Page 1
Æ ISLA IM-H Multi-Deck Display Hot Merchandisers Installation & Operation Manual Shipped with Technical Data Sheets September 2020 I/O Manual for IM-H...
Page 2
The information contained in this document is the property of Hussmann Corporation and shall not be used in whole or in part without written permission. This manual was written in accordance with originally prescribed equipment that is subject to change.
Check your shipment for any possible shortages of material. If a shortage should exist and is found to be the responsibility of Hussmann, notify Hussmann. If such a shortage involves the carrier, notify the carrier immediately, and request an inspection. Hussmann will acknowledge shortages within ten days from receipt of equipment.
REVISION B Updated to new template based on s-Series model Original Issue August 31, 2018 This warning does not mean that Hussmann products will cause cancer or reproductive harm, or is in violation of any product-safety standards or INSTALLATION TOOL LIST requirements.
2) NOTE: CASES MUST BE GROUNDED 3) NOTE: LED LIGHTS ARE NOT AVAILABLE ON HOT CASES AT THIS TIME. 4) NOTE: FOR TOTAL ELECTRICAL LOADS ADD LIGHT AMPS HOT LEVEL AMPS. IM-H U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
(3) sides and the top of the crate. the merchandiser. 3. Then unscrew/remove the nails from around the base of the crate (frame), releasing it from Hot Merchandiser the skid. ISLA IM-H HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
SOLVE MOST HINGE OPERATION PROBLEMS. Note: A. To avoid removing concrete flooring, begin lineup leveling from the highest point of the store floor. B. When wedges are involved in a lineup, set them first. IM-H U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
The Bumper and Price Tag Extrusion should only be serviced by a trained installation professional. Incorrect servicing will result in damage. Close-offs are shipped loose and must be assembled by installer. Hot Merchandiser ISLA IM-H HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
Page 10
The end body panels will encapsulate the side panels Note that lower side of the lower body panels must be properly placed around mounting surface to ensure proper fit. IM-H U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
6. Never drag or push the ISLA by ANY COMPONENT including ANY GLASS COMPONENT. This will result in damage to the base, and possibly damage to other components 7. Evenly support the entire base structure on rollers or dollies before attempting to move. Hot Merchandiser ISLA IM-H HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
Page 12
9. If using Floor-jacks or Bottle-jacks, use the recommended lifting points located at the underside of the case • These points will be visible channels • Lift simultaneously to place dollies or rolle IM-H U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
Page 13
• These surfaces are intended for the storage and merchandising of food products • Use a ladder or designed structure to work above the case PRICE TAG EXTRUSION BUMPER LOWER BODY PANELS BOTTOM BODY PANELS Hot Merchandiser ISLA IM-H HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
“Wiring Diagram” section, but always check the serial plate. BALLAST LOCATION Ballasts are located within the access panel that runs the length of the top of the case IM-H U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
Page 15
IM-H Electrical (Cont'd) Shelf Connectors Junction Box Location LIGHT RECEPTACLE (LEFT SIDE OF CASE) BOTTOM FRONT CENTER POWER/SENSOR RECEPTACLES (RIGHT SIDE OF CASE) Hot Merchandiser ISLA IM-H HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
PLATED MEALS 140° - 165°F pre-heated foods are being loaded into the case. VEGETABLES 160° - 175°F • Shelves are pre-set to 185°F, suitable for many food and container types. IM-H U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
Three Shelf Control Panel Power ON/OFF Switch Four Shelf Control Panel Digital Temperature Controller Five Shelf Control Panel Controller temperature indicates *SHELF-temperature only (not product temperature) Hot Merchandiser ISLA IM-H HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483 U.S.A.
AVOID the following: 1. Mechanical Abrasion Mechanical abrasion means those things that will scratch the steel’s surface. Steel pads, wire brushes, abrassive cleaners, and scrapers are prime examples. IM-H U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
Dispatch Hatco authorized service agent Main power switch on, but Open circuit. case is inoperative Dispatch Hatco authorized service agent Dispatch Hatco authorized service agent continued on next page... Hot Merchandiser ISLA IM-H HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483...
Page 79
Lamp needs to be replaced. and Operation Manual. * Only Florescent Lights on Light Switch needs to replaced. Dispatch Hatco authorized service agent shelves - O/H heating lamps not used with Heated Shelves IM-H U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
Hatco for assistance. HATCO CORPORATION P.O. Box 340500 Milwaukee, WI 53234-0500 U.S.A. (800) 558-0607 (414) 671-6350 Parts and Service Fax (800) 690-2966 International Fax (414) 671-3976 partsandservice@hatcocorp.com Hot Merchandiser www.hatcocorp.com ISLA IM-H HUSSMANN CORPORATION • BRIDGETON, MO 63044-2483...
To obtain warranty information or other support, contact your Hussmann representative. Please include the model and serial number of the product. Hussmann Corporation, Corporate Headquarters: Bridgeton, Missouri, U.S.A. 63044-2483 01 October 2012 IM-H U.S. & Canada 1-800-922-1919 • Mexico 1-800-890-2900 • www.hussmann.com...
Additional copies of this publication may be obtained by contacting: provide you with the correct parts and information for your particular Hussmann® Chino or going to our website unit. They can be found on a small metal plate on the unit.