Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for ALDI Auto XS FLX-KW-02
Summary of Contents for ALDI Auto XS FLX-KW-02
- Page 1 Original instructions COMPACT CAR JACK...
-
Page 3: Table Of Contents
Table of contents Overview ................4 Scope of delivery/parts ............4 General Information .............. 5 Read and store operating instructions ........ 5 Explanation of the symbols ............5 Safety ..................6 Intended use .................. 6 Safety information ................. 6 Initial start-up ................11 Check the car jack and scope of deliver ........11 General ....................11 Assembly of the car jack ............ -
Page 4: Overview
Parts Saddle (extension bolt) Stroke piston Pump body Handle holder Overload valve (under red plastic cover) Release valve Lower lever bar Upper lever bar Oil filling plug (not visible) -
Page 5: General Information
General Information GENERAL INFORMATION Read the instructions and keep them in a safe place These operating instructions apply to this compact car jack (hereinafter referred to as the “car jack”) and contain important information on its setup and use. Read these operating instructions carefully before using the car jack for the first time. -
Page 6: Safety
Safety Declaration of conformity (Chapter "Declaration of Conformity"): Products marked with this symbol comply with all applicable Community Regulations of the European Economic Area. The GS (Tested Safety) mark certifies that the product is safe when used correctly. The GS mark means that the safety of the product has been www.tuv.com ID 1111218466... - Page 7 Safety – Do not let children play with the packaging film. Children can become entangled therein while playing. – Keep children away from small parts. WARNING! Risk of personal injury! No persons or animals may be lifted with the car jack. This may result in serious injury or even death.
- Page 8 Safety CAUTION! Risk of personal injury! The user of this car jack must be fully familiar with the functions of the car jack, and the entire procedure to ensure safe operation before using the product. Failure to observe them may result in personal injury. –...
- Page 9 Safety – Do not use the car jack in damp indoor areas or in rain. – Do not store the car jack in a place where it could fall down. – Do not place any objects on the housing. – Do not load the car jack beyond the permissible load capacity specified in the operating instructions.
- Page 10 Safety – Never leave the car jack unattended during use. – Ensure that children keep sufficient distance from the car jack. – Children must not play with the car jack. – People with limited sensory or mental abilities should not be in the vicinity of the car jack.
-
Page 11: Initial Start-Up
Initial start-up – Do not use the car jack if the housing has cracks, deformations or fractures (see "Maintenance, Repair and Inspection"). Take the car jack out of service immediately and contact the manufacturer through the service centre indicated on the warranty card. -
Page 12: Assembly Of The Car Jack
Assembly of the car jack ASSEMBLY OF THE CAR JACK Mounting the lever bar 1. Connect the two parts of the lever bars with each other, and insert them into the handle holder. OPERATION OF THE CAR JACK WARNING! Do not work on or under the vehicle without knowing the exact function and mode of operation of the device! Before each use of the car jack, check that it is functioning properly, in particular that there is no leakage of hydraulic oil, that... -
Page 13: Lifting The Vehicle
Operating of the car jack Lifting the vehicle – Place the car jack underneath the vehicle to be lifted, under the respective car jack bracket (refer to your vehicle's owner's manual). Pump the lever bar until the saddle is just below the jacking point. -
Page 14: Troubleshooting
Troubleshooting TROUBLESHOOTING Problem Possible causes Remedy The car jack Release valve is open. Close the release valve by does not lift the turning it clockwise. vehicle / cannot Remove any dirt that lift load / cannot obstructs the safe closing lift load to full of the valve. -
Page 15: Maintenance, Repair And Inspection
Maintenance, repair and inspection Problem Possible causes Remedy Saddle moves Air in the hydraulic Remove the air from the slowly upwards system. hydraulic system. (without load). MAINTENANCE, REPAIR AND INSPECTION CAUTION! Damages and risks of injury! When the car jack is used in work areas where oil has leaked, the car jack may slip and cause material damage and/or personal injury. -
Page 16: Add Hydraulic Oil
Maintenance, repair and inspection Adding hydraulic oil – Position the car jack vertically. – Check that the car jack is completely lowered. If necessary, lower it as far as it will go. – Remove the filling plug from the housing (filling opening). –... -
Page 17: Cleaning And Storage
Claning and storage CLEANING AND STORAGE NOTICE Danger due to improper use! The car jack may be damaged by improper handling. – Do not use sharp cleaning agents, brushes with metal or nylon bristles, or pointed or metallic cleaning objects such as knives, scrapers made of hard materials, etc. -
Page 18: Technical Data
Technical Data TECHNICAL DATA Item No. FLX-KW-02 Max. load capacity 5,000 kg Min. height 195 mm Max. height 380 mm Lifting height 125 mm Height adjustable 0–60 mm Oil volume 117 ml Weight 3.3 kg Service life 5 years DISPOSAL Disposal of packaging Dispose of the packaging sorted by type. -
Page 19: Declaration Of Conformity
Declaration of conformity DECLARATION OF CONFORMITY... - Page 20 PRODUCED IN CHINA FOR: Aldi Stores Ltd. PO Box 26, Atherstone, Warwickshire, CV92SH. Aldi Stores (Ireland) Ltd.