All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by SaS/WS 1161 BU TV Consumer Care, the Netherlands...
2.1 Technical Specifications 2.2 Directions for Use Directions for use can be downloaded from the following 2.3 Connections websites: 2.4 Chassis Overview http://www.philips.com/support http://www.p4c.philips.com Notes: • Figures can deviate due to the different set executions. • Specifications are indicative (subject to change).
Page 3
Technical Specifications, and Connections TPN1.1E LA EN 3 Connections 18860_001_100427.eps 100531 Figure 2-1 Connection overview Note: The following connector colour abbreviations are used - Data (+) (acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green, - Ground Gy= Grey, Rd= Red, Wh= White, Ye= Yellow. 2 - Head phone (Output) 80 - 600 ...
Page 4
EN 4 TPN1.1E LA Technical Specifications, and Connections 2.3.2 Rear Connections 14 - Ground P50 / 75 15 - Video Red/C 0.7 V 16 - Status/FBL 0 - 0.4 V: INT 4 - HDMI: Digital Video, Digital Audio - In 1 - 3 V: EXT / 75 ...
3.3.3 Spare Parts external damage. • Check the strain relief of the Mains/AC Power cord for For the latest spare part overview, consult your Philips Spare proper function. Part web portal. • Check the electrical DC resistance between the Mains/AC...
Page 6
EN 6 TPN1.1E LA Precautions, Notes, and Abbreviation List The third digit in the serial number (example: Abbreviation List AG2B0335000001) indicates the number of the alternative B.O.M. (Bill Of Materials) that has been used for producing the 0/6/12 SCART switch control signal on A/V specific TV set.
Page 7
6.5 MHz. L' is Band (VESA standard for communication I, L is all bands except for Band I channel and display). Using E-DDC, LG.Philips LCD (supplier) the video source can read the EDID Loudspeaker information form the display.
Page 8
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4- wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
Mechanical Instructions TPN1.1E LA EN 9 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assembly/Panel Removal 4.4 Set Re-assembly.
Page 10
EN 10 TPN1.1E LA Mechanical Instructions 18860_102_100428.eps 100428 Figure 4-2 Cable dressing (22") 2011-Jan-21...
Page 11
Mechanical Instructions TPN1.1E LA EN 11 18860_103_100428.eps 100601 Figure 4-3 Cable dressing (26") Service Positions For easy servicing of a TV set, the set should be put face down on a soft flat surface, foam buffers or other specific workshop tools.
Page 12
EN 12 TPN1.1E LA Mechanical Instructions 4.3.2 Small Signal Board (SSB) Caution: it is mandatory to remount all different screws at their Push down original position during re-assembly. Failure to do so may result in damaging the SSB. 1. Release the tape from near the bottom side of the set from the SSB shielding.
Page 13
Mechanical Instructions TPN1.1E LA EN 13 4.3.7 Keyboard Control Panel Set Re-assembly Refer to Figure 4-8. To re-assemble the whole set, execute all processes in reverse 1. Unplug the connector [1] on the IR/LED board that leads to order. the Local Control board, as it is not unplug-able at the Local Control board itself (soldered connector).
EN 14 TPN1.1E LA Service Modes, Error Codes, and Fault Finding 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: 5.1 Service Modes 5.2 Service Tools 5.3 Software Upgrading 5.4 Error Codes 5.5 Fault Finding and Repair Tips Service Modes The Customer Service Mode (CSM) is used for communication between the call centre and the customer, while the Service...
Page 15
Figure 5-4 Example of SAM Table 5-1 Contents of SAM Default Value Action Items Range 19" 22" 26" Description Brand PHILIPS PHILIPS PHILIPS brand customer TPN1 1E 2.01 TPN1 1E 2.01 TPN1 1E 2.01 software version Date Apr 21 2010...
Page 16
Introduction Introduction Philips continuously tries to improve its products, and it’s ComPair (Computer Aided Repair) is a Service tool for Philips recommended to update the TV software when updates are Consumer Electronics products. and offers the following: available. Software update files can be downloaded from the 1.
Page 17
Service Modes, Error Codes, and Fault Finding TPN1.1E LA EN 17 buffer, it is displayed at the left side and all other errors shift one position to the right. Basically there are three kinds of error codes: Error Code Event No problem C bus error Tuner error...
EN 18 TPN1.1E LA Alignments 6. Alignments Index of this chapter: Process 6.1 General Alignment Conditions 1. Press the following key sequence on the remote control 6.2 Hardware Alignments transmitter: “0 6 2 5 9 6 INFO”, see Figure 6-2. 6.3 Auto Colour for ADC Calibration 2.
Page 19
Alignments TPN1.1E LA EN 19 Table 6-1 The 1931 CIE chromaticity (x, y) by CS-200 • Restore the initial picture settings after the alignments. Table 6-3 White tone default settings Picture Mode 0.276 0.010 0.282 0.010 Normal (9000K) 0.287 0.010 0.296 0.010 Colour temperature Cool (11000K)
EN 20 TPN1.1E LA Circuit Descriptions 7. Circuit Descriptions Index of this chapter: Introduction 7.1 Introduction 7.2 Power Architecture The TPN1.1E LA chassis is using the NT72632 for main processing. Notes: • Only new circuits (circuits that are not published recently) 7.1.1 TPN1.1E Architecture Overview are described.
