Related Manuals for Cool Energy EcoStore Series
Summary of Contents for Cool Energy EcoStore Series
- Page 1 Cool Energy EcoStore Heat Pump Water Heater EcoStore - Air Source Heat Pump Water Heater EcoStore P a g e...
- Page 2 Cool Energy EcoStore Heat Pump Water Heater INTRODUCTION Thank you for purchasing this equipment which will give many years trouble free use with the correct installation and care. In the unusual occurrence that problems occur with the installation or continued use please contact the installer in the first instance to provide all the backup required to ensure these products meet the high standard met by our products.
-
Page 3: Table Of Contents
Cool Energy EcoStore Heat Pump Water Heater INDEX GENERAL NOTICE ..........................04 ....................................04 IELD OF USE ..............................04 PRODUCT NAME……………………….. SAFETY INFORMATION………………………............................04 ...............................05 ERTIFICATIONS AND ARKINGS ..........................05 EANING OF THE SYMBOLS USED HEREIN .................................05 ELIVERY AND PACKAGING RANSPORT …… ..................................05 ....................................06 EASURING ................................06... - Page 4 Cool Energy EcoStore Heat Pump Water Heater 4.4.1 W ..............................17 EEKLY DISINFECT FUNCTION 4.4.2 V :..................................17 ACATION MODE 4.4.3 P ..............................17 OWER N AND POWER 4.4.4 L .................................17 OCK AND UNLOCK 4.4.5 Q ...................................18 UERY FUNCTION .....................................19 ETTING 4.5.1 T ................................19...
-
Page 5: General Notice
Cool Energy EcoStore Heat Pump Water Heater GENERAL NOTICE Field of use The heat pump water heater for the production of hot water is only intended to be used for sanitary water heating, without exceeding the usage restrictions specified herein. To this purpose it must be hydraulically connected to a sanitary water delivery network. -
Page 6: Certifications And Markings
Cool Energy EcoStore Heat Pump Water Heater Certifications and Markings The verification has been performed with reference to the following technical standards: UNI EN 16147; EN 12102; EN 60335-1; EN 60335-2-21; EN 60335-2-40; EN 55014-1; EN 55014-2; EN 61000-3-2; EN 61000-3-3;... -
Page 7: Measuring
Cool Energy EcoStore Heat Pump Water Heater Measuring The measuring units used in this manual for the relevant physical magnitudes are those of the International System(SI). Temperature unit shift Press ENTER for 3 seconds to unlock the buttons. Pressing the E-HEATER key for 10 seconds they can shift the temperature from display unit from ‘°F’... -
Page 8: Energy Efficiency
Cool Energy EcoStore Heat Pump Water Heater vaporized refrigerant fluid switches back to the liquid state as a consequence of thermal dissipation. The liquid refrigerant, flowing through a choking component (expansion valve), undergoes a low pressure expansion and, after returning to the evaporator, it can again draw heat from the surrounding environment. -
Page 9: Main Components
Cool Energy EcoStore Heat Pump Water Heater Using renewable energies and ensuring optimum energy efficiency, the heat pump provides an environment-friendly and efficient solution to heat water throughout the year. Main components 2.4.1 Tank The tank consists of a water-tight Stainless Steel AISI316L cylindrical inner vessel. -
Page 10: Thermal Insulation And Coating
Cool Energy EcoStore Heat Pump Water Heater Positioning fastening, connection and maintenance operations must be performed when the device is not powered. Be sure that the device has a proper position, far away from water, direct heat sources, etc. Do not open the container of the device, inside there are no spare parts. -
Page 11: Technical Data Table
Cool Energy EcoStore Heat Pump Water Heater Technical data table Model EcoStore 200 EcoStore 300 Type Air Source Heat Pump Water Heater Ԩ Temp. Standard 55°C ( 38°C bis ~ 65°C) (DIN 4753) AISI 316 / EN Storage material 1.4404... -
Page 12: Installation And First Start-Up
Cool Energy EcoStore Heat Pump Water Heater INSTALLATION AND FIRST START-UP (qualified personnel only) CAUTION! • The installation room must be 20 m or larger and have suitable air exchange and not be subject to sub zero conditions. • The equipment must be installed in compliance with the national installation regulations. -
Page 13: Hydraulic Safety Unit
Cool Energy EcoStore Heat Pump Water Heater 3.1.1 Hydraulic safety unit (mandatory) You must install a hydraulic safety unit (Supplied in G3 Kit) complying with EN 1487 or with equivalent local standards in force; • Check valve; • Check valve control device;... -
Page 14: Duct
Cool Energy EcoStore Heat Pump Water Heater • check that there are no leaks from the various hydraulic connections; N ote****** We recommend that you flush the pipes before connecting the unit Only proceed with the electrical connection after performing this operation... -
Page 15: Electrical Connection
Cool Energy EcoStore Heat Pump Water Heater Electrical connection WARNING: T he equipment is already factory-wired and is equipped with a plug for the c onnection to an outlet having appropriate electrical characteristics. V erify that the mains voltage complies with the value specified in the label applied on the e quipment, and that the mains can supply a sutable pressure and flow. - Page 16 Cool Energy EcoStore Heat Pump Water Heater Water Temperature setting 15 | P a g e...
