for the 2000 Ezzy Duo and Duo Plus EZZY DUO 2000 SAIL TUNING Rigging: 1) Slide the mast through the luff sleeve. Note: slide the mast above the cams (do not attach the cams to the mast yet).
Page 2 Tuning Guide for the 2000 Ezzy Duo and Duo Plus Velcro loosened until the ™ touches the buckle. This will allow the cam to slide further from the mast and will make it easier to get the cam onto the mast. Also,...
Page 3 Tuning Guide for the 2000 Ezzy Duo and Duo Plus Check that batten tension on the screw-batten tensioners is correct. YOUR BATTEN TENSIONERS HAVE BEEN SET AT THE FACTORY AND SHOULD ONLY NEED SLIGHT ADJUSTING. When correctly tensioned, there should be no wrinkles running across the batten pockets. If the battens do need adjusting, use the screwdriver key that is stored at the tack of your sail and tighten the battens until the wrinkles through the batten pocket disappear.
Page 4 Tuning Guide for the 2000 Ezzy Duo and Duo Plus 7) Roll sail beginning from the head, and tuck in the mast pad horizontally. 8) Insert the sail into the sail bag with the sleeve-end first. Sail Care: Sunlight: Sunlight will break down all sailcloth in a relatively short time (300 hours of direct sunlight).
Page 5 Tuning Guide for the 2000 Ezzy Duo and Duo Plus Sail feels heavy: 1) Leech is too tight, try more downhaul. 1) Sail is too deep, try more outhaul and downhaul. Sail feels too powerful: 2) Mast is too stiff, check that you are using the correct mast.