All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by SaS/WS 1065 BU TV Consumer Care, the Netherlands...
2.1 Technical Specifications 2.2 Directions for Use Directions for use can be downloaded from the following 2.3 Connections websites: 2.4 Chassis Overview http://www.philips.com/support http://www.p4c.philips.com Notes: • Figures can deviate due to the different set executions. • Specifications are indicative (subject to change).
Page 3
Technical Specifications, Connections TPM5.2E LA EN 3 Connections 18840_001_100323.eps 100428 Figure 2-1 Connection overview Note: The following connector colour abbreviations are used 3 - USB2.0 (acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green, Gy= Grey, Rd= Red, Wh= White, Ye= Yellow. 10000_022_090121.eps 2.3.1 Side Connections...
Page 4
EN 4 TPM5.2E LA Technical Specifications, Connections 5 - HDMI: Digital Video, Digital Audio - In - Audio L 0.5 V / 1 kΩ - Ground Audio - Ground Blue - Audio L 0.5 V / 10 kΩ / 75 Ω - Video Blue/C-out 0.7 V 10000_017_090121.eps - Function Select...
3.3.3 Spare Parts external damage. • Check the strain relief of the Mains/AC Power cord for For the latest spare part overview, consult your Philips Spare proper function. Part web portal. • Check the electrical DC resistance between the Mains/AC...
Page 6
EN 6 TPM5.2E LA Precautions, Notes, and Abbreviation List The third digit in the serial number (example: Abbreviation List AG2B0335000001) indicates the number of the alternative B.O.M. (Bill Of Materials) that has been used for producing the 0/6/12 SCART switch control signal on A/V specific TV set.
Page 7
6.5 MHz. L' is Band (VESA standard for communication I, L is all bands except for Band I channel and display). Using E-DDC, LG.Philips LCD (supplier) the video source can read the EDID Loudspeaker information form the display.
Page 8
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4- wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
Mechanical Instructions TPM5.2E LA EN 9 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assembly/Panel Removal 4.4 Set Re-assembly.
Page 10
EN 10 TPM5.2E LA Mechanical Instructions 18840_102_100324.eps 100324 Figure 4-2 Cable dressing (22") 2010-Jun-25...
Page 11
Mechanical Instructions TPM5.2E LA EN 11 18840_104_100324.eps 100324 Figure 4-3 Cable dressing (26") Service Positions For easy servicing of a TV set, the set should be put face down on a soft flat surface, foam buffers or other specific workshop tools.
Page 12
EN 12 TPM5.2E LA Mechanical Instructions 4.3.4 Speakers 1. Release the speaker cable from its clamps. 2. Unplug the speaker connector from the SSB. 3. Take the speakers out. When defective, replace the whole unit. Pull up 4.3.5 Stand removal Caution: it is mandatory to remount all different screws at their original position during re-assembly.
Page 13
Mechanical Instructions TPM5.2E LA EN 13 4.3.8 LCD Panel 1. Remove the SSB as described earlier. 2. Remove the PSU as described earlier. 3. Remove the speaker as described earlier. 4. Remove the stand as described earlier. 5. Release the tape that fix the Keyboard Control cable near the Keyboard Control panel.
EN 14 TPM5.2E LA Service Modes, Error Codes, and Fault Finding 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: 5.1 Service Modes 5.2 Service Tools 5.3 Software Upgrading 5.4 Error Codes 5.5 Fault Finding and Repair Tips Service Modes The Customer Service Mode (CSM) is used for communication between the call centre and the customer, while the Service...
Page 15
Service Modes, Error Codes, and Fault Finding TPM5.2E LA EN 15 5.1.2 Service Alignment Mode (SAM) Press “OK” to check the Version information of the software when you select the “0. F/W Version”. How to enter To enter the factory mode, use the following method: •...
Page 16
Service Tools 5.2.1 ComPair Introduction ComPair (Computer Aided Repair) is a Service tool for Philips Consumer Electronics products. and offers the following: 1. ComPair helps to quickly get an understanding on how to ComPair II Developed by Philips Brugge repair the chassis in a short and effective way.
Page 17
Software Upgrading 5.3.1 Introduction Philips continuously tries to improve its products, and we recommend that you update the TV software when updates are available. Software update files can be obtained from your dealer or can be downloaded from the following websites: http://www.philips.com/support...
Page 18
EN 18 TPM5.2E LA Service Modes, Error Codes, and Fault Finding Error Codes The error code buffer contains all errors detected since the last time the buffer was erased. The buffer is written from left to right. When an error occurs that is not yet in the error code buffer, it is displayed at the left side and all other errors shift one position to the right.
Alignments TPM5.2E LA EN 19 6. Alignments Index of this chapter: Alignment: 6.1 General Alignment Conditions 1. At SAM mode menu, select AUTO_COLOR item. Then 6.2 Hardware Alignments press “OK” key to adjust ADC_GAIN_R, ADC_GAIN_G, 6.3 YPbPr Mode display adjustment ADC_GAIN_B and ADC_OFFSET_R, ADC_OFFSET_G, 6.4 PC mode display adjustment ADC_OFFSET_B.
Page 20
EN 20 TPM5.2E LA Alignments PC mode display adjustment 6.4.1 Display quality adjustment Use the POPO (pixel on pixel off) pattern to adjust the clock until no stripe and adjust the phase until clear picture (“Auto” will be done every time switching to PC mode and mode change).