Page 21
Circuit Descriptions TPN1.1E LA EN 21 7.1.2 SSB Cell Layout DC/DC DIGITAL I/O NT72632 AUDIO CLA SS - D TUNER ANALOG I/O ANALOG I/O DIGITAL I/O SERVICE CONNECTOR 18860_207_100507.eps 100531 Figure 7-2 SSB layout cells (top view) 2011-Jan-21...
Page 22
EN 22 TPN1.1E LA Circuit Descriptions Power Architecture Refer to figure Figure 7-3 for the power architecture of this platform (DC/DC power conversion). +5V_STBY +3.3V_STBY VDD1V2_STBY G903T63UF G912T63U U7203 U7204 FLASH U4205 NVT72633 U4101 SC189 +1V2_ON U7209 SI4835 +5V_ON +3V3_ON G5657F Q7106 U7210...
IC Data Sheets TPN1.1E LA EN 23 8. IC Data Sheets This section shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic” ICs).
Page 24
EN 24 TPN1.1E LA IC Data Sheets Pinning information Name Name Name Name MDQ1 SAR_ADC1 AUD_VDD VDD_33 MDQ6 SAR_ADC2 AUD_GND VDD_12 MDM0 SAR_ADC3 DAOUT_L0 I2SI_BCLK/ AGPIO24 I2SI_ADCDAT(I)/ MDQ12 STBC_RST DAOUT_R0 AGPIO54 VDD_DDR PW_EN/ AGPIO56 DAOUT_L1 I2SI_WS(I)/ AGPIO55 MDQ14 VGA_VS/ AGPIO60 DAOUT_R1 I2SO_DAT1/ AGPIO52 MDQ9...
Page 25
IC Data Sheets TPN1.1E LA EN 25 Pinning information RXA0- ADC0M I2SO WS/ AGPIO10 padbypass1 RXA0+ I2SO DAT0/AGPIO09 RXA1- LVDS_GND RXA1+ CVBS1 LVDS_B3+ RXA2- CVBS0 LVDS_B3- VDD_DDR RXA2+ FSADJ LVDS_BCLK+ MA11 GND_HDMI COMP LVDS_BCLK- HDMI_DDC_SCK/ VDD_TVDAC LVDS_B2+ MRAS# AGPIO16 HDMI_DDC_SDA/ TV_OUT LVDS_B2- AGPIO13...
Page 26
EN 26 TPN1.1E LA IC Data Sheets Diagram B19 SSB: DC-DC Power, G5657F12U (IC U7210) Block diagram Pull high Pull high 3µA 3µA UVLO UVLO 4V LDO 4V LDO & & Internal +4V Internal +4V REGULATOR REGULATOR ISEN ISEN REFERENCE REFERENCE SOFTSTART SOFTSTART...
Page 27
IC Data Sheets TPN1.1E LA EN 27 Diagram B05 SSB: Side input, TPA6132A2RTER 25mW QFN-16 (IC U1401) Block diagram HPVDD Supply 2.2 F Control PGND HPVDD INL- Resistor OUTL Array INL+ Short-Circuit HPVSS Protection Thermal HPVDD Protection INR- Resistor OUTR Array INR+ HPVDD...
Page 28
EN 28 TPN1.1E LA IC Data Sheets Diagram B17 SSB: Audio amplifier, AD82581B-TKG TQFN-48 12W (IC U6202) Block diagram Pinning information N.C. N.C. N.C. N.C. N.C. N.C. MCLK CLK_OUT N.C. DGND N.C. N.C. N.C. N.C. DVDD N.C. N.C. DVDD N.C. DGND SDATA 18860_304_100510.eps...
Styling Sheets TPN1.1E LA EN 61 11. Styling Sheets Styling Sheet 19" PICO 19" Pos No. Description Remarks FRONT CABINET REAR COVER STAND ASSY STAND NECK 1176 REMOTE CONTROL FOR ELECTRICAL PARTS/ASSEMBLIES SEE WIRING DIAGRAM CHAPTER 9 18840_800_100415.eps 100415 2011-Jan-21...
Styling Sheets TPN1.1E LA EN 62 Styling Sheet 22" PICO 22" Pos No. Description Remarks FRONT CABINET REAR COVER STAND ASSY STAND NECK 1176 REMOTE CONTROL FOR ELECTRICAL PARTS/ASSEMBLIES SEE WIRING DIAGRAM CHAPTER 9 18840_801_100415.eps 100426 2011-Jan-21...
Page 63
Styling Sheets TPN1.1E LA EN 63 Styling Sheet 26" PICO 26" SZ313 SZ317 Pos No. Description Remarks FRONT CABINET REAR COVER STAND ASSY STAND NECK For 26HFL3232D/10 only STAND NECK 1176 REMOTE CONTROL SZ308 FRONT CABINET For 26HFL3232D/10 only SZ313 REAR COVER For 26HFL3232D/10 only SZ317...