Sealey BBQ04 Instructions Manual

Thank you for purchasing a Sealey product. Manufactured to a high standard this product will, if used according to these instructions
and properly maintained, give you years of trouble free performance.
IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS.
USE THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE
DAMAGE AND/OR PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. PLEASE KEEP INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY INSTRUCTIONS
1.1. GENERAL SAFETY
WARNING! The warnings, cautions and instructions in this manual cannot cover all possible conditions and situations that

may occur. It must be understood by the operator that common sense and caution are factors which cannot be built into this
product, but must be applied by the operator.
WARNING! Hazardous fire or explosion may result if instructions are ignored.
r
WARNING! Never use a flame to do the leak test and ensure no naked flames are nearby when doing the leakage test.
r
WARNING! Accessable parts may be very hot. Keep young children and pets away.
r
WARNING! If you smell gas: turn off the gas supply at the bottle, extinguish all naked flames, do not operate any electrical
r
appliances, check for leaks as detailed in this manual. If odour persists, contact your Sealey dealer.
WARNING! Any modification to this appliance may be dangerous and is absolutely not permitted.
r
Read the instructions carefully before assembly and retain this manual for future reference.
3
Use outdoors only, stand on a level surface, remember hot fat may drip out of the drip tray
3
Handle the hot barbecue with the help of oven gloves.
3
Leak test all connections after each tank refill.
3
The barbecue should be cleaned on a regular basis. Take care not to enlarge burner ports of orifice openings when cleaning the
3
burner or valves.
Always do the gas leak check before you use the barbecue. Test the leakage on all the connections where gas passes by.
3
Connect the regulator and hose onto the gas tank and the burner, close all the valves by turning the control knobs to the "OFF" (fully
3
clockwise) position.
Put soapy water on all the connections where the gas reaches. Open the gas tank valve and regulator. If bubbles are seen, tighten the
3
connection if bubbles are still seen, close all valves, turn off the regulator and contact your Sealey dealer for help. Never use the
barbecue with a leak.
The gas leak check must be done when first connecting the barbecue and every time the gas bottle is changed.
3
The gas bottle can only be changed by a competent person.
3
The lid must always be open when lighting the burner.
3
Use oven gloves and sturdy long handled barbecue tools when cooking on the grill.
3
Be prepared if an accident or fire should occur. Know where your first aid kit and fire extinguishers are and how to use them correctly.
3
Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.
3
Ensure the appliance has completely cooled before storing.
3
DO NOT store petrol or other flammable vapours or liquids in the vicinity of this or any other appliance.
7
Any gas cylinder not connected for use should not be stored in the vicinity of this or any other appliance.
7
This gas barbecue is designed for outside use only.
7
DO NOT move the barbecue whilst it is in operation.
7
DO NOT operate if there is a gas leak.
7
DO NOT attempt to disconnect any gas fitting if your barbecue is being used, including the gas hose and regulator.
7
DO NOT leave unattended from being lit to fully cooled.
7
DO NOT use this barbecue in a garage or any enclosed area. Keep the surrounding area clear, at least 1.0m from any combustable
7
materials and 0.5m from a brick wall.
DO NOT attempt any unauthorised interference of the main controls on this barbecue, i.e. gas taps, injectors, valve etc.
7
DO NOT attempt to use charcoal in this barbecue, do use the flame tamer plate. (fits immediately above burner)
7
DO NOT position on a surface that may be damaged by hot fat or heat.
7
1.2 BARBECUE/TROLLEY STAND SAFETY
1.2.1 Be aware of finger traps when assembling as the frame is not self supporting until the barbecue module is fitted, section 4 and 6.
1.2.2 Read carefully section 6, fitting, removing, transporting and storing with barbecue module.
1.2.3 Ensure catch "Q" is engaged with local bracket when fitting barbecue module as described in 6.1.3.
1.2.4 Wear suitable gloves when handling light gauge sheet metal barbecue module.
NOTE: This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities or lack of
experience and knowledge, unless they have been given supervision or instruction concerning the use of the appliance by a person responsible
for their safety. Children should be supervised to ensure that they do not play with the appliance.
2. INTRODUCTION & SPECIFICATION
Portable gas barbecue with fitted fold out side tables. Features piezoelectric ignition, variable heat control, large single burner and chrome grill.
Wheeled stand folds into transport trolley, ideal for picnics, camping, and home use. Grill unit detaches from stand and folding legs enable its
use as a table top barbecue. Supplied with propane gas clip-on regulator. Butane regulator not supplied.
© Jack Sealey Limited 2013
MODEL: ................................................................................... BBQ04
Dimensions Standing and Open (WxDxH): ........1040 x 450 x 930mm
Cooking Area: .................................................................420 x 340mm
Gas Types .................................................................Propane, Butane
Heat Output ................................................................................ 3.9kw
Original Language Version
INSTRUCTIONS FOR
GAS BBQ PORTABLE
MODEL N : BBQ04
O
:
BBQ04 Issue: 1 - 25/02/13