Advertisement
Quick Links
MultiDos HighSpeed 37000
Vloeistof Doseersysteem
Liquid Dosing system
Flüssigkeit Dosiersystem
Liquide Systeme de dosage
EN
Installation and operating instructions
Item number: 010-123-000
Date: August 2018
Doetinchem,
Version 2 - Translation of original instructions for use
The Netherlands
According to Annex VllA of machine directive 2006/42/EG, for completed machinery
www.hanskamp.nl/en
Advertisement
Subscribe to Our Youtube Channel
Related Manuals for Hanskamp MultiDos HighSpeed 37000
Summary of Contents for Hanskamp MultiDos HighSpeed 37000
- Page 1 MultiDos HighSpeed 37000 Vloeistof Doseersysteem Liquid Dosing system Flüssigkeit Dosiersystem Liquide Systeme de dosage Installation and operating instructions Item number: 010-123-000 Date: August 2018 Doetinchem, Version 2 - Translation of original instructions for use The Netherlands According to Annex VllA of machine directive 2006/42/EG, for completed machinery...
-
Page 2: Manual Contents
All information in this manual has been compiled with care. Hanskamp shall not be lia- ble for errors or faults in this manual. The recommendations are meant to serve as guidelines. - Page 3 Doseersysteem -Dosing system – Dosiersystem – Systeme de dosage Introduction MultiDos HighSpeed by Hanskamp, a proven, sustainable technique enabling you to very easily dose the right quantity of liquids per day and per cow. Smart, fast and affordable. MultiDos HighSpeed doses liquid propylene glycol like gravy on top of the feed chunks.
- Page 4 • Only use approved spare parts, and make sure they are only installed by authorized technicians. 4 - 20 Hanskamp AgroTech B.V. (The Netherlands) www.hanskamp.nl/en...
- Page 5 Before the electrical supply is attached to the MultiDos HighSpeed, make sure all parts are tight and that all the parts are in good condition. • Contact your nearest milking equipment dealer if you have any questions. 5 - 20 Hanskamp AgroTech B.V. (The Netherlands) www.hanskamp.nl/en...
- Page 6 General safety messages appear in this safety messages section. Specific safety messages are in applicable parts of this manual when potential hazards may occur if the instructions or procedures are not followed. 6 - 20 Hanskamp AgroTech B.V. (The Netherlands) www.hanskamp.nl/en...
-
Page 7: Installation Instruction
Do not use any solvents or abrasives that could damage the safety stickers. • Replace missing or illegible safety stickers. • Safety stickers are obtainable from Hanskamp. Always specify the item numbers in correspondence. 7 - 20 Hanskamp AgroTech B.V. (The Netherlands) www.hanskamp.nl/en... -
Page 8: Wall Mount Assembly
4. Attach the wall mount (fixings not included). Distance between the tube and the plate: ± 8mm 8 - 20 Hanskamp AgroTech B.V. (The Netherlands) www.hanskamp.nl/en... - Page 9 Caution! Turning the rotor by hand can cause minor injuries to the hand. Note: Hanskamp only guarantees correct operation if the suction hose is 2 metres or less. Note: PVC hose is not suitable for acids. A hose kit suitable for acids can be ordered from Hanskamp upon request.
- Page 10 Bend the HanskampQualityTube into the shape of the pump housing as much as possible (figure 12). Suction hose Art. no.: 082-254-100 Pressure tube Art. no.: 082-254-100 10 - 20 Hanskamp AgroTech B.V. (The Netherlands) www.hanskamp.nl/en...
- Page 11 If the HanskampQualityTube is worn out (leaky) due to intensive use, replace it according to the prescribed steps. An over- hauling set is available from Hanskamp. Check the rollers and bearings for wear as well. These are also available from Hanskamp if necessary.
- Page 12 No part of this publication may be reproduced or made public without prior permission in writing from Hanskamp AgroTech BV. Although this publication was put together with the utmost care, Hanskamp AgroTech is not liable for any damage that might arise due to errors or gaps in this publication.
- Page 13 Leaking feed-through coupling Hose too loose on the cou- Mount a hose clamp (art. No. 3547) on the pling coupling/hose 13 - 20 Hanskamp AgroTech B.V. (The Netherlands) www.hanskamp.nl/en...
- Page 14 The Netherlands, Doetinchem 15-09-2015 H.J. Hanskamp 14 - 20 Hanskamp AgroTech B.V. (The Netherlands) www.hanskamp.nl/en...
- Page 15 Attention! Always mount the nozzle vertically. 003-533-001 Shielded installation Hole distances 003-533-000 Note: the liquid must not be dosed over the nose of the cow. Shielded installation; cow can’t reach nozzle. 15 - 20 Hanskamp AgroTech B.V. (The Netherlands) www.hanskamp.nl/en...
- Page 16 3 = Blue 4 = Red 5 = Orange Example: Art. Nr.: 037-323-000 = • A MultiDos HighSpeed 200RPM 24VDC • Consists of 1 pump; • Built in blue wall mount cover 16 - 20 Hanskamp AgroTech B.V. (The Netherlands) www.hanskamp.nl/en...
- Page 17 Frictional drag due to improper maintenance or wearing of rollers and guides. Twisting, kinking, or excess lengths of the HanskampQualityTube installed in the MultiDos HighSpeed. Wall thickness and thickness variation. 17 - 20 Hanskamp AgroTech B.V. (The Netherlands) www.hanskamp.nl/en...
- Page 18 Carefully set up and monitor each of the foregoing variables during use of the HanskampQualityTube in the MultiDos HighSpeed. Read and heed the instructions of Hanskamp (manufacturer) or (milking machine) dealer of the apparatus, the MultiDos HighSpeed, regarding HanskampQualityTube installation, pump rollers, guide rollers and supply channel maintenance and cali- bration.
- Page 19 003-540-000 Wall mount MultiDos HS green with 3 inserts 003-541-000 Wall mount MultiDos HS bleu with 3 inserts 003-542-000 Wall mount MultiDos HS red with 3 inserts 003-543-000 Wall mount MultiDos HS orange with 3 inserts 19 - 20 Hanskamp AgroTech B.V. (The Netherlands) www.hanskamp.nl/en...
- Page 20 Doseersysteem -Dosing system – Dosiersystem – Systeme de dosage Hanskamp AgroTech B.V. Broekstraat 17 7009 ZB Doetinchem The Netherlands Tel: +31 (0)314 - 393 797 Fax: +31 (0)314 - 393 826 www.hanskamp.nl/en info@hanskamp.nl 20 - 20 Hanskamp AgroTech B.V. (The Netherlands) www.hanskamp.nl/en...
Need help?
Do you have a question about the MultiDos HighSpeed 37000 and is the answer not in the manual?
Questions and answers