Page 21
Alignments TPM5.2E LA EN 21 Option Settings 6.5.1 Reset Options In SAM, after reset “Reset option code”, restart the set immediately. 6.5.2 Option Code Overview Table 6-3 Option code overview CTN_ALT BOM# Panel Type Panel ID 19PFL3405H/12_1 LG LC185EXN-SCA1 19PFL3405H/12_2 AUO M185XW01 V6 19PFL3405H/05_1 LG LC185EXN-SCA1...
EN 22 TPM5.2E LA Circuit Descriptions 7. Circuit Descriptions Index of this chapter: Introduction 7.1 Introduction 7.2 Power Architecture The TPM5.2E LA chassis is using the MT5363 main processor. Notes: 7.1.1 TPM5.2E Architecture Overview • Only new circuits (circuits that are not published recently) are described.
Page 23
Circuit Descriptions TPM5.2E LA EN 23 7.1.2 SSB Cell Layout AUDIO CLA SS - D COMMON INTERFACE DC/DC MT5363 ANALOG I/O TUNER DIGITAL I/O DIGITAL I/O ANALOG I/O S ERVICE CONNECTOR 18840_206_100406.eps 100428 Figure 7-2 SSB layout cells (top view) 2010-Jun-25...
Page 24
EN 24 TPM5.2E LA Circuit Descriptions Power Architecture Refer to figure Figure 7-3 for the power architecture of this platform (DC/DC power conversion). ” 6 18840_205_100324.eps 1004288 Figure 7-3 Power Architecture 7.2.1 Power Supply Unit All power supplies are a black box for Service. When defective, a new board must be ordered and the defective one must be returned, unless the main fuse of the board is broken.
IC Data Sheets TPM5.2E LA EN 25 8. IC Data Sheets This section shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic” ICs).
Page 26
EN 26 TPM5.2E LA IC Data Sheets Pinning information LT 1 RCLK0_ RDQ10 RDQ15 RDQS0_ RDQ14 RDQ12 AO1N AOCKN VCC2IO RCLK0 RDQ8 RDQS1 RDQS0 RDQ11 VCC2IO AO0N AO2N AO3N VCC2IO RDQ13 RDQS1_ DVSS RDQM1 VCC2IO AOCKP AO1P VCC2IO RDQ5 RDQ0 DVSS RDQ9 VCC2IO...
Page 27
IC Data Sheets TPM5.2E LA EN 27 Pinning information DVSS GPIO32 GPIO26 GPIO17 GPIO9 ETTXD3 ETRXCLK ETRXD1 ETRXDV ETCRS AO4P GPIO36 GPIO28 GPIO22 GPIO11 GPIO4 ETTXD1 ETRXD3 ETMDIO DVSS GPIO34 GPIO27 GPIO18 GPIO10 ETTXEN ETTXCLK ETRXER ETMDC DVSS GPIO30 GPIO20 GPIO12 GPIO6 ETTXD2...
EN 28 TPM5.2E LA IC Data Sheets Diagram B01 SSB: Power-1, MP9403 (IC U701) Block diagram CURRENT SENSE AMPLIFIER 0.95V RAMP OSCILLATOR 340KHz 0.3V CURRENT COMPARATOR ERROR 0.8V AMPLIFIER 6υA COMP 1.2V IN < 3.95V INTERNAL REGULATORS 1.3 V SHUTDOWN COMPARATOR Pinning information TOP VIEW...
Page 29
IC Data Sheets TPM5.2E LA EN 29 Diagram B12 SSB: Audio Amp/Headphone out, TPA6132A2RTER 25mW QFN-16 (IC U602) Block diagram HPVDD Supply 2.2 F Control PGND HPVDD INL- Resistor OUTL Array INL+ Short-Circuit HPVSS Protection Thermal HPVDD Protection INR- Resistor OUTR Array INR+...
Page 30
EN 30 TPM5.2E LA IC Data Sheets Diagram B12 SSB: Audio Amp/Headphone out, TPA3113D2PWPR 6W TSSOP-28 (IC U601) Block diagram GVDD PVCCL BSPL PVCCL PBTL Select OUTPL FB Gate Drive OUTPL OUTPL FB PGND LINP Gain PLIMIT Logic Control GVDD PVCCL LINN BSNL...
Page 56
Circuit Diagrams and PWB Layouts TPM5.2E LA EN 56 Layout IR/LED Board R201 R304 R301 C201 R203 ZD202 CN301 CN001 Bottom SPG1 18840_522_100408.eps 100428 2010-Jun-25...
Page 57
Styling Sheets TPM5.2E LA EN 57 11. Styling Sheets Styling Sheet 19" PICO 19" Pos No. Description Remarks FRONT CABINET REAR COVER STAND ASSY STAND NECK 1176 REMOTE CONTROL FOR ELECTRICAL PARTS/ASSEMBLIES SEE WIRING DIAGRAM CHAPTER 9 18840_800_100415.eps 100415 2010-Jun-25...
Page 58
Styling Sheets TPM5.2E LA EN 58 Styling Sheet 22" PICO 22" Pos No. Description Remarks FRONT CABINET REAR COVER STAND ASSY STAND NECK 1176 REMOTE CONTROL FOR ELECTRICAL PARTS/ASSEMBLIES SEE WIRING DIAGRAM CHAPTER 9 18840_801_100415.eps 100426 2010-Jun-25...
Page 59
Styling Sheets TPM5.2E LA EN 59 Styling Sheet 26" PICO 26" Pos No. Description Remarks FRONT CABINET REAR COVER STAND ASSY STAND NECK 1176 REMOTE CONTROL FOR ELECTRICAL PARTS/ASSEMBLIES SEE WIRING DIAGRAM CHAPTER 9 18840_802_100415.eps 100415 2010-Jun-25...