-
Page 17: Operations Before Turning On The Product
Cool Energy EcoStore Heat Pump Water Heater Operating instructions 4.3.1 Operations before turning on the product • When the product is turned on for the first time, all indicators on the UI will turn on for 3 seconds, and in the same time an acoustic sound will be heard. After a minute without any other operation, all buttons are blocked apart from UNLOCK button. -
Page 18: Basic Function
Cool Energy EcoStore Heat Pump Water Heater running of the heat pump. • Defrosting during water-heating. In heat pump running period, if the evaporator frosted in lower ambient temperature, the system will defrost automatically to keep effective performance(circa 3~10 min.). At defrosting time, the fan motor will stop, but compressor will still run. -
Page 19: Query Function
Cool Energy EcoStore Heat Pump Water Heater 4.4.5 Query function For the convenience of maintenance and debug, query function is available by Press 2 buttons together. , then system running parameters will be shown one by one with following sequence by each pushing of “... -
Page 20: Setting
Cool Energy EcoStore Heat Pump Water Heater Setting 4.5.1 Temperature setting The temperature displayed is the water temperature in the upper part of tank. Method for temperature set: Press the button increase the temperature, press the button to decrease. Confirm setting. - Page 21 Cool Energy EcoStore Heat Pump Water Heater Method for timer set: Enter timer setting. Select timer ( )which needs to be set. The timer icon will flash slowly if it is selected. Confirm the selected setting timer. Then will be lightened. Then the hour value of timer will flash slowly.
-
Page 22: Cancel
Cool Energy EcoStore Heat Pump Water Heater Method for cancel timer setting: Enter timer setting. Select timer ( )which needs to be cancel. The timer icon will flash slowly if it is selected. Confirm to cancel the timer. Then repeat selecting timer and cancelling. -
Page 23: Disinfect Mode
Cool Energy EcoStore Heat Pump Water Heater 4.5.5 Disinfect mode Manually turn on disinfect function: Icon will flash Confirm manually activate disinfection function, then the unit will heat up water to 65°C at least for disinfection. Disinfect Clock Setting: Press button for 3 sec. -
Page 24: Vacation Mode
Cool Energy EcoStore Heat Pump Water Heater 4.5.6 Vacation mode Method for Vacation mode setting: Enter Vacation setting. Icon will flash. Icon will be lightened. will show the last setting vacation days. Set vacation days. The days range is 1~99 days. -
Page 25: Error
Cool Energy EcoStore Heat Pump Water Heater Error If some errors happen, the buzzer will buzz 3 times every other minute. Press for 1 sec to stop the buzzer but the alarm icon will keep glittering. When an error is verified, although in some conditions it may function, it cannot reach the expected efficiency. - Page 26 Cool Energy EcoStore Heat Pump Water Heater Electric leakage error Maybe some wires have been broken or If PCB current_induction_circuit check bad wire connection. the current difference between L,N Contact a qualified person to service the 14mA, system consider it as "electric unit.
