Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Minuteman MC17000QP
Summary of Contents for Minuteman MC17000QP
- Page 1 Model: MC17000QP 170 Automatic 170 Automatic 170 Automatic 170 Automatic 170 Automatic MC17000-00CE Floor Scrubber Floor Scrubber Floor Scrubber , , , , , Floor Scrubber Floor Scrubber Batter Batter Batter y y y y y Batter Batter OPERATION SERVICE...
-
Page 3: Table Of Contents
TABLE OF CONTENTS Page Safety Instructions ..................1 Electrical Requirements ................2 Control Panel Identification ................. 3 Brush Installation Instructions ..............4 Operating Instructions/ Maintenance ............5 Main Polyethelene Components ..............6 - 7 Solution/Recovery Tank w/Pump ..............8 - 9 Vacuum Components .................. -
Page 4: Safety Instructions
IMPORTANT SAFETY INSTRUCTIONS CAUTION Operators must read and understand this manual before operating or maintaining this equipment. • Do not operate this scrubber in the red discharge area of the battery condition meter. Operating the scrubber for long periods in the red zone of the gauge will cause overheating of the motors and possible permanent damage to the batteries may result. -
Page 5: Electrical Requirements
ELECTRICAL REQUIREMENTS: This piece of equipment operates on 24 Volt DC. BATTERY REQUIREMENTS: 2 x 12V 80 Amp Hour 20 Hour Rate Deepcycle P/N 956721 2 x 12V 105 Amp Hour 20 Hour Rate Deepcycle P/N 956712 BATTERY SERVICE AND INSTALLATION: *Warning: Battery acid can cause burns. -
Page 6: Control Panel Identification
CONTROLS 1. Squeegee left lever 8. Vacuum recovery hose 2. Vacuum switch 9. Power assist control 3. Battery condition gauge 10. Foot pedal for lower/raising brush 4. Brush switch 11. Pump switch 5. Solution control lever 12. Auxiliary out 7. Drain hose for recovery tank... -
Page 7: Brush Installation Instructions
BRUSH REMOVAL Empty solution and recovery tanks. Disconnect batteries. Remove Squeegee assembly. Lower brush. Tilt machine as shown (figure 3) until machine rests on foot pedal. Brush has a snap-on push off clutch plate. Pushing brush away from the machine from the side, will release brush assembly. -
Page 8: Operating Instructions/ Maintenance
OPERATING INSTRUCTIONS 1. Filling: Fill the solution tank with the desired amount of water and add liquid cleaning solution to the proper dilution ratio. DO NOT USE powdered cleaning chemicals. Powders are unlikely to dissolve thoroughly, resulting in clogging the in-line solution filter. This can reduce or stop water flow to the brush. -
Page 9: Main Polyethelene Components
Main Components... - Page 10 Parts List Item Part No. Qty. Description 430000MCH Base Assy. 17 B/E Machined 430001MCH 170 Sol/Recovery Tank Assy. 430002 Cover Poly 170 Burgundy 430044 Hinge Lid 17 B/E 430046 Side Skirt Retainer 17 430049 Splash Skirt 17 B/E 430126 Hinge Backing Plate 430136 Gasket Seal Kit (4) 430141...
-
Page 11: Solution/Recovery Tank W/Pump
Tank Assembly... - Page 12 Parts List Item Part No. Qty. Description 130118 Solution Strainer 200173 Float Housing 210401 Solution Hose 210409 Fitting Brass 3/8 MPT 3/8 FPT 210410 Fitting Brass 3/8 FPT 3/8 Barb 210414 O Ring 2-113 290203 Hose Clamp 430001MCH 170 Sol/Recovery Tank 430037 Bumper Wheel Axle 430038...
-
Page 13: Vacuum Components
740063 VAC MTR 24V 27A 740429 VAC MTR (220V) USED ON 115V MODEL 27B 740943 VAC MTR (240V) SINGLE STAGE EXPORT... - Page 14 Parts List Item Part No. Qty. Description 250041 Seal, Rubber 831001 Crimp Clamp 440R 290017 Molded Vac Motor Gasket 430018 Z Bracket 430029 Caster 430042 Caster Mounting Bracket 430138-1 Wheel 6” 430069 Vacuum Manifold Assembly 828264 Spring Washer Cup 430099 Vacuum Hose 450038 Z Bracket...
-
Page 15: Brush Drive Assemblies
Brush Drive Assembly... -
Page 17: Squeegee Assembly
Squeegee Assembly... - Page 18 Parts List Item Part No. Qty. Description 430033 Battery Tray 430039SP Dashboard 170 Screen Printed 430039CESP Dashboard 170CE Screen Printed 430052 Squeegee Lift Cable Assy 430053 Solution Control Cable A 430059 Squeegee Lift Brkt Assy 430060 Squeegee Lift Arm Assy 430070 Squeegee Mount Assy 430073...
-
Page 19: Wiring Diagram
Wiring Diagram CE Version... - Page 20 Wiring Diagram Standard Version...
-
Page 21: Limited Warranty
Minuteman International, Inc. warrants to the original purchaser/user that this product is free from defects in workmanship and materials under normal use and service for a period of three years from date of purchase. In addition, Minuteman International, Inc. will, at its option, honor labor warranty claims for the first 12 months from date of sale, provided such claims are submitted through and approved by factory authorized repair stations.