-
Page 27: Faq
Cool Energy EcoStore Heat Pump Water Heater When the ambient temp T4 is out of Heat Pump running range (-7~43 °C ) Heat Pump will stop, unit will show LA It is normal, and no necessary to repair. on the position of clock on display until T4 back to (-7~ 43 °C ). -
Page 28: Hydraulic Safety Unit Efficiency Check
Cool Energy EcoStore Heat Pump Water Heater 4.11 Hydraulic safety unit efficiency check The hydraulic unit efficiency is very important to prevent any overpressures inside the tank (that would damage it), and allows the user to safely operate the equipment. Periodically check the efficiency of the hydraulic safety unit, according to the instructions provided by the manufacturer. -
Page 29: Alse Errors Of Operpation
Cool Energy EcoStore Heat Pump Water Heater False errors of operation • Due to a start caused by a voltage fall, you must wait 3 minutes before the reactivation of the compressor, in order to preserve its integrity. • If the auto protection is activated and the system stops, control that: - When the supply indicator is on, if the system is being forced to function even without the normal operative conditions;... -
Page 30: Water Circuit / Condensate Discharge
Cool Energy EcoStore Heat Pump Water Heater Lift the filter and clean it from possible impurities. Put again the cleaned filter and the opening before restart the equipment. Water circuit / Condensate discharge The water circuit check is limited to the integrated filter installed by the customer (if any; in this case follow the instructions provided by the valve manufacturer);... -
Page 31: Anode Verification
Cool Energy EcoStore Heat Pump Water Heater For a correct and competent maintenance, it is necessary to evacuate/ leak the refrigerator circuit ( draining and filling)! Anode verification (periodic) The device is protected against corrosion by an electronic anticorrosion anode for protection against the effects of spurious currents that could damage it. -
Page 32: Replace And/Or Control The Electrical Resistance
Cool Energy EcoStore Heat Pump Water Heater Procedure: • Switch off the device; • Disconnect the device from electric current • Clear out the device (see par. 4.12) until the water level is lower than the height of anode junction;... -
Page 33: Outside Cleaning
Cool Energy EcoStore Heat Pump Water Heater • Restore the connection to the electric supply; • Restart the boiler. 5.11 Outside cleaning For the cleaning of the outer shell only use soapy solutions, absolutely avoiding abrasive products containing organic thinners (alcohol, benzine, etc.). - Page 34 Cool Energy EcoStore Heat Pump Water Heater The limestone deposits on the resistance cause an irregular and violent thermic change in The electrical resistance Hard water grade is anomalous. those places where the makes noises. Water with lot of limestone.
-
Page 35: Installation Examples
Cool Energy EcoStore Heat Pump Water Heater Fig. 2 – Maintenance space requirements (unit: mm) Fig. 3 – Hydraulic connection diagram – Hot Water Only 34 | P a g e... -
Page 36: Commissioning Sheet And Service Record
Cool Energy EcoStore Heat Pump Water Heater Fig. 4 - Hydraulic connection diagram – Second Heat Source 35 | P a g e... - Page 37 Cool Energy EcoStore Heat Pump Water Heater Fig. 4 - Hydraulic connection diagram – Twin Coil Circuits SYMBOL LEGEND Interception valve Interception valve with retain device Pressure reduction Thermometer Manometer Condenses pipe Drain tap Safety valve Leak valve Pump Timer...
- Page 38 Cool Energy EcoStore Heat Pump Water Heater Fig. 6 - Duct A: Without duct B: Air outlet withput canvas, air inlet connect to duct (A≤5m) C: Air inlet and outlet with D: Air outlet connect to canvas, air duct (A+B ≤ 5m) inlet without duct (A≤5m)
- Page 39 Cool Energy EcoStore Heat Pump Water Heater Fig. 7 – Possible solutions when using the heat pump Heat pump for hot water without connection to air ducts Thanks to the vast range of heat pump for hot sanitary water (without, with one or two exchangers with thermic heat integration), the solar systems and other supply sources, as for example firewood heaters, can represent a further use of the environmental energy.
- Page 40 Cool Energy EcoStore Heat Pump Water Heater Heat pump for sanitary hot water with aspiration kit Heat pump for sanitary hot water with aspiration kit Heat pump for sanitary water with pellet boiler Heat pump for sanitary water with wall-mounted gas boiler...
- Page 41 Cool Energy EcoStore Heat Pump Water Heater Fig.6- Electric connection 40 | P a g e...
- Page 42 Cool Energy EcoStore Heat Pump Water Heater ELECTRICAL AND ELECTRONIC EQUIPMENT ( 2002/96/EC – ISPOSAL OF WASTE WEEE DIRECTIVE) This symbol indicates that the appliance must not be treated as domestic waste upon disposal. Rather, it must be delivered to an authorized collection centre for the recycling of electrical and electronic appliances.
- Page 43 Cool Energy EcoStore Heat Pump Water Heater 8 MAINS PRESSURE HOT WATER STORAGE SYSTEM COMMISSIONING CHECKLIST This Commissioning Checklist is to be completed in full by the competent person who commissioned the storage system as a means of demonstrating compliance with the appropriate Building Regulations and then handed to the customer to keep for future reference.
- Page 44 Cool Energy EcoStore Heat Pump Water Heater SERVICE RECORD It is recommended that your heating system is serviced regularly and that the appropriate Service Interval Record is completed. Service Provider Before completing the appropriate Service Record below, please ensure you have carried out the service as described in the manufacturer’s instructions.
- Page 45 Cool Energy EcoStore Heat Pump Water Heater Cool Energy Holding Ltd. 163 Cleethorpe Road, Grimsby, DN31 3AX. Email: s ales@coolenergyshop.com 3 0 T U U 3 0 T w ww.coolenergyshop.com 3 0 T 3 0 T 44 | P a g e...
Need help?
Do you have a question about the EcoStore Series and is the answer not in the manual?
Questions and answers